Mono FG149 Installation And Operation Manual
  1. Manuals
  2. Brands
  3. Mono Manuals
  4. Oven
  5. FG149
  6. Installation and operation manual

Mono FG149 Installation And Operation Manual

Hide thumbs Also See for FG149:
Table of Contents

Advertisement

Quick Links

www.monoequip.com
Installation and Operation Manual
FG0BX-UK-MAN-0200 | Rev. A21 (July 2021)
Oven Serial Number _________________________________
Oven Code
149
Condenser Serial Number ____________________________ (if fitted)
In the event of an enquiry, please quote these serial numbers.
Bx OVEN
Eco-connect
150
153
158
159
170
4/5/10-Tray | Steam

Advertisement

Table of Contents
loading

Related Manuals for Mono FG149

Summary of Contents for Mono FG149

  • Page 1 Oven Serial Number _________________________________ Oven Code www.monoequip.com Condenser Serial Number ____________________________ (if fitted) In the event of an enquiry, please quote these serial numbers. Bx OVEN Eco-connect Installation and Operation Manual 4/5/10-Tray | Steam FG0BX-UK-MAN-0200 | Rev. A21 (July 2021)
  • Page 2 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual MONO FG0BX-UK-MAN-0200 | Rev. A21 (July 2021)
  • Page 3 Installation and Operation Manual MONO Bx Eco-connect Ovens ATTENTION If oven fails to heat up, when first connected to a power supply or during use at any time, press the reset buttons located on the rear back panel. (Do not remove the back panel)
  • Page 4 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Safety symbols The following safety symbols are used throughout this document and manual (available at www.monoequip.com). Before using your new equipment, read the instruction manual carefully and pay special attention to information...
  • Page 5 Installation and Operation Manual MONO Bx Eco-connect Ovens Electrical safety and advice regarding supplementary electrical protection Commercial kitchens and food service areas are environments where electrical appliances may be located close to liquids or operate in and around damp conditions or where the restricted movement for installation and service is evident.

  • Page 6: Table Of Contents

    MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Contents Page 1. Introduction ......................8 2. Specifications ......................10 Mechanical specifications ........................10 Electrical specifications ........................10 3. Safety ........................11 4. Installation ....................... 12 Power ..............................12 Water ..............................
  • Page 7 Installation and Operation Manual MONO Bx Eco-connect Ovens 8. Cleaning ........................49 Daily cleaning instructions ........................49 Weekly cleaning instructions ........................ 49 9. Maintenance ......................54 General maintenance ........................... 54 Steam system maintenance ......................... 54 Light bulb replacement ......................... 54 10.

  • Page 8: Introduction

    “A combination of clean industrial design and the latest technology.”  The MONO BX oven range is designed to take the baking Industry’s standard trays.  Ovens in the range are of stainless steel construction and selected models have removable tray racks to aid cleaning.
  • Page 9 Installation and Operation Manual MONO Bx Eco-connect Ovens Figure 1: BX oven features Power on/off switch Identification / Serial number plate. Touchscreen Damper flue – do not cover the flue Figure 2: Optional condenser FG0BX-UK-MAN-0200 | Rev. A21 (July 2021)

  • Page 10: Specifications

    MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual 2. Specifications Mechanical specifications Table 1: Mechanical specifications 4/5-trays oven 10-trays oven FG159 FG153 FG158 FG150 FG149 FG170 18 in. 40 cm 60 cm 18 in. 40 cm 40 cm Tray size 30 in.

  • Page 11: Safety

    Do not attempt any repairs.  Contact the Mono Service Department for advice.  Fit only MONO spare parts to this oven.  All connections to the oven must comply with the statuary requirements of the country of installation. ...

  • Page 12: Installation

    MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual 4. Installation Power Warning!  A 30mA Residual Current Device (RCD) must protect the supply to this machine.  Always fit a wall isolator to isolate the oven completely. The isolator must be visible, labelled clearly, and easily accessible by an operator.

