General Inspection - BOMBARDIER Ski-Doo MX Z 600 Series Manual

Date: April 13, 2001
YEAR
All
GENERAL
Proper snowmobile storage is a necessity during
the summer months or when a vehicle is not being
used for more than one month.
NOTE: Refer to Storage column from LUBRI-
CATION AND MAINTENANCE ESTIMATE chart
(P/N 484 300 128) jointly with the present storage
procedure Bulletin in order to cover each and every
aspect of the snowmobile storage procedure.

GENERAL INSPECTION

Visually inspect the entire vehicle. Open the hood,
and remove any loose objects or accumulation of
dirt inside bottom pan and under engine.
NOTE: To facilitate the inspection and ensure ad-
equate lubrication of components, it is recom-
mended to clean the entire vehicle.
CAUTION: Do not use Bombardier Cleaner on de-
cals or vinyl.
Any parts found to be worn, broken or damaged,
while performing these storage procedures,
should be replaced.
LUBRICATION
WARNING
Unless otherwise specified, engine should
be turned OFF for all lubrication and mainte-
nance procedures.
Steering and Front Suspension
Lubricate the steering mechanism. Inspect all com-
ponents for tightness.
Printed in Canada (mbs-2001-014a.fm SG)
® TM Trademarks of Bombardier Inc. or its subsidiaries.
©2001 Bombardier Inc. All rights reserved.
MODEL
All
2001-12
SUBJECT: Storage Procedure
MODEL NUMBER
All
Apply BOMBARDIER LUBE (P/N 293 600 016) on
all ball joints.
Apply synthetic grease (P/N 413 711 500) on stabi-
lizer sliders, if so equipped. Lubricate also front
suspension posts and pivot arms at grease fittings.
WARNING
Do not lubricate the throttle and/or brake ca-
bles and housings. Avoid getting oil on the
brake pads.
Countershaft and Brake System
All Models without O-Rings Sealing Brake Disk
For proper operation, if so equipped, brake disc
and driven pulley must slide freely on counter-
shaft. Lubricate sparingly using anti-seize lubricant
(P/N 293 800 070).
A15D0AB
TYPICAL
1. Lubricate here
No. 2001-12
SERIAL NUMBER
All
1
Page 1 of 4