Component Location And Replacement; Dashboard Components - Simplicity Legacy Series Service & Repair Manual

7 Electrical System Service
Location and Replacement
COMPONENT LOCATION AND
REPLACEMENT
NOTE: Most models do not require the dashboard to be
removed for component replacement or service. If it is
required, refer to Section 14, HOOD, DASH, & FOOT
REST SERVICE.
D
A
N
P
Figure 14. Dashboard Components
A Dashboard
B. Instrument Panel
C. PTO Switch
HEADLIGHT SWITCH
The headlight switch (D, Figure 14) is located in the
dashboard (A) on the left-hand side.
1. Disconnect and secure the negative battery cable,
(see Section 6, COMMON SERVICE PROCE-
DURES).
2. Unplug the wire harness (B, Figure 15) from the back
of the switch (C).
3. From behind the dashboard, push in the locking tabs
(D) and remove the switch as shown in Figure 35.
NOTE: Be careful to not press on the tabs that hold the
contact block to the switch rocker. The parts in the con-
tact block are very small and could get lost if separated.
4. Install headlight switch in reverse order of removal.
IGNITION KEY SWITCH
The ignition key switch is located in the dashboard on
the right-hand side of the steering wheel.
1. Remove the key (G, Figure 16) from the switch if not
already done so.
2. Disconnect and secure the negative battery cable,
(see Section 6, COMMON SERVICE PROCE-
DURES).
B
F
E
C
D. Headlight Switch
E. Ignition Key Switch
F. Height of Cut Switch
A
B
Figure 15. Headlight Switch Replacement
A Dashboard
B. Wire Harness
A
C
B
Figure 16. Ignition Key Switch Replacement
A Dashboard
B. Wire Harness
C. Ignition Key Switch
D. Washer
3. Unplug the wire harness (B) from the back of the igni-
tion key switch (C).
4. Remove the cap (F) using a screwdriver or pliers.
5. Remove the key switch nut (E) from the switch.
6. Remove the switch (C) from the back of the dash-
board (A).
7. Reinstall ignition key switch in reverse order of
removal.
7 - 18
C
C
C. Headlight Switch
D. Locking Tabs
E
A
D
C
E. Key Switch Nut
F. Cap
G. Keys
D
D
G
F