Table of Contents
Advertisement
12 May 2005
Power and Ground
Locate a switched 12-volt power source under the dash and install the Red wire to it.
Install the other end to the Power connector of the control box.
Install the Black ground loop to a good ground and install the other end to the
Ground connector of the control box.
Display Assembly Installation
* * * E X T R E M E
THE DISPLAY IS VERY FRAGILE AND IS INSTALLED AND
TESTED AT THE MANUFACTURER. IF YOU MUST REMOVE
THE DISPLAY IN ORDER TO PAINT THE PILLAR MOUNT
TAKE EXTREME CARE WHEN REINSTALLING. DO NOT
OVERTIGHTEN MOUNTING SCREWS OR DISPLAY WILL BE
DAMAGED AND WARRANTY WILL BE VOIDED. ***
Place the display assembly on the A-pillar to determine the best mounting location
and mark this location on the pillar. Remove the A-pillar for ease of installation.
Hold the display assembly in place on the A-pillar. Drill 3/16" holes into the corners
of the display assembly mount and also through the pillar.
Drill a hole through the A-pillar large enough for the display control wiring connector
to pass through. This hole is NOT required if you decide to run wiring along the
outside of the A-pillar.
Install the telephone-type communication cable into the back of the display circuit
board and route the wiring through the drilled hole or along the outside of the pillar
as preferred.
Insert the supplied ratchet fasteners through the drilled holes and into the A-pillar,
securing the X-Monitor display assembly to the A-pillar. Install the A-pillar into place
and route the control wiring down to the control box.
Insert the other end of the communications cable into the socket of the control box.
Once all connections are made, secure the box in place under the dash and away
from moving parts.
U.S. Shipping Address: 88-446 Harrison St, Sumas, WA 98295
1086210 GMC/Chevy Duramax X-Monitor
Plant Address: Unit A10, 33733 King Rd, Abbotsford, BC, Canada V2S 7M9
Phone: 604-853-6096 Fax: 604-853-8749 Internet: www.bd-power.com
C A U T I O N * * *
BD Engine Brake Inc.
U.S. Mailing Address: P.O. Box 231, Sumas, WA 98295
17
Advertisement
Table of Contents