  • Page 13: Water

    Allow a 50 mm gap at the sides and rear of this oven.  Chimneys and evacuation ducts fitted above mono ovens should be insulated. Before use In the interests of hygiene, we strongly recommend that, before using the oven for the first time, you wipe the inside of the oven and all accessories thoroughly with a clean cloth soaked in warm soapy water.

  • Page 14: Ambient Working Temperatures

    It is the customers’ sole responsibility to arrange for adequate ventilation. Any component malfunctioning during the guarantee period found to have been subject to excessive humidity or ambient working temperature above 40 °C (115 °F) will not be covered by the component manufacturer guarantee or MONO’s product warranty. MONO...

  • Page 15: Isolation

    Installation and Operation Manual MONO Bx Eco-connect Ovens 5. Isolation Electrical supply To stop the oven in an emergency, switch off the electricity at the wall isolator. Water supply In an emergency, shut off the water supply to stacked ovens by closing the shut-off valves...

  • Page 16: Touchscreen Operations

    MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual 6. Touchscreen Operations Operations are performed by touching an area of the screen, bringing up the next information panel or activating a function.  Caution! Do not use excessive force to operate the touchscreen panel...

  • Page 17: Starting And Operating Using Ready-Made Recipes (Programs)

    Installation and Operation Manual MONO Bx Eco-connect Ovens Starting and operating using ready-made recipes (programs) Ensure the power and water supplies are safely connected to the oven (see Installation on page 11). If the display (A) is blank, press the green power button (B) at the bottom of the front panel.
  • Page 18 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Touch the Programs tile on the Choose an option screen. Select a product category. (a) Touch the scroll up and down buttons to change category pages.  The Back button returns the display to show the Choose an option screen.
  • Page 19 Installation and Operation Manual MONO Bx Eco-connect Ovens A baking screen now appears. (a) Wait while the oven heats up. A Heating message flashes on the screen. (b) Load the oven with products when Ready flashes on the screen. (c) Touch Start to begin baking.
  • Page 20 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual During a bake, two actions can be performed.  Touch the View button to view settings during a bake.  Touch the numbered square (e.g., 2) to view the settings for different baking phases.

  • Page 21: Manual Bake (No Program Mode)

    Installation and Operation Manual MONO Bx Eco-connect Ovens Manual bake (no program mode) 1. Touch the Manual Bake tile. 2. Set the temperature required. (a) Touch the Temperature circle. (b) Key in the temperature required. (c) Touch the OK () button.
  • Page 22 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual 4. Load the oven with products and touch Start.  The timer counts down from a set time to 00:00 or counts upwards if no time set. 5. Use the steam and damper functions when needed.

  • Page 23: Setting The Time And Date

    Installation and Operation Manual MONO Bx Eco-connect Ovens Setting the time and date Touch the Settings tile. Enter the Oven Settings password, and then touch the OK () button. Note Default passwords for the various access levels are in the Passwords section of this manual. However, for security reasons, the passwords section may have been removed.
  • Page 24 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Touch the item that needs adjusting, and then use the up or down arrows as required.  The time, date, month, and year can be adjusted.  The day is not adjustable – it automatically updates using the date, month, and year.

  • Page 25: Setting Up A New Program

    Installation and Operation Manual MONO Bx Eco-connect Ovens Setting up a new program Touch the Programs tile. Choose the category or number group required. Touch the Info (i) button of the next free recipe slot. Touch the Options button. FG0BX-UK-MAN-0200 | Rev. A21 (July 2021)
  • Page 26 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Enter the Operator password and touch OK. Note Default passwords for the various access levels are in the Passwords section of this manual. However, for security reasons, the passwords section may have been removed.
  • Page 27 Installation and Operation Manual MONO Bx Eco-connect Ovens Edit a tray layout for the new product recipe. (a) Touch the Change tray layout box (b) Touch the W (width) box to highlight it. (c) Use the up or down arrow key to change quantity across the tray.

