15.1
Checking the play in the throttle cable
15.2
Adjusting the play in the throttle cable
–
Check the throttle grip for smooth operation.
–
Move the handlebar to the straight-ahead position. Turn the throt-
tle grip back and forth slightly and determine the play in throttle
A
cable
.
Play in throttle cable
»
If the throttle cable play does not meet the specified value:
–
Adjust the play in the throttle cable.
400192-11
Danger
Danger of poisoning Exhaust gases are toxic and inhaling
them may result in unconsciousness and death.
–
Always make sure there is sufficient ventilation when
running the engine.
–
Use effective exhaust extraction when starting or run-
ning the engine in an enclosed space.
–
Start the engine and let it run at idle speed. Move the handlebar to
and fro over the entire steering range.
The idle speed must not change.
»
If the idle speed changes:
–
Adjust the play in the throttle cable.
Preparatory work
–
Remove the seat. (
–
Turn the tap handle of the fuel tap to the OFF position.
–
Remove the fuel tank.
–
Check the throttle cable routing. (
Main work
–
Move the handlebar to the straight-ahead position.
–
Push back sleeve
–
Ensure that the throttle cable sleeve is pushed all the way into bar-
2
rel adjuster
–
3
Loosen nut
.
S04292-10
–
Turn barrel adjuster
cable at the throttle grip.
Guideline
Play in throttle cable
–
3
Tighten nut
–
1
Slide on sleeve
400192-11
TUNING THE ENGINE 15
2 ... 3 mm (0.08 ... 0.12 in)
p. 53)
(
p. 57)
p. 64)
1
.
.
2
A
so that there is play
2 ... 3 mm (0.08 ... 0.12 in)
.
.
(
p. 93)
(
p. 93)
in the throttle
93