Tranquility ® Modular Water-to-Water (TMW) Series Table of Contents Model Nomenclature General Information Unit Physical Data TMW036-120 – Unit Dimensional Data TMW170 & 340 – Unit Dimensional Data Unit Installation Piping Installation 9-10 Load Plumbing Installation Water-Loop Heat Pump Applications Ground-Water Heat Pump Applications 12-13 Water Quality Standards...
Page 2
C L I M AT E M A S T E R WAT E R - S O U R C E H E AT P U M P S Water-to -Water ( TMW ) Series Tranquility ® R e v . : M a r c h 1 0 , 2 0 2 1 This Page Intentionally Left Blank C l i m a t e M a s t e r Wa t e r - S o u r c e H e a t P u m p s...
C L I M AT E M A S T E R WAT E R - S O U R C E H E AT P U M P S Water-to -Water ( TMW ) Series Tranquility ® R e v . : M a r c h 1 0 , 2 0 2 1 General Information ⚠...
Page 5
CAUTION! DO NOT store or install units in corrosive Notify the ClimateMaster Traffic Department of all environments or in locations subject to temperature or damage within fifteen (15) days of shipment.
C L I M AT E M A S T E R WAT E R - S O U R C E H E AT P U M P S Water-to -Water ( TMW ) Series Tranquility ® R e v . : M a r c h 1 0 , 2 0 2 1 Unit Physical Data Model TMW036...
C L I M AT E M A S T E R WAT E R - S O U R C E H E AT P U M P S Water-to -Water ( TMW ) Series Tranquility ® R e v . : M a r c h 1 0 , 2 0 2 1 TMW170 &...
⚠ Optional pressure-rated hose assemblies designed WARNING! specifically for use with ClimateMaster units are available. Similar hoses can be obtained from alternate suppliers. WARNING! Polyolester Oil, commonly known as POE oil, is Supply and return hoses are fitted with swivel-joint fittings a synthetic oil used in many refrigeration systems including those with HFC-410A refrigerant.
The field installed high pressure switch shall have a cut-out pressure of 300 psig and a cut-in pressure of 250 psig. This pressure switch can be ordered from ClimateMaster with a 1/4” internal flare Unit Power Disconnect connection as part number 39B0005N02.
20 mesh] size. The ClimateMaster Water Quality Table provides water quality requirements for ClimateMaster coaxial heat exchangers and fluid coolers. The water should be evaluated by an independent testing facility comparing to this Table and when properties are outside of these requirements, an external secondary heat exchanger must be used to isolate the equipment from the unsuitable water.
Page 13
250 psig. This pressure switch be present, a closed loop system is recommended. It is can be ordered from ClimateMaster with a 1/4” internal flare recommended to install an intermediate heat exchanger connection as part number 39B0005N02.
C L I M AT E M A S T E R WAT E R - S O U R C E H E AT P U M P S Water-to -Water ( TMW ) Series Tranquility ® R e v . : M a r c h 1 0 , 2 0 2 1 Ground-Loop Heat Pump Applications ⚠...
Page 15
250 psig. This pressure switch [2.0 to 2.6 l/m per kW] is achieved. Secondly, a flow control can be ordered from ClimateMaster with a 1/4” internal flare device may be installed. The devices are typically an orifice connection as part number 39B0005N02.
C L I M AT E M A S T E R WAT E R - S O U R C E H E AT P U M P S Water-to -Water ( TMW ) Series Tranquility ® R e v . : M a r c h 1 0 , 2 0 2 1 Electrical –...
HP Switch Circuit #2 #97B0013N01) or MPC Controller AOM (part #97B0031N01) on the web at climatemaster.com ALL wiring diagrams are available at climatemaster.com c l i m a t e m a s t e r . c o m...
TMW120 Series Line Voltage Field Wiring Commercial Class ALL wiring diagrams available at climatemaster.com C l i m a t e M a s t e r Wa t e r - S o u r c e H e a t P u m p s...
Tranquility ® R e v . : M a r c h 1 0 , 2 0 2 1 TMW Series Wiring Diagram Matrix All current 60 Hz wire diagrams can be downloaded at www.climatemaster.com/commercial-wiring Wiring Diagram Model Electrical Control...
Page 21
T H E S M A R T S O L U T I O N F O R E N E R G Y E F F I C I E N C Y Water-to -Water ( TMW ) Series Tranquility ®...
Page 22
C L I M AT E M A S T E R WAT E R - S O U R C E H E AT P U M P S Water-to -Water ( TMW ) Series Tranquility ® R e v . : M a r c h 1 0 , 2 0 2 1 Typical Wiring Diagram Three Phase –...
Page 23
T H E S M A R T S O L U T I O N F O R E N E R G Y E F F I C I E N C Y Water-to -Water ( TMW ) Series Tranquility ®...