  • Page 28: Multi Bake Operation

    MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Multi bake operation Touch the Multi Bake tile. Set a timer Touch a time-setting box. Adjust the bake time required using up and down keys. Touch the OK () button.
  • Page 29 Installation and Operation Manual MONO Bx Eco-connect Ovens Set the temperature for the bakes (a) Touch a heat-setting box. (b) Type in temperature required. (c) Touch OK to confirm the temperature. Start the bake. (a) Load the oven. (b) Touch the Start button (next to the bake time required).
  • Page 30 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual The panel flashes when a bake finishes, and the oven emits a beep-beep alarm. Touch the Stop button next to the 00:00 time. 10. Touch the Stop button at any time to end a bake, and the same settings are useable again.

  • Page 31: 7-Day Timer

    Installation and Operation Manual MONO Bx Eco-connect Ovens 7–Day Timer While the oven is in standby mode, it can heat up at pre-set times every day as required. Touch the 7 Day Timer tile. Touch the day an oven operation is required.
  • Page 32 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Set the Off-time. (a) Touch the Off tile of a time panel. (b) Set the time using the keys in the box that appears, and then touch Save (A).

  • Page 33: Putting The Oven Into Standby Mode

    Installation and Operation Manual MONO Bx Eco-connect Ovens Putting the oven into Standby mode The Standby button turns the oven off until the screen is touched again. Putting the oven into Sleep mode If enabled in the oven settings, the Sleep button instructs the oven to maintain temperature to a pre-set value.

  • Page 34: User Settings (Oven Setup)

    MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual User settings (oven setup) Caution!  Do not make changes to settings unless you are fully aware of the results. Touch the Settings tile. Enter the Oven Settings password, and then touch OK.
  • Page 35 Installation and Operation Manual MONO Bx Eco-connect Ovens Touch the Left Arrow and Right Arrow buttons to access the pages of oven settings. Page 1 Page 3 Page 2 5. To make an adjustment, touch the item and change the setting.
  • Page 36 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Table 3: Oven settings explained (general level) Temperature Units Centigrade (Celsius) or Fahrenheit. Sleep Mode Delay Oven will go into sleep mode after the set minutes, providing it is up to temperature and has been through at least one bake cycle.

  • Page 37: Factory Settings (Oven Setup)

    Installation and Operation Manual MONO Bx Eco-connect Ovens Factory settings (oven setup) Caution!  Do not make changes to settings unless you are fully aware of the results. Touch the Settings tile. Enter the Oven Settings password, and then touch OK.
  • Page 38 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Enter the High Level Settings password, and then touch OK. Touch the Factory settings box (B). Touch the Left Arrow and Right Arrow buttons to access the pages of oven settings.

  • Page 39: Changing The Passwords

    Installation and Operation Manual MONO Bx Eco-connect Ovens 7. To make an adjustment, touch the item and edit a new setting. 8. Touch the Save () when the oven settings are as required. Changing the passwords Touch the Settings tile.
  • Page 40 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Enter the High Level Settings password, and then touch OK. 5. Touch the password level you want to change (e.g., user password). 6. Change the password. Touch the Old Password box, and enter the current password.

  • Page 41: Diagnostics

    Installation and Operation Manual MONO Bx Eco-connect Ovens Diagnostics The operation of the following items can be checked from the diagnostics screen: Door switch operation Fan forward Lights on/off    Fan overload Fan reverse Canopy   ...
  • Page 42 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Using the diagnostics screen 1. Touch the item to be tested (e.g., Light)  The red square changes to a green square (E). 2. Touch the same item again to end the test.

  • Page 43: Using The Usb Port

    Installation and Operation Manual MONO Bx Eco-connect Ovens 7. Using the USB Port Using the USB port to import recipes Importing a recipe archive to an oven without IoT firmware installed Insert a USB flash drive into the USB socket.
  • Page 44 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Touch the High Level Settings box on the main options screen. Enter the High Level Settings password, and then touch OK. Touch the Down Arrow button (C) to display the next page of high-level settings.
  • Page 45 Installation and Operation Manual MONO Bx Eco-connect Ovens Touch the recipe archive required (F), and then touch the Upload () button. 10. Touch Yes when a pop-up window (G) warns about deleting all current recipes from the oven. 11. Wait for the Operation Completed window to be displayed, and then touch OK (H).
  • Page 46 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Importing a recipe archive to an oven with IoT firmware installed Insert a USB flash drive into the USB socket.  Do not force the flash drive into the socket. It only fits in one way.
  • Page 47 Installation and Operation Manual MONO Bx Eco-connect Ovens Touch the High Level Settings box on the main options screen. Enter the High Level Settings password, and then touch OK. Touch the Import From USB box (C). Touch the Upload Recipes box (D).
  • Page 48 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Touch the recipe archive required (E), and then touch the Save () button. 10. Touch Yes when a pop-up window (F) warns about applying the archive.  All current recipes are deleted from the oven and replaced by the uploaded ones.

