Table Of Contents - Montigo DelRay DRL3613NI-2 Installation & Maintenance Manual

This appliance may be installed in an aftermarket,
permanently located, manufactured home (USA
only) or mobile home, where not prohibited by
local codes.
This appliance is only for use with the type of gas
indicated on the rating plate. A conversion kit is
supplied with the appliance.
contents
Safety Alert Key .................................................................................. 2
Introduction ....................................................................................... 2
Efficiency ............................................................................................. 2
Section A: Before You Begin .......................................................................4
Installation Checklist ......................................................................................4
Standard Installation Checklist ....................................................................5
Rating Plate Sample .......................................................................................6
Section 1: Dimensions ....................................................................... 7
DelRay Dimensions ........................................................................................7
Section 2: Framing ............................................................................ 8
In Wall and Corner Dimensions ..................................................................8
Alcove above the fireplace ...........................................................................8
Clearances ........................................................................................................9
Section 3: venting .............................................................................. 9
Section 3-3-1: venting Layout ......................................................... 10
Wall and Roof mounted venting ...............................................................10
Section 3-2: Installing a Roof Mounted Direct vent Termination
for 4''/7'' (MVTK-1) ............................................................................ 11
Section 3-2-1: Venting Layout ...................................................................11
Section 3-3: Installing a Wall Mounted Termination 4''/7'' ......... 12
Section 3-3-2: Venting Components ........................................................13
Section 3-3-2.2: Duravent DirectVent Pro 4" x 6⅝" Venting Compo-
nents ................................................................................................................14
Section 3-3-3: Heat Shields 4''/7'' .................................................... 15
Section 4: Wiring .............................................................................. 16
DRL**13 (N/L) I Wiring Diagram ...............................................................16
Installation of the wall switch .....................................................................16
DR**13 (N/L) I-2 Wiring Diagram ..............................................................17
Installation of Electrical Supply .................................................................17
xG0226 - 042220
Section 5: Installing the gas line..................................................... 18
Fuel Type .........................................................................................................18
Gas Pressure .................................................................................................18
Section 5-3: GAS CONNECTION ................................................................18
Section 6: Finishing .......................................................................... 19
Finishing Around the Fireplace .................................................................19
Cement Board Install ...................................................................................19
Section 8: Removing & Installing the Screen / Door .................... 20
Removing the Screen...................................................................................20
Reinstalling the Screen ................................................................................20
Removing the door ......................................................................................20
Reinstalling the door ....................................................................................20
Propane Conversion ........................................................................ 21
Section 9: Installing the Accessories .............................................. 23
Installing the Fireglass or Optional Glass Media ...................................23
DelRay 36" Optional Log Kit Installation .................................................23
Propane Driftwood Layout .........................................................................23
Natural Gas Driftwood Layout ...................................................................23
DelRay 48" Optional Log Kit Installation .................................................24
Propane Driftwood Layout .........................................................................24
Natural Gas Driftwood Layout ...................................................................24
Section 10: cleaning and Maintenance ........................................ 26
General............................................................................................................26
Cleaning ..........................................................................................................26
Pilot Burner Adjustment. ............................................................................26
Troubleshooting............................................................................................27
Direct Vent Outdoor Applications ............................................................27
Notes ...............................................................................................................27
Appendix A: venting Terminations ................................................ 28
Appendix B: Warranty ..................................................................... 29
Appendix B: Warranty continued .................................................. 30
Appendix c: Amendment ................................................................ 31
General
3