Table Of Contents - Thermo Scientific ULT-80 Installation & Operation Manual

ULT 80 and ULT 95 Table of Contents
Preface
Compliance ............................................................................................... 3
WEEE/RoHS ............................................................................................ 3
After-sale Support .................................................................................... 3
Unpacking ................................................................................................. 3
Out of Box Failure ..................................................................................... 3
Warranty ................................................................................................... 3
Section I Safety
Warnings ................................................................................................... 4
Section II General Information
Description ................................................................................................ 5
Specifications ............................................................................................ 5
Section III Installation
Site ........................................................................................................... 7
Electrical Requirements ............................................................................ 8
Plumbing Requirements ............................................................................ 9
Fluids ........................................................................................................ 9
Filling Requirements .................................................................................. 9
Flow Control ........................................................................................... 10
Nitrogen Purge ........................................................................................ 10
Drain ....................................................................................................... 10
Section IV Operation
Start Up .................................................................................................. 11
Controller Keypad & Display ................................................................... 11
Changing a Value .................................................................................... 12
Controller Displays .................................................................................. 12
Operator's Loop ..................................................................................... 13
Setup Loop ............................................................................................. 13
Error Messages ...................................................................................... 16
High Temp/Low Liquid Level Safety ........................................................ 16
9-Pin Accessory Connector ..................................................................... 17
Analog Interface ..................................................................................... 18
Section V Maintenance & Troubleshooting
Service Contracts ................................................................................... 19
Cleaning .................................................................................................. 19
Rust ........................................................................................................ 19
Checklist ................................................................................................. 19
Service Assistance .................................................................................. 21
Technical Support ................................................................................... 21
ULT 95 Rear View .................................................................................. 22
ULT 95 Left Side View ............................................................................ 22
ULT 80 Right Side View .......................................................................... 23
ULT 80 Left SideView ............................................................................. 23
Additional Loops .................................................................................... 24
Calibration Loop ..................................................................................... 25
Calibration Procedure ............................................................................. 25
- 1 -