ITR Hurricane Zephyr HW Installation And Operating Manual page 5

10.3
10.4
10.5
10.6
10.7
10.8
10.9
10.10
10.11
10.12
10.13
10.14
10.15
10.16
10.17
10.18
10-19
10.20
10.21
10.22
10.23
Section 11, Maintenance...........................................................11-1
11.1
11.2
11.3
11.4
11.5
11.6
11.7
11.8
11.9
Section 12, Warranty and Service .............................................12-1
12.1
12.2
12.4
12.5
12.6
12.7
12.8
Inspection Check sheet (including Test Points)
Warranty Information & Warranty Card
International Thermal Research
Burner On ...................................................................10-1
Service Switch Off.........................................................10-2
Remote Switch Off ........................................................10-2
Heater Cycling .............................................................10-2
Thermostats Off............................................................10-3
Voltage Low of High ......................................................10-3
Overheat ....................................................................10-4
Fuse Blown ..................................................................10-4
Fuel Pump/Solenoid ......................................................10-5
Ignitor ........................................................................10-5
Combustion Fan ...........................................................10-6
Water Pump.................................................................10-6
Flame Out ...................................................................10-6
Compressor .................................................................10-8
Bypass Mode................................................................10-8
Water Pump On ............................................................10-9
Flame Sensor Module ....................................................10-9
Test Points...................................................................10-9
Reduced Output.......................................................... 10-10
Smokey,Smelly Exhaust .............................................. 10-10
A Silent Killer ............................................................. 10-11
The First Few Weeks .....................................................11-1
Adding Coolant .............................................................11-1
Nozzle.........................................................................11-2
Fuel Lines and Filter ......................................................11-2
Combustion Chamber ...................................................11-2
Checking Hoses and Tubes .............................................11-2
Electrical System ..........................................................11-3
Recommended Spare Parts ............................................11-3
Protecting Hydronic Heating Systems ...............................11-4
General Warranty .........................................................12-1
Limited Warranty ..........................................................12-1
Owner's Responsibility ...................................................12-2
Not Covered Under Warranty ..........................................12-2
Customer Service Calls .................................................12-3
Returns .......................................................................12-3
Telephone Service.........................................................12-4
Table of Contents