Carrier AquaSnap 30RAP011-060 Controls, Start-Up, Operation, Service, And Troubleshooting page 137

NOTE: To avoid injury to personnel and damage to equipment or property when performing
maintenance listed in this maintenance log, use good judgment, follow safe practices, and
adhere to the safety considerations/information as outlined in preceding sections of this
Controls, Start-Up, Operation, Service, and Troubleshooting document.
MONTH
DATE
OPERATOR
UNIT SECTION
Check Oil Level
COMPRESSOR Leak Test
Check Crankcase Heater If Equipped
Inspect and Clean Cooler
Inspect Cooler Heater
COOLER Leak Test
Record Water Pressure Differential (PSI)
Inspect Water Pumps
Leak Test
CONDENSER
Inspect and Clean Condenser Coil
General Cleaning and Tightening Connections
Check Pressure Transducers
CONTROLS
Confirm Accuracy of Thermistors
Check Chilled Water Flow Switch Operation
General Tightening and Cleaning Connections
STARTER
Inspect All Contactors
Check Refrigerant Charge
SYSTEM Verify Operation of EXVs and Record Position
Record System Superheat
NOTE: Equipment failures caused by lack of adherence to the Maintenance Interval Requirements are not covered under warranty.
APPENDIX E — MAINTENANCE SUMMARY AND LOG SHEETS (cont)
30RAP Monthly Maintenance Log
ACTION UNIT
yes/no
yes/no
yes/no
yes/no
amps
yes/no
PSI
yes/no
yes/no
yes/no
yes/no
yes/no
yes/no
yes/no
yes/no
yes/no
yes/no
0-100%
deg. F
1 2 3 4
/ / / / / / / / /
5 6 7 8 9
/ / / / / / / /
ENTRY
Every 3 - 5 Years
Annually
Annually
10 11 12
/ / / / / / /