  • Page 49: Cleaning

    Installation and Operation Manual MONO Bx Eco-connect Ovens 8. Cleaning Warning!  Isolate the oven from the mains supply and allow time to cool before cleaning. Warning! Do not remove the rear panelling inside the oven. That panel  provides access to the fan assembly, which is not safety interlocked and could cause serious injury.
  • Page 50 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Additional cleaning for ovens with 60 cm x 40 cm trays (FG156 2-tray / FG158 4-tray) Open the oven door. Lift and unlatch the internal racking. Remove the internal racking from the sides of the oven...
  • Page 51 Installation and Operation Manual MONO Bx Eco-connect Ovens Figure 7: Removing and installing a runner rack A. Top pin slots B. Bottom pin slots C. Instructions in Figure 8 viewed from this direction and shows the left-hand rack. 4T = 4-trays side 5T = 5-trays side FG0BX-UK-MAN-0200 | Rev.
  • Page 52 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Figure 8: Installing a runner rack (left-hand side shown) A. Place slots nearest oven wall over top pins B. Swing rack into line up bottom slots with bottom pins C.
  • Page 53 Installation and Operation Manual MONO Bx Eco-connect Ovens Figure 9: Check for the correct number of runners on the left and right sides A. 4-tray runners B. 5-tray runners FG0BX-UK-MAN-0200 | Rev. A21 (July 2021) MONO...

  • Page 54: Maintenance

    MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual 9. Maintenance General maintenance  Check for frayed or bare cables.  Do not use the machine if frayed or bare cables are visible. Follow cleaning instructions (see Cleaning on page 48).
  • Page 55 Installation and Operation Manual MONO Bx Eco-connect Ovens Take the frame (B), glass (C) and gasket (D) off the lamp unit. Remove the light bulb (E) by pulling in the direction of the arrow. Replace it with a new light bulb.

