Descriptions Of Work - Volkswagen Touareg 2010 Maintenance Manual

Touareg 2010 ➤ , Touareg 2015 ➤
Maintenance - Edition 02.2019
4

Descriptions of work:

This chapter provides information on the following subjects:
♦ Swivel joints, axle mountings, coupling rod bearings and anti-
roll bar rubber mounting: inspect for damage
♦ Automatic headlight control and static cornering light: check‐
ing function ⇒ page 37
♦ Automatic gearbox: changing ATF (0C8 gearbox)
⇒ page 37
♦ Battery: checking charge level
♦ Battery beneath driver seat: inspecting and checking with bat‐
tery tester with printer VAS 6161
♦ Status of battery: reading, sending diagnosis protocol via on‐
line connection ⇒ page 39
♦ Front passenger airbag: checking key switch and "ON/OFF
function" ⇒ page 49
♦ Tyres: checking condition, wear pattern, tyre pressure and
tread depth ⇒ page 39
♦ Brake system and shock absorbers: inspecting for leaks and
damage ⇒ page 49
♦ Brake fluid: changing
♦ Brake fluid level (dependent upon lining wear): checking
⇒ page 54
♦ Brakes, front and rear: checking thickness of brake pads and
condition of brake discs
♦ Diesel fuel filter: draining water (diesel engine)
♦ Diesel fuel filter: renewing (diesel engine)
♦ Diesel particulate filter: checking
♦ Window regulators: checking positioning (open and close
functions) ⇒ page 58
♦ Fault memories of all systems: reading with vehicle diagnostic
tester and correcting possible faults according to repair guide‐
lines ⇒ page 59
♦ Bonnet: greasing catch hook
♦ Gearbox, final drive and drive shaft bellows: inspecting for
leaks and damage ⇒ page 60
♦ Hybrid components: inspecting for damage to high-voltage
components and lines in engine compartment and rear area
⇒ page 60
♦ Interior and exterior body: inspecting for corrosion with doors
and flaps open ⇒ page 61
♦ Poly V-belt: renewing
♦ Poly V-belt: checking condition
♦ Poly V-belt for compressor: renewing
♦ Cooling system: checking frost protection and coolant level
⇒ page 68
♦ Air suspension: checking for leaks and damage
♦ Air filter: cleaning housing and renewing filter element
⇒ page 70
34
4. Descriptions of work:
⇒ page 37
⇒ page 38
⇒ page 50
⇒ page 56
⇒ page 65
⇒ page 58
⇒ page 59
.
⇒ page 61
⇒ page 61
⇒ page 62
⇒ page 36
⇒ page 62
⇒ page 70