Installation; Unpacking; Mounting Guidelines - Briggs & Stratton 71037 Installation And Operator's Manual

Installation

Unpacking

Delivery Inspection
After removing the carton, carefully inspect the transfer
switch components for any damage that may have occurred
during shipment.
IMPORTANT: If loss or damage is noted at time of delivery,
have the person(s) making delivery note all damage on the
freight bill and affix his signature under the consignor's
memo of loss or damage. If loss or damage is noted after
delivery, contact the carrier for claim procedures. Missing or
damaged parts are not warranted.
Shipment Contents
• Automatic Power Transfer Switch
• Installation and Operator's Manual
• Current Transformers
Typical
— — — — — — Control Wiring
Hot
Water
Heater
Alternate
Hot Water
Heater
6
Contactor
Branch Circuits
— — — — — — Control Wiring
Contactor
Emergency
Load Center
Branch Circuits

Mounting Guidelines

The Automatic Transfer Switch is enclosed in a NEMA
Type 3R enclosure suitable for indoor/outdoor use.
Guidelines for mounting the Automatic Transfer Switch
include:
• Install the switch on a firm, sturdy supporting structure.
• The switch must be installed with minimum NEMA 3R
hardware for conduit connections.
• To prevent switch contact distortion, level and plumb the
enclosure. This can be done by placing washers between
the switch enclosure and the mounting surface.
• NEVER install the switch where any corrosive
substance might drip onto the enclosure.
• Protect the switch at all times against excessive moisture,
dust, dirt, lint, construction grit and corrosive vapors.
A typical installation of the Automatic Power Transfer Switch
is depicted below. An alternative installation of the Automatic
Power Transfer Switch is also depicted below. It is best if the
transfer switch is mounted near the utility meter, either
inside or outside. Discuss layout suggestions/ changes with
the owner before beginning the system installation process.
Service Disconnect
Main Transfer
Breaker
Switch
Panel
Disconnect Switch
Transfer
Main
Switch Breaker
Panel
Disconnect Switch
Watt -
Hourmeter
Generator
Air
Conditioner
Watt -
Hourmeter
Generator
Air
Conditioner
BRIGGSandSTRATTON.COM