  • Page 56: Spares Information

    MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual 10. Spares When ordering the spares, please quote the machine serial number as found on the silver information plate of the machine and on the front cover of this manual.
  • Page 57 Installation and Operation Manual MONO Bx Eco-connect Ovens PART 1 10 TRAY OVEN SPARES SECTION FG150 SECTION 3 COOLING FAN AND DAMPER SECTION 5 BAKING CHAMBER AND DOOR PARTS SECTION 4 WATER SYSTEM SECTION 2 MAIN PANEL SECTION 1 MOTORS AND ELEMENTS REAR VIEW WITH OUTER SHEETING REMOVED FG0BX-UK-MAN-0200 | Rev.
  • Page 58 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual PART 1 / SECTION 1 – 10 TRAY - MOTORS AND ELEMENTS FG150 8 Kw ovens HEATING ELEMENT – B847-04-068 = 240 volts B847-04-073 = 220 volts PART 30 7 Kw ovens HEATING ELEMENT –...
  • Page 59 Installation and Operation Manual MONO Bx Eco-connect Ovens PART 1 / SECTION 1 – 10 TRAY - MOTORS AND ELEMENTS FG150 PART 21 OVERHEAT THERMOSTAT – B888-30-014 MOTOR AND ELEMENT CONNECTIONS PART NUMBERS REFER TO DRAWING M1500E25-75100 IN ELECTRICAL MANUAL FG0BX-UK-MAN-0200 | Rev.
  • Page 60 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual PART 1 / SECTION 2 – 10 TRAY - MAIN PANEL FG150 PT-4A FAN MOTOR OVERLOAD B801-03-020 PT4B FAN MOTOR OVERLOAD AUX. CONTACTOR B801-14-012 PT-5A FAN MOTOR OVERLOAD B801-03-020 PT5B FAN MOTOR OVERLOAD AUX.
  • Page 61 Installation and Operation Manual MONO Bx Eco-connect Ovens PART 1 / SECTION 3 – 10 TRAY - COOLING FAN AND DAMPER FG150 DAMPER BRACKET 150-02-01000 PART 34 REAR FAN UNIT B869-75-018 PART 37 AUX. POWER OUTLET FUSE B842-85-039 PART 35...
  • Page 62 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual PART 1 / SECTION 4 – 10 TRAY – WATER/STEAM SYSTEM FG150 DELIVERY PIPE - LONG 150-07-00800 DELIVERY PIPE - SHORT 150-07-00700 PART 20 WATER SOLENOID (INC. HOSES) 150-07-00400 HOSE –...
  • Page 63 Installation and Operation Manual MONO Bx Eco-connect Ovens PART 1 / SECTION 4 – 10 TRAY – WATER/STEAM SYSTEM FG150 BULKHEAD COUPLING EQUAL ELBOW A900-34-321 A900-34-387 JOINT TUBE 150-07-00900 DELIVERY PIPE 150-07-00500 DELIVERY PIPE - LONG 150-07-00800 DELIVERY PIPE - SHORT...
  • Page 64 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual PART 1 / SECTION 5 – 10 TRAY - BAKING CHAMBER AND DOOR PARTS FG150 TOP HINGE LH OVEN PT No.150-03-05400 TOP HINGE RH OVEN PT No.150-03-04700 DOOR SEAL PT No.150-03-02500...
  • Page 65 Installation and Operation Manual MONO Bx Eco-connect Ovens PART 1 / SECTION 5 – 10 TRAY - BAKING CHAMBER AND DOOR PARTS FG150 LIGHT ASSEMBLY PT No.B721-67-011 INDIVIDUAL LIGHT ASSEMBLY PARTS AVAILABLE AS BELOW GASKET GLASS AND FRAME REPLACEMENT BULB Pt.
  • Page 66 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual PART 2 4/5 TRAY 18 X 30 OVEN SPARES SECTION FG159 SECTION 1 SECTION 3 MOTOR AND ELEMENT DAMPER SECTION 4 WATER SYSTEM SECTION 2 SECTION 5 MAIN PANEL...
