Safety; Safe Operating Practices - Toro MB TX 2500 Operator's Manual

Safety

Improper use or maintenance of the machine can
result in injury. To reduce the potential for injury,
comply with these safety instructions and always pay
attention to the safety-alert symbol
means Caution, Warning, or Danger—personal
safety instruction. Failure to comply with the
instruction may result in personal injury or death.

Safe Operating Practices

WARNING
Engine exhaust contains carbon monoxide,
an odorless gas that is lethal if inhaled.
Do not run the engine indoors or in an
enclosed area.
Training
•
Read the Operator's Manual and other training
material. If the operator(s) or mechanic(s) cannot
read this manual, it is the owner's responsibility to
explain this material to them.
•
Become familiar with the safe operation of the
equipment, operator controls, and safety signs.
•
All operators and mechanics should be trained.
The owner is responsible for training the users.
•
Never let children or untrained people operate or
service the equipment. Local regulations may
restrict the age of the operator.
•
The owner/user can prevent and is responsible
for accidents or injuries occurring to himself or
herself, other people or property.
Preparation
•
Wear appropriate clothing including hard hat, eye
protection, long pants, substantial, slip-resistant
footwear, and hearing protection. Tie back long
hair. Do not wear loose jewelry.
•
Inspect the area where the equipment is to be
used and ensure that all objects are removed from
the machine before use.
•
Know and mark the locations of all utility lines.
•
Use extra care when handling fuels. They are
flammable and vapors are explosive.
– Extinguish all cigarettes, cigars, pipes, and
other sources of ignition.
– Use only an approved container
– Do not remove the fuel cap or fill the fuel tank
while the engine is running or hot.
– Do not add or drain fuel in an enclosed space.
(Figure 2), which
•
Operation
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
4
– Do not store the machine or fuel container
where there is an open flame, spark, or pilot
light, such as on a water heater or other
appliance.
– If you spill fuel, do not attempt to start the
engine; avoid creating any source of ignition
until the fuel vapors have dissipated.
Check that the operator's presence controls, safety
switches, and shields are attached and functioning
properly. Do not operate the machine unless they
are functioning properly.
Use your full attention while operating the
machine. Do not engage in any activity that
causes distractions; otherwise, injury or property
damage may occur.
Never run an engine in an enclosed or poorly
ventilated area.
Operate the machine only in good light, keeping
away from holes and hidden hazards.
Ensure that all drives are in neutral before
starting the engine. Start the engine only from the
operator's position.
Do not operate the machine with the guards
not securely in place. Be sure all interlocks are
attached, adjusted properly, and functioning
properly.
Do not change the engine governor setting or
overspeed the engine.
Stop the machine on level ground, lower the
hopper, shut off the engine, and remove the key
before leaving the operator's position for any
reason.
Never carry passengers and keep pets and
bystanders away.
Slow down and use caution when making turns
and crossing roads and sidewalks.
Do not operate the machine while ill, tired, or
under the influence of alcohol or drugs.
Use care when loading or unloading the machine
into a trailer or truck.
Use care when approaching blind corners, shrubs,
trees, or other objects that may obscure vision.
Ensure that the area is clear of other people before
operating the machine. Shut off the machine if
anyone enters the area.
Never leave a running machine unattended.
Do not exceed the rated operating capacity, as the
machine may become unstable which may result
in loss of control.
Never jerk the controls; use a steady motion.