Download Print this page

Advertisement

FITNESS
FB160 Folding Bike
OWNER'S MANUAL
PLEASE CAREFULLY READ THIS ENTIRE MANUAL BEFORE OPERATING YOUR NEW FOLDING BIKE

Advertisement

loading
Need help?

Need help?

Do you have a question about the FB160 and is the answer not in the manual?

Questions and answers

Carolyn
April 25, 2025

how to replace batteries in console

1 comments:
Mr. Anderson
May 13, 2025

To replace the batteries in the Xterra FB160 console, use 2 AAA or UM-4 batteries. Open the battery compartment on the console, remove the old batteries, insert the new ones with correct polarity, and close the compartment.

This answer is automatically generated

Subscribe to Our Youtube Channel

Summary of Contents for Xterra FB160

  • Page 1 FITNESS FB160 Folding Bike OWNER’S MANUAL PLEASE CAREFULLY READ THIS ENTIRE MANUAL BEFORE OPERATING YOUR NEW FOLDING BIKE...
  • Page 3: Table Of Contents

    Congratulations On Your New Folding Bike and Welcome to the XTERRA Fitness Family! Thank you for your purchase of this quality Folding Bike from XTERRA Fitness. Your new Folding Bike has been manufactured by one of the leading fitness manufacturers in the world.
  • Page 4: Product Registration

    Manufacturer’s 90 Day Limited Warranty Your XTERRA Folding Bike is warranted for 90 days from the date of purchase against defects in material when used for the purpose intended, under normal conditions and provided it receives proper care. Any part found defective or missing will be sent at no cost when returned in accordance with the terms of this warranty.
  • Page 5: Important Safety Instructions

    Failure to follow all guidelines may compromise the effectiveness of the exercise experience, expose yourself (and possibly others) to injury, and reduce the longevity of the equipment. SAVE THESE INSTRUCTIONS - THINK SAFETY! CAUTION!! Please be careful when unpacking the carton. FB160 Folding Bike...
  • Page 6 For your benefit, read this manual carefully before you use the XTERRA Fitness FB160 Folding Bike. To help us assist you, note the product model number and serial number before contacting us. Before reading further, please familiarize yourself with the parts that are labeled in the drawing below.
  • Page 7 FB160 Assembly Part Checklist No. 01/02 No. 03 No. 04/08 Main Frame Seat Support Tube Handlebar Tube/Console (1pc) (1pc) (1pc / 1pc) No. 05 No. 06 No. 07 Front Stabilizer Rear Stabilizer Seat (1pc) (1pc) (1pc) No. 09L/R No. 10 No.
  • Page 8: Fb160 Assembly Instructions

    FB160 Assembly Instructions Front Stabilizer and Rear Stabilizer Wrench 1. Pull out the Lock Pin (No. 11) from the Front Support Tube (No. 01) and adjust the Front Support Tube (No. 01) to the open position then re-insert the Lock Pin (No. 11) to secure the frame position.
  • Page 9 (No. 15L & 15R). The right pedal is on the right hand side of the bike as you sit on it. The Right Pedal (No. 09R) should be tightened clockwise and the Left Pedal (No. 09L) counter-clockwise. FB160 Folding Bike...
  • Page 10 Seat Support Tube (No. 03), using the pre-installed 3 Flat Washers (No.16) and 3 Nylon Nuts (No. 17). 2. Insert the Seat Support Tube (No. 03) to the Front Support Tube (No. 01); fasten with the Club Knob (No. 10). FB160 Folding Bike...
  • Page 11 1. Remove 4 Screw Sets (No. 12) from the Handlebar Tube (No. 04). 2. Connect the Middle Sensor Wire (No. 19) with the Console (No. 08). 3. Attach the Handlebar Tube (No. 04) to the Rear Support Tube (No. 02), and tighten with 4 Screw Sets (No. 12). FB160 Folding Bike...
  • Page 12: Operation Of Your Console

    0.0 ~ 999.9 CAL ODOMETER 0.0 ~ 9999 KM (MILE) PULSE 40 ~ 240 BPM BATTERY TYPE 2 AAA or UM 4 OPERATING TEMPERATURE 0°C ~ +40°C, 32˚F ~ 104˚F STORAGE TEMPERATURE -10°C ~ +60°C, 14˚F ~ 140˚F FB160 Folding Bike...
  • Page 13 NOTE • If the display is faint or shows no figures, please replace the batteries. • The monitor will automatically shut off if there is no signal received after 4 minutes. FB160 Folding Bike...
  • Page 14 Tighten any parts that may have loosened over time before proceeding with your workout. NOTE: Should any part become defective, contact XTERRA Customer Service immediately to order replacement parts or seek advice on proper service. Discontinue use until the defective part has been repaired.
  • Page 15: Parts List

    FB160-665-PART27 Lower sensor wire FB160-665-PART28 Screw M5x20L FB160-665-PART29 Flat washer φ10.3xφ25 FB160-665-PART30 Self-tapping screw M4x10L FB160-665-PART31 Self-tapping screw ST4.2x12L FB160-665-PART32 Self-tapping screw ST4.2x20L FB160-665-PART33 Magnet assembly FB160-665-PART34 Axle for Main frame FB160-665-PART35 Flat washer φ5.2xφ18 FB160-665-PART36 Pulley FB160 Folding Bike...
  • Page 16 Bushing FB160-665-PART64 Plastic washer φ14xφ10.3 FB160-665-PART65 Belt FB160-665-PART66 Grommet FB160-665-PART67 End cap for rear stabilizer FB160-665-PART68 End cap for front stabilizer FB160-665-PART69 Chain cover(L) FB160-665-PART70 Chain cover(R) FB160-665-PART71 Screw M5x8L FB160-665-PART72 Allen key FB160-665-PART73 Hex Head Wrench FB160 Folding Bike...
  • Page 17: Exploded View

    Exploded View FB160 Folding Bike...
  • Page 18: Manufacturer's Limited Warranty

    Effective September 19, 2019 - Folding Bike LIMITED WARRANTY XTERRA Fitness Inc. warrants all its home use Folding Bike parts for a period of time listed below, from the date of retail sale, as determined by a sales receipt or in the absence of a sales receipt, eighteen (18) months from the original factory shipping date. XTERRA Fitness’...
  • Page 19 FB160 Folding Bike...
  • Page 20 3000 Nestle Road Jonesboro, AR 72401 - Phone:870-333-5500 - Fax:870-935-7611 www.xterrafitness.com FB160 Folding Bike ©2019 All RIghts Reserved. FB160 Owner’s Manual...