Page 2
If you lose the Operator Manual or the Declaration of Conformity, you can download them from the website below or request a printed copy from the address below. www.cornelius-emea.com Cornelius Deutschland GmbH Tel.: +49 (0) 21 73 / 79 3 – 0 Carl-Leverkus-Str.
By using the unit as intended you will not only protect yourself, but also prevent damage oc- curring to the unit and its components! The intended use of undercounter coolers from the Energize 1 HC series (referred to as “unit” in the following) is to refrigerate and convey non-alcoholic beverages and their basic ingredi- ents.
Improper use Improper use of the unit and unauthorised modifications to the unit and its components may cause personal injury and equipment damage for which Cornelius Deutschland GmbH shall assume no liability. Improper use of the unit is prohibited. The following in particular is regarded as improper use: –...
An expert must also have received technical training in the unit-specific special features of Cornelius products. The assigned tasks are always to be carried out in compliance with the relevant installation and service manual for the unit concerned; see the document “Under- counter cooler installation and service manual”, document no.
Not every one of following key terms is necessarily used in this documentation. Risk = extent x likelihood of occurrence Operator manual Undercounter cooler Cornelius Deutschland GmbH Energize 1 HC Document no. TD1001000 Version 01/10/2019, Index 4...
1.5.1 Disclaimer of liability and warranties If work is undertaken on the unit which is not described in this document, Cornelius Deutsch- land GmbH shall not assume any liability for any resulting hazards and damages. The same applies to described work which is partly or not fully performed in compliance with the regula- tions set out in this document.
1.3.2. • Children must be supervised to ensure that they do not play at or with the unit. Operator manual Undercounter cooler Cornelius Deutschland GmbH Energize 1 HC Document no. TD1001000 Version 01/10/2019, Index 4...
Page 11
If you begin to notice any smell, leave the room and alert the fire ser- vice. NOTICE! In particular, safety standards are to be observed in their scope of validity (e.g. EN 60335-2-75). Cornelius Deutschland GmbH Operator manual Undercounter cooler Document no. TD1001000 Energize 1 HC Version 01/10/2019, Index 4...
Unpacking the unit NOTICE! Cornelius Deutschland GmbH is not responsible for damaged deliveries. If any damage is found, all packaging material is to be kept and the freight carrier is to be contacted. If the freight carrier is not contacted within 48 hours of receipt of delivery, the warranty claim might be rendered void.
• When working at the unit or its components, wear a grounding (anti- static) wrist strap at the very least and wear antistatic gloves if neces- sary. Cornelius Deutschland GmbH Operator manual Undercounter cooler Document no. TD1001000 Energize 1 HC...
Such fuels or lubricants must always be prevented from seeping into the ground, the sewage system and any bodies of water, and must always be prevented from entering the at- mosphere. Operator manual Undercounter cooler Cornelius Deutschland GmbH Energize 1 HC Document no. TD1001000 Version 01/10/2019, Index 4...
Fig. 1 Cover Cooling unit with refrigerator and car- Connecting plate with tube connections bonator Control and indicator panel Water level gauge Line supply Cornelius Deutschland GmbH Operator manual Undercounter cooler Document no. TD1001000 Energize 1 HC Version 01/10/2019, Index 4...
When requested at the tower, they are conveyed to the tower via the python. Only the soda is continuously circulated. or electrically operated syrup pumps are used to convey the brands (syrup). Operator manual Undercounter cooler Cornelius Deutschland GmbH Energize 1 HC Document no. TD1001000 Version 01/10/2019, Index 4...
The applicable installation and service manual contains the diagram and description of the connections for this unit; see the document “Undercount- er cooler installation and service manual”, document no. TD1001100. Cornelius Deutschland GmbH Operator manual Undercounter cooler Document no. TD1001000...
