Container change for two-hand controls with blow-off circuit (14 pages)
Summary of Contents for Nordson High Flow FB
Page 1
P/N 107 987C High Flow and 100 PLUS FB Powder Pumps The Nordson High Flow and 100 PLUS Powder Pumps are highly 1. Description efficient venturi-type pumps designed primarily for pipe-coating (fusion bond) applications. Both pumps are designed to lift fluidized powder out of a feed hopper, atomize the powder stream and deliver it to a powder spray gun.
See Figure 2. Use the following steps to install the pumps. 2. Installation 1. If the pumps are to be mounted on a Nordson Model HTM hopper, locate the 28 mm (1.10 in.) hole used to mount the pump. If using...
Solvents will swell and damage the O-rings. Do not scrape parts with sharp objects as burrs or scratches on powder contact surfaces will contribute to powder buildup or impact fusion. Inspect parts for wear and replace if necessary. 1997 Nordson Corporation 107 987C Manual 32-15 All rights reserved...
Page 4
High Flow and 100 PLUS FB Powder Pumps 5. Parts High Flow FB Powder Pump See Figure 3. Item Part Description Quantity Note — 118 829 Pump, powder, hi-flow, FB S Elbow, male, 8 mm tube x 972 277 thread...
Page 5
High Flow and 100 PLUS FB Powder Pumps High Flow FB Powder Pump (contd.) 3215003A Fig. 3 High Flow FB Powder Pump 1997 Nordson Corporation 107 987C Manual 32-15 All rights reserved Issued 2/97...
Page 6
B: Optional fitting (not shipped with pump). Use in place of the 8 mm tube fittings on air nozzles, for use with older EXP-100 control units and in. OD air tubing. AR: As Required NS: Not Shown Manual 32-15 107 987C 1997 Nordson Corporation All rights reserved Issued 2/97...
Page 7
High Flow and 100 PLUS FB Powder Pumps 100 PLUS FB Powder Pump (contd.) 3215004A Fig. 4 100 PLUS FB Powder Pump 1997 Nordson Corporation 107 987C Manual 32-15 All rights reserved Issued 2/97...
S Nut, ground, pump mount 142 382 S Tube, pick-up, 0.490 ID x 24 in. 224 722 NOTE A: Black silicone O-rings are electrically conductive. Do not substitute non-conductive O-rings. Manual 32-15 107 987C 1997 Nordson Corporation All rights reserved Issued 2/97...
Page 9
High Flow and 100 PLUS FB Powder Pumps 6. Spare Parts (contd.) 3215005A Fig. 5 Pick-up tube and assembly 1997 Nordson Corporation 107 987C Manual 32-15 All rights reserved Issued 2/97...
Page 10
NOTE A: Used with 100 PLUS FB pump. B: Used with High Flow FB pump. AR: As Required Original copyright date 1990. 100 PLUS, Nordson and the Nordson logo are registered trademarks of Nordson Corporation. Tivar is a registered trademark of Menasha Corporation.