  • Page 67 Installation and Operation Manual MONO Bx Eco-connect Ovens PART 2 / SECTION 1 – 4/5 TRAY 18 X 30 – MOTOR AND ELEMENT FG159 PART 10 FAN MOTOR UNIT – B720-74-005 PART 11 HEATING ELEMENT – B847-04-068 = 240volts B847-04-073 = 220volts PART NUMBERS REFER TO DRAWING M159E25-75000 IN ELECTRICAL MANUAL FG0BX-UK-MAN-0200 | Rev.
  • Page 68 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual PART 2 / SECTION 2 – 4/5 TRAY 18 X 30 – MAIN PANEL FG159 PART 2a PART 27 LIGHT RELAY B723-37-004 FAN FUSE B842-85-025 PART 2b PART 3 LIGHT RELAY BASE CONTROL CIRCUIT MCB –...
  • Page 69 Installation and Operation Manual MONO Bx Eco-connect Ovens PART 2 / SECTION 3 – 4/5 TRAY 18 X 30 – DAMPER FG159 PART 9 DAMPER SOLENOID L/H OVEN B749-83-003 DAMPER SOLENOID R/H OVEN B749-83-004 DAMPER SOLENOID BRKT 158-02-00300 COUPLING 158-02-00600 PART NUMBERS REFER TO DRAWING M159E25-75000 IN ELECTRICAL MANUAL FG0BX-UK-MAN-0200 | Rev.
  • Page 70 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual PART 2 / SECTION 4 – 4/5 TRAY 18 X 30 – WATER/STEAM SYSTEM FG159 BULKHEAD COUPLING A900-34-321 (UNDER INSULATION) COPPER PIPE A900-34-253 (10mm OD X 20 swg) HOSE – BLUE...
  • Page 71 Installation and Operation Manual MONO Bx Eco-connect Ovens PART 2 / SECTION 4 – 4/5 TRAY 18 X 30 – WATER/STEAM SYSTEM FG159 EQUAL ELBOW A900-34-387 PIPE GUIDE BRACKET INDIVIDUAL PART NUMBERS ARE 150-01-07700 NOT AVAILABLE FOR PIPES. ALL PIPES MADE FROM...
  • Page 72 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual PART 2 / SECTION 5 – 4/5 TRAY 18 X 30 BAKING CHAMBER AND DOOR PARTS FG159 TOP HINGE LH OVEN PT No.158-03-10501 TOP HINGE RH OVEN PT No.158-03-10500 DOOR SEAL PT No.159-03-01500...
  • Page 73 Installation and Operation Manual MONO Bx Eco-connect Ovens PART 2 / SECTION 5 – 4/5 TRAY 18 X 30 BAKING CHAMBER AND DOOR PARTS FG159 LIGHT ASSEMBLY PT No.B721-67-011 INDIVIDUAL LIGHT ASSEMBLY PARTS AVAILABLE AS BELOW GASKET GLASS AND FRAME REPLACEMENT BULB = B857-94-007 Pt No.B721-67-008...
  • Page 74 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual PART 3 4/5 TRAY 60 X 40 OVEN SPARES SECTION FG158 SECTION 3 SECTION 1 DAMPER AND FAN MOTOR AND ELEMENT SECTION 4 WATER SYSTEM SECTION 2 SECTION 5...
  • Page 75 Installation and Operation Manual MONO Bx Eco-connect Ovens PART 3 / SECTION 1 – 4/5 TRAY 60 X 40 – MOTOR AND ELEMENT FG158 HEATING ELEMENT – B847-04-067 = 240volts PART 11 B847-04-074 = 220volts FAN MOTOR UNIT – B720-74-005...
  • Page 76 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual PART 3 / SECTION 2 – 4/5 TRAY 60 X 40 – MAIN PANEL FG158 PART 2a PART 27 LIGHT RELAY B723-37-004 FAN FUSE B842-85-025 PART 2b PART 3 LIGHT RELAY BASE CONTROL CIRCUIT MCB –...
  • Page 77 Installation and Operation Manual MONO Bx Eco-connect Ovens PART 3 / SECTION 3 – 4/5 TRAY 60 X 40 – DAMPER AND COOLING FAN FG158 PART 9 DAMPER SOLENOID L/H OVEN B749-83-003 DAMPER SOLENOID R/H OVEN B749-83-004 DAMPER SOLENOID BRKT...
