Schwank SPW2-JZ Series Installation & Owner's Manual page 49

QUALIFIED INSTALLER TO COMPLETE THIS TUBE HEATER COMMISSIONING REPORT
REFER TO THIS COMPLETED REPORT WHEN CALLING TECHNICAL SERVICES: 1-877-
TYPE OF GAS
HAS A MANUFACTURER'S GAS CONVERSION KIT BEEN INSTALLED
DOES BUILDING HAVE A 'NEGATIVE AIR' CONDITION
IS HEATER EXPOSED TO CHEMICAL OR CORROSIVE ATMOSPHERE
IS 'OUTSIDE COMBUSTION AIR' REQUIRED TO THE BURNER

MINIMUM CLEARANCES CONFORM TO REQUIREMENTS OF THIS MANUAL
WHAT IS THE ALTITUDE OF THIS PROJECT LOCATION ABOVE SEA LEVEL
IS ALTITUDE ADJUSTMENT REQUIRED? (See Section 27, Page 47)

CAN HEATER BE AFFECTED BY OVERHEAD CRANES / VIBRATION
THE GAS SUPPLY PIPING IS ADEQUATELY SIZED FOR SYSTEM VOLUME
GAS SUPPLY LINES AND BRANCHES HAVE BEEN PURGED OF AIR
INLET GAS SUPPLY PRESSURE WITH ALL HEATERS OPERATING
MANIFOLD PRESSURE WITH HEATER OPERATING
LINE VOLTAGE READING AT THE HEATER
VOLTAGE READING AT IGNITION MODULE
IS THE HEATER PROPERLY ELECTRICALLY GROUNDED
FLAME SIGNAL STRENGTH FROM SENSOR (µA microamps)
IS THE HEATER CONTROLLED BY A THERMOSTAT
IS THE THERMOSTAT STRATEGICALLY LOCATED
'MAXIMUM STACK HEIGHT' SIGN(S) POSTED AT THERMOSTAT(S)
TOTAL LENGTH OF LOW VOLTAGE THERMOSTAT WIRE
GAUGE OF THE LOW VOLTAGE THERMOSTAT WIRE
WHAT IS THE HEATER TUBE LENGTH (10 ft per tube section)
WHAT IS THE TOTAL LENGTH OF THE VENT (Add 5 ft for each 90° elbow)
WHAT LENGTH IS THE COMBUSTION AIR DUCT (Add 5 ft for each 90° elbow)
WHAT IS THE TOTAL TURBULATOR LENGTH (See Section 26, Pages 45-46)
IS THE TURBULATOR IN THE PROPER LOCATION IN THE SYSTEM (Page 46)
THIS HEATER TEST FIRED WITHOUT MALFUNCTION
49
NG LP
YES NO
YES NO
YES NO
YES NO
YES NO
FEET
YES NO
YES NO
YES NO
YES NO
" WC
" WC
VOLTS
VOLTS
YES NO
µA
YES NO
YES NO
YES NO
FEET
GAUGE
FEET
FEET
FEET
INCHES
YES NO
YES NO
SPW2, STW2(S) / IWP2, IW2(S) I&O Manual
IM170629
RL: 03C
RD: APR 2019