Final Steps - BOMBARDIER Ski-Doo MX Z 600 Series Manual

BODY CARE
Fabrics
To clean the entire vehicle, use only flannel cloths
or equivalent.
CAUTION: Do not use other types of fabrics on
windshield and hood to avoid further damages
to surfaces.
CAUTION: For aluminum parts use only alumi-
num cleaner and follow instructions on container.
Cleaning
Remove any dirt or rust.
NOTE: To facilitate the inspection and ensure ad-
equate lubrication of components, it is recom-
mended to clean the entire vehicle with Bombar-
dier Cleaner (P/N 293 110 001 (spray can 400 g)
and P/N 293 110 002 (4 L)).
CAUTION: Do not use Bombardier Cleaner on de-
cals or vinyl.
For vinyl and plastic parts, use Vinyl & Plastic Cleaner
(P/N 413 711 200 (6 x 1 L)).
Inspect hood and repair any damage.
To remove scratches on windshield or hood use
BOMBARDIER Scratch Remover Kit (P/N 861 774
800).
Cleaning Products
UTILITY
To clean grease.
To clean grease.
To protect metal.
To clean/repair scratches.
To clean seat, windshield and
plastic parts.
Page 4 of 4
CAUTION: Never clean plastic parts or hood with
strong detergent, degreasing agent, paint thin-
ner, acetone, products containing chlorine, etc.
Touch up all metal spots where paint has been
scratched off. Spray all metal parts including
schock chromed rods with BOMBARDIER LUBE
(P/N 293 600 016).
Wax the hood and the painted portion of the frame
for better protection.
NOTE: Apply wax on glossy finish only.

FINAL STEPS

Block air intake hole and exhaust system hole us-
ing clean cloths.
Protect the vehicle with a cover to prevent dust
accumulation during storage.
Lift rear of vehicle until track is cleared of the ground
and support with a brace or trestle.
Do not release track tension.
CAUTION: If snowmobile has to be stored out-
side it is necessary to cover it with an opaque
but ventilated tarpaulin. This will prevent sun
rays and grime from affecting plastic compo-
nents and vehicle finish.
COMPONENT
Entire snowmobile
including metallic parts.
Aluminum parts.
All metal parts.
Windshield and hood.
Vinyl and plastic parts.
2001-12
PRODUCT
Bombardier Cleaner
(P/N 293 110 001)
Dursol cleaner
BOMBARDIER LUBE
(P/N 293 600 016)
Bombardier Scratch Remover Kit
(P/N 861 774 800)
Bombardier Plastic and Vinyl Cleaner
(P/N 413 711 200 (6 x 1 L))