Fresenius Medical Care 460018 Operator's Manual page 21

D I S S O L U T I O N

CAUTION! B
CAUTION! U
 15
FOR MINUTES
S (MSDS)
HEET
DRY ACID PRODUCT BEING USED
WARNING! D
IMPORTANT THAT THE ENTIRE CONTENTS OF EACH CASE OF DRY ACID CONCENTRATE IS EMPTIED INTO THE
D
ISSOLUTION
WARNING!
CONCENTRATE INTO THE MIXER
INHALATION INJURY
NOTE: G
A P
CID RODUCT CONTAINS
DURING THE
NOTE: I
NPUT WATER PRESSURE DIRECTLY EFFECTS HOW FAST
MAXIMUM INPUT WATER PRESSURE IS
9. Remove the Dry Acid Dissolution Unit Small Access Lid and
slowly add granules as seen in Figure 7. This minimizes the
amount of particulates discharged into air while adding
granules to the tank. If clumping in dry acid product is present,
then the larger access lid can be used to load the Tank, but
ensure that the bags are slowly poured into the large access
port to avoid splashing of water onto the outside of the Dry
Acid Dissolution Unit (See Appendix A for further complete dry
acid mixing information, page 45).
10. After the Dry Acid Concentrate has been added, remove the Large Access lid dry off the Final Fill Level
Sensor of any splashing that may have occurred during the add granules process (Figure 8).
Locate Final Fill Sensor
11. Replace the Large and Small Access Lid then press the
Dissolution side START button.
The Dry Acid Dissolution Unit will proceed to the MIX
Operation.
P/N 460018 Rev. D
C Y C L E C o n t i n u e d
C
E CERTAIN THE SAME ATALOG
SING EYE PROTECTION AND GLOVES IS RECOMMENDED
. I
F CONTACT WITH SKIN
P
FOR FURTHER ERSONAL
.
O NOT USE CASE OF DRY ACID CONCENTRATE THAT HAS BEEN OPENED OR TAMPERED WITH
U . B
NIT E CERTAIN ALL BAGS PER CASE HAVE BEEN ADDED
IN ABSENCE OF SIGNIFICANT CLUMPING
.
USE OF THE LARGE ACCESS LID WHEN POURING ACID CONCENTRATE MAY RESULT IN
.
F ® D A P
RANU LO RY CID RODUCT CONTAINS
4
BAGS PER BOX
ADD GRANULES O
PERATION
60
N
UMBER IS ON ALL CASES
. I
,
FLUSH WITH PLENTY OF SOAP AND WATER
P E (PPE)
ROTECTIVE QUIPMENT
,
ONLY USE THE SMALL ACCESS LID WHEN POURING ACID
3
BAGS PER BOX AND
. C
ONTENTS OF ALL EIGHT BOXES MUST BE POURED INTO THE TANK
.
T D
HE
½
PSI WITH A MINIMUM GALLON PER MINUTE FLOW RATE
Clean Final Fill Sensor with a soft cloth.
Figure 8
.
,
F CONTACT WITH EYES RINSE IMMEDIATELY
. S M
EE ATERIAL
OR EMERGENCY INSTRUCTIONS FOR THE
.
C DRY
ITRASATE WITH
A D U
RY CID ISSOLUTION NIT WILL FILL
.
Figure 7
S D
AFETY ATA
. I
T IS
D A
RY CID
A D
CETATE RY
. T
HE
15