0.5-1.0 Tap water flow pressure > 2 1. Changes reserved NOTICE! When using Cornelius pythons, heat loss of 8-15 kcal/h is to be calculated for each consecutive metre. Operator manual Undercounter cooler Cornelius Deutschland GmbH Energize 1 HC Document no. TD1001000...
To prevent algae building up in the water, the disinfectant Molco (PN 14- 9670-150) can be added. The container size with 150 ml disinfectant is suf- ficient for 30 litres of water. Cornelius Deutschland GmbH Operator manual Undercounter cooler Document no. TD1001000...
Page 20
Once the unit has been switched off and only then: 1. Plug the mains plug into the earthed socket, if applicable. Fig. 5 Operator manual Undercounter cooler Cornelius Deutschland GmbH Energize 1 HC Document no. TD1001000 Version 01/10/2019, Index 4...
3. Connect the tube connection back onto the product container. NOTICE! If you would like to change another beverage, please inform your service partner. Cornelius Deutschland GmbH Operator manual Undercounter cooler Document no. TD1001000 Energize 1 HC Version 01/10/2019, Index 4...
6. Turn the carbonator pump switch (Fig. 7/3) to position “0”. Fig. 7 7. Pull the mains plug out of the earthed socket. Fig. 8 Operator manual Undercounter cooler Cornelius Deutschland GmbH Energize 1 HC Document no. TD1001000 Version 01/10/2019, Index 4...
Change the water in the water bath. Please contact your service partner As required Undercounter cooler, interior Thaw ice build-up Please contact your service partner Cornelius Deutschland GmbH Operator manual Undercounter cooler Document no. TD1001000 Energize 1 HC Version 01/10/2019, Index 4...
11. Afterwards, open the CO bottle valve again. 12. Inspect the unit for damage. Always replace any damaged components and parts. Please contact your service partner. Operator manual Undercounter cooler Cornelius Deutschland GmbH Energize 1 HC Document no. TD1001000 Version 01/10/2019, Index 4...
2. Clean the unit with a clean, damp cloth and, if necessary, an approved cleaning agent. 3. Dry the unit with a paper towel. Fig. 11 Cornelius Deutschland GmbH Operator manual Undercounter cooler Document no. TD1001000 Energize 1 HC Version 01/10/2019, Index 4...
Page 26
Syrup has been stored too long Connect a new syrup container; and has had CO added see chapter 4.2 Contaminated tubes Please contact your service part- Operator manual Undercounter cooler Cornelius Deutschland GmbH Energize 1 HC Document no. TD1001000 Version 01/10/2019, Index 4...
Page 27
(see documen- vant pressure-reducing valve tation on the CO system) Cornelius Deutschland GmbH Operator manual Undercounter cooler Document no. TD1001000 Energize 1 HC Version 01/10/2019, Index 4...
Page 28
Crushed ice in the cup may also cause decarbonisation. When the finished beverage comes into contact with sharp-edged ice, CO is released from the dispensed drink. Operator manual Undercounter cooler Cornelius Deutschland GmbH Energize 1 HC Document no. TD1001000 Version 01/10/2019, Index 4...
Page 29
Applicable documents Applicable documents Declaration of conformity Cornelius Deutschland GmbH Operator manual Undercounter cooler Document no. TD1001000 Energize 1 HC Version 01/10/2019, Index 4...
Page 30
Applicable documents Handover certificate Operator manual Undercounter cooler Cornelius Deutschland GmbH Energize 1 HC Document no. TD1001000 Version 01/10/2019, Index 4...
Page 31
Applicable documents Cornelius Deutschland GmbH Operator manual Undercounter cooler Document no. TD1001000 Energize 1 HC Version 01/10/2019, Index 4...
Page 32
Applicable documents Operator manual Undercounter cooler Cornelius Deutschland GmbH Energize 1 HC Document no. TD1001000 Version 01/10/2019, Index 4...
Page 33
Applicable documents Cornelius Deutschland GmbH Operator manual Undercounter cooler Document no. TD1001000 Energize 1 HC Version 01/10/2019, Index 4...