Limited Warranty - Zoeller QWIK JON PREMIER 201 Installation Instructions Manual

SEE BELOW FOR LIST OF CAUTIONS
1.
This unit is not designed to handle any material other than human waste
and toilet paper. The list of items that should not be used with this
system includes, but is not limited to: feminine sanitary products,
condoms, cotton balls and swabs, baby wipes, paper towels, etc.
2. Check to be sure your power source is adequate to handle the amperage
requirements of the motor as indicated on the pump or unit I.D. tag.
3. All plumbing (discharge and carbon filter vent) must be installed to meet
local codes. Unit must be vented. Do not use an automatic plumbing
vent
4. Maximum operating temperature must not exceed 40 °C (104 °F).
5. Do not use cleaning products containing bleach in the toilet tank, toilet or
attached as they will degrade the pump seals.
6. This product is designed for use with one toilet only.
7. Conductor color coding: Type 1 - Line (Brown), Neutral (Blue), Ground
(Yellow / Green). Type 2 - Line (Black), Neutral (White), Ground (Green).
8. Electrical control box or electrical box are waterproof required.
9. Prop65 Warning for California residents: Cancer and Reproductive Harm-
www.P65Warnings.ca.gov.
Manufacturer warrants, to the purchaser and subsequent owner during
the warranty period, every new product to be free from defects in materi-
al and workmanship under normal use and service, when properly used
and maintained, for a period of two years from date of purchase by the
end user, that inspections determine to be defective. Proof of purchase
is required. Inspections determine to be defective in material or
workmanship, will be repaired, replaced or remanufactured at Manufac-
turer's option, provided however, that by so doing we will not be obligat-
ed to replace an entire assembly, the entire mechanism or the complete
unit. Fill and flush mechanism are guaranteed as per OEM warranty only
and vitreous china are guaranteed only for a factory defect. No
allowance will be made for shipping charges, damages, labor or other
charges that may occur due to product failure, repair or replacement.
This warranty does not apply to and there shall be no warranty for any
material or product that has been disassembled without prior approval of
Manufacturer, subjected to misuse, misapplication, neglect, alteration,
accident or uncontrolled weather event; that has not been installed,
operated or maintained in accordance with Manufacturer's installation
instructions; that has been exposed to outside substances including but
not limited to the following: sand, gravel, cement, mud tar, hydrocar-
bons, hydrocarbon derivatives (oil, gasoline, solvents, etc.), or other
In instances where property damages are incurred as a result of an alleged product failure,
the property owner must retain possession of the product for investigation purpose.
HELPFUL HINTS FOR EASY INSTALLATION
1. Read all instructions before beginning installation.
2. Be sure the floor is level within 3 mm (1/8").
3. Install vent pipe seal with flange side of seal on the outside of lid.
4. Use soapy water to lubricate all seals to aid installation.
5. Install rubber coupling/union in vent line to aid disassembly.
6. Do not over torque toilet mounting screws.
7. Do not use an automatic plumbing vent device.
8. Obtain model number and date code, and record information in the
space provided on the front of this manual. Refer to this information
when calling the factory.
DO'S AND DON'T'S FOR INSTALLING A UNIT
1. DO read all installation material with the unit.
2. DO inspect unit for any visible damage caused by shipping.
Contact dealer if unit appears to be damaged.
1. Repair and service should be performed by an Authorized Service and
Warrenty Center only. (Consult Factory.)
2. Note: Consult Factory if installation is above 7.6 m (25') vertical height in DN25
(1") pipe. The grinder pump is designed for use in Qwik Jon
only. It is not designed for use in any other application.
3. Pumps with the "cCSAus" mark
UL778.
C22.2 No.108.
4. All

LIMITED WARRANTY

abrasive or corrosive substances, wash towels or any other abusive
entity, etc. in all pumping applications. The warranty set out in the
paragraph above is in lieu of all other warranties expressed or implied;
and we do not authorize any representative or other person to assume
for us any other liability in connection with our products.
Contact authorized distributors to obtain any needed repair or replacement
of part(s) or additional information pertaining to our warranty.
MANUFACTURER EXPRESSLY DISCLAIMS LIABILITY FOR
SPECIAL, CONSEQUENTIAL OR INCIDENTAL DAMAGES OR
BREACH OF EXPRESSED OR IMPLIED WARRANTY; AND
ANY IMPLIED WARRANTY OF FITNESS FOR A PARTICULAR
PURPOSE AND OF MERCHANTABILITY SHALL BE LIMITED
TO THE DURATION OF THE EXPRESSED WARRANTY.
Some jurisdictions do not allow limitations on the duration of an implied
warranty, so the above limitation may not apply to you. Some jurisdic-
tions do not allow the exclusion or limitation of incidental or consequen-
tial damages, so the above limitation or exclusion may not apply to you.
This warranty gives you specific legal rights and you may also have
other rights which vary from jurisdiction to jurisdiction.
3. DO clean all visible debris from the unit.
4. DO always disconnect pump from power source before handling.
5. DO install a ball or gate valve and a union in the discharge line
6. DO test pump immediately after installation to be sure that the system
7. DO review all applicable local and national codes and verify that the
8. We DO NOT recommend this product be connected to utilities other than
9. DO inspect and test system for proper operations at least every 3 months.
®
© Copyright 2022 Zoeller Co. All rights reserved.
- 2 -
NOTES
SEE BELOW FOR LIST OF NOTES
and/or the "US" mark are tested to UL Standard
Pumps with the "cCSAus" mark
connecting to the system must be on the same
DO'S AND DON'T'S,
DO always connect to a separately protected and properly grounded
ground fault protected circuit. DO NOT ever cut, splice or damage
power cord. DO NOT carry or lift pump by its power cord. DO NOT
use an extension cord.
downstream of the check valve.
is working properly.
installation conforms to each of them.
those found in a normal bathroom application. Washing machines and
dishwashers are examples of equipment that we DO NOT recommend.
® Premier units
are to CSA Standard
level.
continued