Page 24
C L I M AT E M A S T E R WAT E R - S O U R C E H E AT P U M P S Water-to -Water ( TMW ) Series Tranquility ® R e v . : M a r c h 1 0 , 2 0 2 1 Typical Wiring Diagram Three Phase –...
Page 25
T H E S M A R T S O L U T I O N F O R E N E R G Y E F F I C I E N C Y Water-to -Water ( TMW ) Series Tranquility ®...
Page 26
C L I M AT E M A S T E R WAT E R - S O U R C E H E AT P U M P S Water-to -Water ( TMW ) Series Tranquility ® R e v . : M a r c h 1 0 , 2 0 2 1 Typical Wiring Diagram Three Phase –...
Page 27
T H E S M A R T S O L U T I O N F O R E N E R G Y E F F I C I E N C Y Water-to -Water ( TMW ) Series Tranquility ®...
Page 28
C L I M AT E M A S T E R WAT E R - S O U R C E H E AT P U M P S Water-to -Water ( TMW ) Series Tranquility ® R e v . : M a r c h 1 0 , 2 0 2 1 Typical Wiring Diagram Three Phase –...
Page 29
T H E S M A R T S O L U T I O N F O R E N E R G Y E F F I C I E N C Y Water-to -Water ( TMW ) Series Tranquility ®...
Page 30
C L I M AT E M A S T E R WAT E R - S O U R C E H E AT P U M P S Water-to -Water ( TMW ) Series Tranquility ® R e v . : M a r c h 1 0 , 2 0 2 1 Typical Wiring Diagram Three Phase –...
C L I M AT E M A S T E R WAT E R - S O U R C E H E AT P U M P S Water-to -Water ( TMW ) Series Tranquility ® R e v . : M a r c h 1 0 , 2 0 2 1 CXM Controls CXM Control - For detailed control information, see the DIP switch 2: Stage 2 Selection - provides selection of...
LT2 of 30°F or 10°F [-1°F or -12°C] (refrigerant temperature). Note: This jumper should only Table 3b: DXM LED And Alarm Relay Operations be clipped under extenuating circumstances, as recommended by ClimateMaster technical Status LED Test LED Fault LED...
Page 34
C L I M AT E M A S T E R WAT E R - S O U R C E H E AT P U M P S Water-to -Water ( TMW ) Series Tranquility ® R e v . : M a r c h 1 0 , 2 0 2 1 DXM Controls, Cont’d.
T H E S M A R T S O L U T I O N F O R E N E R G Y E F F I C I E N C Y Water-to -Water ( TMW ) Series Tranquility ®...
Page 36
C L I M AT E M A S T E R WAT E R - S O U R C E H E AT P U M P S Water-to -Water ( TMW ) Series Tranquility ® R e v . : M a r c h 1 0 , 2 0 2 1 Safety Features –...
C L I M AT E M A S T E R WAT E R - S O U R C E H E AT P U M P S Water-to -Water ( TMW ) Series Tranquility ® R e v . : M a r c h 1 0 , 2 0 2 1 Unit &...
C L I M AT E M A S T E R WAT E R - S O U R C E H E AT P U M P S Water-to -Water ( TMW ) Series Tranquility ® R e v . : M a r c h 1 0 , 2 0 2 1 Operating Pressures TMW036-340 (TMW120, 340 Per Circuit) Cooling...
Page 41
T H E S M A R T S O L U T I O N F O R E N E R G Y E F F I C I E N C Y Water-to -Water ( TMW ) Series Tranquility ®...
C L I M AT E M A S T E R WAT E R - S O U R C E H E AT P U M P S Water-to -Water ( TMW ) Series Tranquility ® R e v . : M a r c h 1 0 , 2 0 2 1 Preventive Maintenance Heat Exchanger Maintenance - Cabinet - Do not allow water to stay in contact with the...
C L I M AT E M A S T E R WAT E R - S O U R C E H E AT P U M P S Water-to -Water ( TMW ) Series Tranquility ® R e v . : M a r c h 1 0 , 2 0 2 1 Warranty (U.S.
C L I M AT E M A S T E R WAT E R - S O U R C E H E AT P U M P S Water-to -Water ( TMW ) Series Tranquility ® R e v . : M a r c h 1 0 , 2 0 2 1 Refrigeration Troubleshooting Form Refrigeration Troubleshooting Form Water-to-Water Units...
Page 47
T H E S M A R T S O L U T I O N F O R E N E R G Y E F F I C I E N C Y Water-to -Water ( TMW ) Series Tranquility ®...
ClimateMaster works continually to improve its products. As a result, the design and specifications of each product at the time for order may be changed without notice and may not be as described herein. Please contact ClimateMaster’s Customer Service Department at 1-405-745-6000 for specific information on the current design and specifications.
Need help?
Do you have a question about the EarthPure Tranquility TMW Series and is the answer not in the manual?
Questions and answers