Table of Contents
Advertisement
S
p
tatuS anD
rogramming
A) UNIT ON/OFF
B) USER SETUP
ENTER USER PASSWORD
ENTER USER PASSWORD
0000
0000
TEMPERATURE UNIT
UNIT STATUS
ON
Celcius
000sec(s)
TEMPERATURE SETUP
SETPOINT
DRAIN TEMP.:
MAIN PAGE RETURN DELAY
02Min(s).
SYSTEM
DIGITAL
SPECS
INPUTS
SYSTEM SPECIFICATIONS
Digital Input 1
PLAN:01
Signal from interlock
Active if
System selection:
CLOSED
Pulsing valve
Control by:
Fluid temperature
SYSTEM SPECIFICATIONS
Digital Input 2
Pulses length: Scaler
Water Inlet switch
Active if
PumpON when CD is: 010%
OPEN
OutTempLW:
22.0
o
C
Delay time= 005secs.
OutTempLW band:
05.0
C
o
OutTempLW Mode:
Prop
Digital Input B5
Diff. pressure switch
Active if
OPEN
Delay time= 030secs.
Digital Input B6
Water pump disch. sw.
Active if
CLOSED
Delay time= 03secs.
Pulsing Valve
SYSTEM SPECS (LADDER)
SYSTEM SPECS (SCALER)
Demand:
LOT HOT PER
Demand:
LOT HOT PER
0%-020%
006-010/060s
0%
006-010/060s
020%-040%
014-020/060s
020%
014-020/060s
040%-060%
023-030/060s
040%
023-030/060s
060%-080%
032-040/060s
060%
032-040/060s
080%-100%
041-050/060s
080%
041-050/060s
100%
050-060/060s
100%
050-060/060s
SYSTEM SPECS (LADDER)
SYSTEM SPECS (SCALER)
Demand:
Pulse
Demand:
0%-020%
006/060s
0%
020%-040%
014/060s
020%
040%-060%
023/060s
040%
060%-080%
032/060s
060%
080%-100%
041/060s
080%
100%
050/060s
100%
COMMUNICATION SETTINGS
BMS address:001
Protocol:CAREL Local
Baudrate: 19200 baud
R
m
& S
-m
enu
ub
enuS
CONTROLLER SETUP
PROGRAMMING MENUS
C) SERVICE MENU D) FACTORY SETUP
ENTER SERVICE PASSWORD
0000
OFFSETS
00.0
o
c
Outside temp:
010.0
o
c
00.0
o
c
Fluid temp:
024.7
o
c
TEMPERATURE SETUP
28.0
o
Setpoint band:
07.0
o
c
c
06.0
o
Drain temp. band:
04.0
o
c
c
SERVICE ALARMS TIME:
Pump oil:
02000hrs
UV lights:
08000hrs
Filter:
08000hrs
Demineralizer: 00300hrs
Minimum off:
072hrs
RUN HOURS RESET
This will reset the
RUN HOURS since last
maintenance.
Choose device
FACTORY SETUP SUB-MENUS
DELAYS
DELAYS
ON/OFF:
015secs
Fact. pass. enab:
10mins
Status
Drain if no dem:
0072hs
CLOSED
Air vent valve: 030secs
Set 0.23S per feet of
5/8" pipe & 3.1 GPM.
Status
CLOSED
FEATURES/ALARMS
ENABLE/DISABLE
ENABLE ALARMS?
Status
CLOSED
Change pump oil:
Ch. water filter:
Change UV lights:
Ck. demineralizer:
Status
OPEN
Modulating Pump
SYSTEM SPECIFICATIONS
Water pump
LOT HOT
RES
Max spd: 072-082%
072%
M in spd: 040-050% 040%
Acceleration
on start:
01%/sec
Pulse
008/060s
008/060s
020/060s
031/060s
043/060s
055/060s
D
iagram
MENUS
PROGRAMMING MENU
G>VERSION INFO
A>UNIT ON/OFF
B>USER SETUP
E) ALARM HISTORY
16 : 47 : 48
2021/05/05
ENTER FACTORY PASSWORD
003:Obstr water filter
SP:
028.0
0000
Band:
07.0
Pump.
Pump valve.
Air vent val.
Drain valve.
Water treat.
FACTORY SETUP MENU
ALARMS LOGGING RESET
SYSTEM SPECIFICATIONS
DIGITAL INPUTS/OUTPUTS
FACTORY
DEVICES
RESET
RUN HOURS
FACTORY RESET
DEVICES RUN HOURS
Are you sure to reset
this device RUN HOURS
This will factory
reset the unit.
registry?
Are you sure?
Choose device
Reset
Save each:
Seconds per hour: 3600
STATUS SCREENS
16 : 47 : 48
2020/05/05
Status:OFF
OT: 010.0
C
Status:OFF
o
NO
CD:000%
FT: 024.7
o
C
CD:000%
YES
Pump status:
OFF
Pump speed:
YES
Pulsing valve:
CLOSED
Pump valve:
YES
Air vent valve:
OPEN
Air vent valve:
Drain valve:
OPEN
Drain valve:
Water treatment:
OFF
Water treatment:
PULSING VALVE-CONTROLLED
TIME SINCE LAST
MAINTENANCE
Water pump:
Water filter:
00000hrs
Water filter:
UV lights:
00000hrs
UV lights:
Demineralizer:
00000hrs
Demineralizer:
PULSING VALVE-CONTROLLED
DEVICES RUN HOURS
Water pump:
Water filter:
UV lights:
Demineralizer:
F) CLOCK
CLOCK SETTING
Clock Mode:
24h
17:06:03
2020/09/08
Set new hour 17:06
Pump: 079%
Set new date 20/09/08
OT: 010.0
yy/mm/dd
FT: 031.3
GENERAL
STATUS
16 : 47 : 48
2020/05/05
Status:OFF
OT: 010.0
o
C
CD:000%
FT: 024.7
C
o
Pump status:
OFF
Pulsing valve:
CLOSED
Air vent valve:
OPEN
12hour(s)
Drain valve:
OPEN
Water treatment:
OFF
ALARM MENU
16 : 47 : 48
2020/05/05
Water low pressure
OT: 010.0
C
o
FT: 024.7
o
C
000%
CLOSED
Water inlet low
OPEN
pressure switch
OPEN
OFF
MONDULATING PUMP
CONTROLLED
TIME SINCE LAST
MAINTENANCE
Restart water pump?
00000hrs
00000hrs
00000hrs
00000hrs
MONDULATING PUMP
CONTROLLED
000hs
000hs
000hs
000hs
G) VERSION INFO
ADIABATIC
20072114
by REFPLUS
VERS 1.4
ALARMS
LOG. RESET
ALARMS LOGGING RESET
Are you sure to reset
the alarms logging?
Reset
alarm.
activated.
Reset alarm?
11
Advertisement
Table of Contents
