Final Inspection - BOMBARDIER Ski-Doo MX Z 600 Series Manual

All Batteries
Fully charge battery.
WARNING
Never charge or boost battery while installed
on vehicle.
Reinstall battery in vehicle. Refer to ELECTRICAL
section then look for Battery in appropriate Shop
Manual.
WARNING
Always connect the battery cables exactly in
the specified order. Connect RED positive ca-
ble first, then BLACK negative ground cable.
Check for proper operation of all gauges, switches
and DESS system (if applicable).

FINAL INSPECTION

Check rewind starter rope condition.
Inspect all electrical connectors and apply dielec-
tric grease (P/N 293 550 004), as required.
Inspect spark plug cables condition and proper con-
nection.
Perform engine timing according to Shop Manual
procedure.
Check headlamp, brake/taillight, gauges and pilot
lamps and electrical instruments. Replace if need-
ed.
Start engine and check for proper engine and elec-
trical operation.
Models with DPM and Air Pump
(enrichment mode)
Unplug hose coming from air pump at DPM man-
ifold.
Run engine at 3000 RPM until all liquid has es-
caped from that hose (about 2 to 3 minutes).
Reconnect hose.
All Models
Adjust headlight beam aiming.
2001-6 Page 3 of 3