  • Page 78 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual PART 3 / SECTION 4 – 4/5 TRAY 60 X 40 – WATER/STEAM SYSTEM FG158 BULKHEAD COUPLING A900-34-321 (UNDER INSULATION) COPPER PIPE A900-34-253 (10mm OD X 20 swg) HOSE – BLUE...
  • Page 79 Installation and Operation Manual MONO Bx Eco-connect Ovens PART 3 / SECTION 4 – 4/5 TRAY 60 X 40 – WATER/STEAM SYSTEM FG158 EQUAL ELBOW A900-34-387 INDIVIDUAL PART NUMBERS ARE NOT AVAILABLE FOR PIPES. PIPE GUIDE BRACKET ALL PIPES MADE FROM...
  • Page 80 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual PART 3 / SECTION 4 – 4/5 TRAY 60 X 40 BAKING CHAMBER AND DOOR PARTS FG158 TOP HINGE LH OVEN PT No.158-03-10501 TOP HINGE RH OVEN PT No.158-03-10500 DOOR SEAL PT No.158-03-01500...
  • Page 81 Installation and Operation Manual MONO Bx Eco-connect Ovens PART 3 / SECTION 4 – 4/5 TRAY 60 X 40 BAKING CHAMBER AND DOOR PARTS FG158 LIGHT ASSEMBLY PT No.B721-67-011 INDIVIDUAL LIGHT ASSEMBLY PARTS AVAILABLE AS BELOW GASKET GLASS AND FRAME REPLACEMENT BULB = B857-94-007 Pt.
  • Page 82 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual PART 4 4/5 TRAY 40 X 60 OVEN SPARES SECTION FG153 SECTION 1 SECTION 3 MOTOR AND ELEMENT DAMPER SECTION 4 WATER SYSTEM SECTION 2 MAIN PANEL SECTION 5...
  • Page 83 Installation and Operation Manual MONO Bx Eco-connect Ovens PART 4 / SECTION 1 – 4/5 TRAY 40 X 60 – MOTOR AND ELEMENT FG153 HEATING ELEMENT – B847-04-067 = 240volts PART 11 B847-04-074 = 220volts FAN MOTOR UNIT – B720-74-005...
  • Page 84 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual PART 4 / SECTION 2 – 4/5 TRAY 40 X 60 – MAIN PANEL FG153 PART 2a PART 27 LIGHT RELAY B723-37-004 FAN FUSE B842-85-025 PART 2b PART 3 LIGHT RELAY BASE CONTROL CIRCUIT MCB –...
  • Page 85 Installation and Operation Manual MONO Bx Eco-connect Ovens PART 4 / SECTION 3 – 4/5 TRAY 40 X 60 – DAMPER AND COOLING FAN FG153 PART 9 DAMPER SOLENOID L/H OVEN B749-83-003 DAMPER SOLENOID R/H OVEN B749-83-004 DAMPER SOLENOID BRKT...
  • Page 86 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual PART 4 / SECTION 4 – 4/5 TRAY 40 X 60 – WATER/STEAM SYSTEM FG153 BULKHEAD COUPLING A900-34-321 (UNDER INSULATION) COPPER PIPE A900-34-253 (10mm OD X 20 swg) PART 12 WATER INLET ASSY (INC.
  • Page 87 Installation and Operation Manual MONO Bx Eco-connect Ovens PART 4 / SECTION 4 – 4/5 TRAY 40 X 60 – WATER/STEAM SYSTEM FG153 EQUAL ELBOW A900-34-387 INDIVIDUAL PART NUMBERS ARE NOT AVAILABLE FOR PIPES. PIPE GUIDE BRACKET ALL PIPES MADE FROM...
  • Page 88 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual PART 4 / SECTION 5 – 4/5 TRAY 40 X 60 BAKING CHAMBER AND DOOR PARTS FG153 TOP HINGE LH OVEN PT No.158-03-10501 TOP HINGE RH OVEN PT No.158-03-10500 DOOR SEAL PT No.153-23-00500...
  • Page 89 Installation and Operation Manual MONO Bx Eco-connect Ovens PART 4 / SECTION 5 – 4/5 TRAY 40 X 60 BAKING CHAMBER AND DOOR PARTS FG153 LIGHT ASSEMBLY PT No.B721-67-011 INDIVIDUAL LIGHT ASSEMBLY PARTS AVAILABLE AS BELOW GASKET GLASS AND FRAME Pt No.B721-67-008...

