Safety; Safe Operating Practices - Toro MB TX 2500 Operator's Manual

Safety

Improper use or maintenance of the machine can
result in injury. To reduce the potential for injury,
comply with these safety instructions and always
pay attention to the safety-alert symbol
means Caution, Warning, or Danger—personal
safety instruction. Failure to comply with the
instruction may result in personal injury or death.

Safe Operating Practices

WARNING
Engine exhaust contains carbon monoxide,
an odorless, deadly poison that can kill you.
Do not run the engine indoors or in an
enclosed area.
Training
•
Read the Operator's Manual and other training
material. If the operator(s) or mechanic(s) cannot
read English, it is the owner's responsibility to
explain this material to them.
•
Become familiar with the safe operation of the
equipment, operator controls, and safety signs.
•
All operators and mechanics should be trained.
The owner is responsible for training the users.
•
Never let children or untrained people operate or
service the equipment. Local regulations may
restrict the age of the operator.
•
The owner/user can prevent and is responsible
for accidents or injuries occurring to himself or
herself, other people or property.
Preparation
•
Wear appropriate clothing including hard hat, eye
protection, long pants, substantial, slip-resistant
footwear, and hearing protection. Tie back long
hair. Do not wear jewelry.
•
Inspect the area where the equipment is to be
used and ensure that all objects are removed from
the machine before use.
•
Know and mark the locations of all utility lines.
•
Use extra care when handling fuels. They are
flammable and vapors are explosive.
– Use only an approved container.
– Never remove the fuel cap or add fuel while
the engine is running. Allow the engine to cool
before refueling. Do not smoke.
– Never fuel or drain the machine indoors.
– Never store the machine or fuel container
inside where there is an open flame, such as
near a water heater or furnace.
– Never fill a container while it is inside a vehicle,
, which
trunk, pick-up bed, or any surface other than
the ground.
– Keep container nozzle in contact with the tank
during filling.
•
Check that the operator's presence controls,
safety switches, and shields are attached and
functioning properly. Do not operate unless they
are functioning properly.
Operation
•
Never run an engine in an enclosed area.
•
Only operate in good light, keeping away from
holes and hidden hazards.
•
Ensure that all drives are in neutral before
starting the engine. Start the engine only from the
operator's position.
•
Never operate with the guards not securely in
place. Be sure all interlocks are attached, adjusted
properly, and functioning properly.
•
Do not change the engine governor setting or
overspeed the engine.
•
Stop the machine on level ground, lower the
hopper, and shut off the engine before leaving the
operator's position for any reason.
•
Never carry passengers and keep pets and
bystanders away.
•
Slow down and use caution when making turns
and crossing roads and sidewalks.
•
Do not operate the machine while ill, tired, or
under the influence of alcohol or drugs.
•
Use care when loading or unloading the machine
into a trailer or truck.
•
Use care when approaching blind corners, shrubs,
trees, or other objects that may obscure vision.
•
Ensure that the area is clear of other people before
operating the machine. Shut off the machine if
anyone enters the area.
•
Never leave a running machine unattended.
•
Do not exceed the rated operating capacity, as the
machine may become unstable which may result
in loss of control.
•
Never jerk the controls; use a steady motion.
•
Watch for traffic when operating near or crossing
roadways.
4