Drive And Driven Pulleys; Liquid Cooling System - BOMBARDIER Ski-Doo MX Z 600 Series Manual

Mini Z Model
Drain oil from engine. Refill crankcase with SAE
5W/30 engine oil.
Refer to Mini Z Shop Manual for proper oil change
procedure.
WARNING
This procedure must only be performed in a
well ventilated area. Do not run engine dur-
ing storage period.

DRIVE AND DRIVEN PULLEYS

Remove belt guard and slip off drive belt.
Check for physical condition of drive and driven
pulley.
Spray antirust product on pulleys (BOMBARDIER
LUBE (P/N 293 600 016)).

LIQUID COOLING SYSTEM

(if applicable)
Check coolant level in coolant tank. Replace cool-
ant if spoiled.
Check for leaks, loose clamps and general condi-
tion of hoses.
BATTERY (if applicable)
The battery must be removed from snowmobile
for storage period.
CAUTION: A poorly charged or a discharged
battery will freeze and damage its elements
and possibly damage its casing and parts sur-
rounding the battery.
Check for wiring harnesses, cables and line condi-
tion.
Disconnect the battery cables and vent tube then
remove the battery from the snowmobile.
WARNING
Always disconnect battery cables exactly in
the specified order. Disconnect BLACK neg-
ative ground cable first, then RED positive
cable.
Electrolyte Battery
Check electrolyte level. Refill as necessary with
distilled water. Fully charge battery at a maximum
rate of 2.0 A/hour.
Gases given off by a battery being charged
are highly explosive. Always charge in a well
ventilated area. Keep battery away from cig-
arettes or open flames. Avoid skin contact
with electrolyte.
Before storing the battery clean outside surface
with a solution of baking soda and water. Remove
all deposits from posts then rinse with tap water.
CAUTION: Do not allow cleaning solution to en-
ter battery interior since it will destroy the elec-
trolyte.
Dry Battery
Disconnect and remove battery from the snow-
mobile.
The battery must always be stored in fully charged
condition.
Clean battery terminals and cable connections us-
ing a wire brush.
Clean battery casing and caps using a solution of
baking soda and water. Rinse battery with clear
water and dry well using a clean cloth.
All Batteries
Coat battery posts with silicone dielectric grease
(P/N 293 550 004) or petroleum jelly.
• To prevent battery from discharging, store it on
a wooden shelf in a cool, dry place. Recharge at
least every 40 days.
TRANSMISSION/CHAINCASE
Drain then refill with proper amount of Bombardier
chaincase oil.
TRANSMISSION/CHAINCASE OIL TYPE
BOMBARDIER
SYNTHETIC OIL
(P/N 413 803 300)
(12 x 355 mL)
All models with liquid
cooled engine and all
Skandic WT models.
CAUTION: Do not use other types of oil. Do not
mix this synthetic oil with other types of oil.
Check for proper drive chain tension.
2001-12
WARNING
BOMBARDIER
MINERAL OIL
(P/N 413 801 900)
(16 x 250 mL)
All models with fan
cooled engine, except
Skandic WT models.
Page 3 of 4