  • Page 90: Condenser Unit (Option)

    MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual 11. Condenser Unit (Option)  All versions should be part of a regular cleaning schedule. Caution! Water should be drained and parts cleaned with an antibacterial wash. Index Introduction ..........page 91 Dimensions ..........
  • Page 91 MONO Bx Eco-connect Ovens Introduction (condenser unit) A condenser unit can be fitted to any MONO Bx oven (or stacked Bx ovens) as required. The thermostatic control can be adjusted to operate in most ambient temperatures. A simple water connection (washing machine type fitting) and a hose to drain are required to operate efficiently.
  • Page 92 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Dimensions (condenser unit) Figure 11: Dimensions of a condenser unit Water out Water in Rear of the oven MONO FG0BX-UK-MAN-0200 | Rev. A21 (July 2021)
  • Page 93 Installation and Operation Manual MONO Bx Eco-connect Ovens Specifications (condenser unit) Power  230 Vac (50 Hz), single phase  21 Watts Wired to the oven electrical panel.  Water  Washing machine type connection to the normal water supply via steam water connection to the oven(s).
  • Page 94 While the oven is in operation (and for some time after use), it is inadvisable to touch the condenser or the surrounds because of conducted heat.  No unauthorised modifications to the condenser are permitted.  Only use MONO spare parts on this condenser. MONO FG0BX-UK-MAN-0200 | Rev. A21 (July 2021)
  • Page 95 Installation and Operation Manual MONO Bx Eco-connect Ovens Installation (condenser unit) Ensure that all power is disconnected and the oven is cool. Before fitting the main condenser assembly, insert blanking plug (A) into the lower hole that will not be required for the type of oven being used.
  • Page 96 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Figure 12: Installation of a condenser unit MONO FG0BX-UK-MAN-0200 | Rev. A21 (July 2021)
  • Page 97 Installation and Operation Manual MONO Bx Eco-connect Ovens Figure 13: Water pipe connections Condenser solenoid Oven #1 Oven #2 Bracket fixings for the water tap Mains water supply inlet Tee-pipe for double oven connection FG0BX-UK-MAN-0200 | Rev. A21 (July 2021)
  • Page 98 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Operation (condenser unit) Review all safety sections in this manual. Ensure that the water is connected correctly and the oven power is on. 14). Adjust the thermostat control to the required position (Figure It is suggested that, as a starting point, the thermostat is set at 60.
  • Page 99 MONO Bx Eco-connect Ovens Spares (condenser unit) This section is for Engineer use only Do not attempt any modifications to the condenser or oven. If in doubt, contact Mono Equipment for advice. Figure 15: Main parts of the condenser unit FG0BX-UK-MAN-0200 | Rev.
  • Page 100 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Item Part number Description Quantity 150-07-01300 Inlet water control unit 150-19-01700 Top sheet 150-19-02300 Cover plate 150-19-02600 Base tray 150-19-02700 Water tank 150-25-07100 Junction box A900-01-196 Jubilee clip A900-01-271...
  • Page 101 Installation and Operation Manual MONO Bx Eco-connect Ovens Other versions of the condenser that may be fitted The following evaporation design versions could be fitted to your oven. They only require to be plugged into the socket found to the rear of the oven (Figure 16).
  • Page 102 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Figure 17: Condenser unit FG150/AC5 MONO FG0BX-UK-MAN-0200 | Rev. A21 (July 2021)
  • Page 103 Installation and Operation Manual MONO Bx Eco-connect Ovens Figure 18: Condenser assembly FG155/X38 FG0BX-UK-MAN-0200 | Rev. A21 (July 2021) MONO...
  • Page 104 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Figure 19: Condenser assembly FG158/AC1 MONO FG0BX-UK-MAN-0200 | Rev. A21 (July 2021)
  • Page 105 Installation and Operation Manual MONO Bx Eco-connect Ovens Figure 20: Reduced height condenser FG158/AC3 FG0BX-UK-MAN-0200 | Rev. A21 (July 2021) MONO...
  • Page 106 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual Figure 21: Reduced height condenser FG158/AC4 MONO FG0BX-UK-MAN-0200 | Rev. A21 (July 2021)
  • Page 107 Installation and Operation Manual MONO Bx Eco-connect Ovens Figure 22: Condenser FG159/AC1 FG0BX-UK-MAN-0200 | Rev. A21 (July 2021) MONO...

  • Page 108: Passwords

    Oven setting access – setting time/date, etc. 2413 High level settings access. Note If the passcodes have been changed and are not available, contact Mono Equipment for a master number that will open all screens. MONO FG0BX-UK-MAN-0200 | Rev. A21 (July 2021)
  • Page 109 Installation and Operation Manual MONO Bx Eco-connect Ovens (Intentional Empty Page) FG0BX-UK-MAN-0200 | Rev. A21 (July 2021) MONO...
  • Page 110 MONO Bx Eco-connect Ovens 4/5/10-Tray | Steam Installation and Operation Manual If a fault arises, please do not hesitate to contact the Customer Service Department, quoting the machine serial number on the silver information plate of the machine and on the front cover of this manual...

This manual is also suitable for:

Fg150Fg153Fg158Fg159Fg170

Table of Contents