Nordson Tribomatic 635598 Instruction Sheet

Modular pump with adapter

Download this manual

Tribomatic

1. Introduction

Fig. 1

Tribomatic Modular Pump with Adapter

E 2000 Nordson Corporation

Modular Pump with Adapter

See Figure 1. This kit includes a modular Tribomatic powder pump and

adapter for use with the Tribomatic automatic powder spray gun. The

adapter is used to install the pump onto a Tribomatic pump mount.

WARNING: Allow only qualified personnel to perform the

following tasks. Follow the safety instructions in this document

and all other related documentation.

343 545A

Issued 8/00

Instruction Sheet

P/N 343545A

Manual 37-35

Page 1 Tribomatic automatic powder spray gun. The adapter is used to install the pump onto a Tribomatic pump mount. Fig. 1 Tribomatic Modular Pump with Adapter 343 545A Manual 37-35 E 2000 Nordson Corporation All rights reserved Issued 8/00...
Page 2: Installation
NOTE: Always blow air from the pump end into the booth. 3. Clean the pump body by blowing air from the pump to the gun. 4. Clean the powder feed hose. Manual 37-35 343 545A E 2000 Nordson Corporation All rights reserved Issued 8/00...
Page 3 5. Inspect the powder feed tubing and replace any pieces that are worn or damaged. If powder is impact-fused inside the tubing, replace the tubing. 343 545A Manual 37-35 E 2000 Nordson Corporation All rights reserved Issued 8/00...
Page 4 S Adapter 941185 S O-ring, silicone, conductive, 0.875 x 1.062 in. 630043 S Holder, pickup tube NOTE A: Measured in increments of 0.03 m. AR: As Required Manual 37-35 343 545A E 2000 Nordson Corporation All rights reserved Issued 8/00...
Page 5 Tribomatic Modular Pump with Adapter Fig. 2 Tribomatic Modular Pump with Adapter Original copyright date 2000. Nordson, the Nordson logo, and Tribomatic are registered trademarks of Nordson Corporation. 343 545A Manual 37-35 E 2000 Nordson Corporation All rights reserved Issued 8/00...