7. CHIMNEY AND DRAFT
This furnace must be connected to a chimney certified for use with wood burning heating appliances. A 7-inch chimney
and connector are mandatory for the Caddy if it is used as a wood-oil unit or if an oil option may be installed in the
future. If the furnace is to be used as a wood only unit or a wood-electric, then a 6-inch chimney is recommended.
The unit is not to be connected to a chimney flue serving another appliance. If the chimney draft exceeds 0.06 IN.W.C.,
a barometric draft control should be installed on the smoke pipe. Never install a manual damper. The barometric
control must be adjusted so that the maximum draft measured at the furnace outlet does not exceed 0.06 IN.W.C.
Please note that a draft exceeding 0.06 IN.W.C. could produce an uncontrollable fire. On the other hand, the
minimum draft required is 0.04 IN.W.C. in the evacuation pipe on the wood side, no matter what type of furnace
(WOOD, WOOD / ELECTRIC OR WOOD / OIL). The adjustment should in no case be modified to increase
combustion.
8. SAFETY RULES
THE INFORMATION GIVEN ON THE CERTIFICATION LABEL AFFIXED TO THE APPLIANCE ALWAYS
OVERRIDES THE INFORMATION PUBLISHED, IN ANY OTHER MEDIA (OWNER'S MANUAL, CATALOGUES,
FLYERS, MAGAZINES OR WEB SITES).
8.1. GENERAL REQUIREMENTS
MAKE SURE THE CHIMNEY OUTLET AND THE PIPES ARE CLEAN AND IN GOOD CONDITION.
DO NOT USE CHEMICAL PRODUCTS OR LIQUIDS TO LIGHT THE FIRE.
DO NOT BURN WOOD COATED WITH PAINT, GLUE OR CHEMICAL PRODUCTS.
DO NOT BURN WASTES OR FLAMMABLE LIQUIDS SUCH AS GASOLINE, NAPHTHA, MOTOR OIL, OR OTHER
UNSUITABLE MATTERS.
DO NOT STORE WOOD IN THE VICINITY OF THE FURNACE.
BETWEEN COMBUSTIBLE MATERIALS AND THE SOURCE OF HEAT.
THE ASH DRAWER AND EXCHANGERS ACCESS PANEL GET VERY HOT. DO NOT MANIPULATE
WITH BARE HANDS.
WARNING: This product can expose you to chemicals including carbon
monoxide, which is known to the State of California to cause cancer, birth defects
or other reproductive harm. For more information go to
8.2. ODOUR FROM THE PAINT
It is normal that smoke and odours emanate from the unit when you first light it. It is recommended to burn it at high
rate and ventilate the building until the odours disappear. The smoke is not toxic. This should be done before the
ducts are connected to the furnace to prevent smoke dispersion in the house.
8.3. ASH DISPOSAL
Ashes must be placed in a metal container with a tight fitting lid. The container should be stored outdoor, well away
from combustible materials. This container should not contain any other type of waste. If the ashes are meant to be
buried in soil, wait until all embers have thoroughly cooled before burying.
8.4. CREOSOTE BUILD-UP AND REMOVAL
When wood is burned slowly, it produces tar and other organic vapours which, when combined with moisture, form
creosote.
The creosote vapours condensate in a relatively cool chimney flue.
accumulate inside the flue lining and the exchangers.
WARNING:
RESPECT THE REQUIRED CLEARANCES
WARNING
www.P65warnings.ca.gov/
As a result, creosote residues
11