Related Manuals for Hayter Harrier 56 Autodrive VS BBC
Summary of Contents for Hayter Harrier 56 Autodrive VS BBC
- Page 1 Harrier 56 Autodrive VS BBC CODE575A OPERATOR MANUAL Original Version (EN) From Serial Number: 404000000 and Up Issued: 26/02/2019 Part number: 3431-260 Rev A...
-
Page 3: Table Of Contents
CONTENTS Introduction Before Operation continued Controls Safety 6 - 9 Blade Brake Clutch General Safety Before Mowing Safety Alert Symbol During Operation 15 - 17 Before Operation Safety Starting - General Safety Forward Travel - Fuel Safety Shutting off the Engine During Operation Safety Parking - General Safety... - Page 4 CONTENTS Maintenance continued Rear Defl ector Carburettor Adjustments Blade Brake Test Lubrication Storage Storage Safety Preparing the Mower for Storage Storage Removing the Mower from Storage Trouble Shooting Warranty EU Privacy Statement Notes...
-
Page 5: Introduction
This operator’s manual should be regarded as part of the mower as it gives essential information regarding safety, operation, maintenance and specifi cations. If you misplace your operator’s manual, contact your local Authorised Hayter Service Dealer for a replacement. Alternatively, visit www.hayter.co.uk/handbooks to download an electronic version. -
Page 6: Safety
SAFETY General Safety personal injury or death. Before Operation Safety - Fuel Safety This mower has been designed in accordance with EN You can fi nd additional safety information where Fuel is extremely fl ammable and highly explosive. A ISO 5395-2:2017. needed throughout this manual. -
Page 7: During Operation Safety
3 seconds. If it doesn’t, stop using your mower immediately and contact a • Operate the engine only in well-ventilated areas. Hayter Authorised Service Dealer. Exhaust fumes contain carbon monoxide, which is lethal if inhaled. • Keep bystanders out of the operating area. Keep small children out of the operating area and under •... -
Page 8: After Operation Safety
Fuel is fl ammable and explosive, and can cause personal injury. Run the engine dry or remove the fuel with a hand pump; never siphon the fuel. • To ensure optimum performance and continued safety certifi cation of the mower, use only genuine Hayter replacement parts and accessories. -
Page 9: Safety & Instructional Decals
Please ensure all Safety Decals are secured on the mower before using the product. If any of the decals are missing or not secure, do not use the mower, contact your local Authorised Hayter Service Dealer for replacements. WARNING: Improper maintenance, use of non-conforming spare parts, or the removal or modifi cation of the safety decals may cause death or serious injury. -
Page 10: Product Overview
PRODUCT OVERVIEW PRODUCT SPECIFICATION 575A Code Model Harrier 56 Autodrive VS BBC Weight (Net) 53.8 kg Length 1574 mm Width 585 mm 1043 mm Height Width of Cut 560 mm Height of Cut 13 - 60 mm Engine Manufacturer Briggs & Stratton... -
Page 11: Setup
The engine must be fi lled with handle. the correct grade of oil and fuel before starting the Delivery Checklist • If a cable is damaged, contact a Hayter Authorised engine. Service Dealer. Check that the following items have been supplied correctly. -
Page 12: Engine Detail
SETUP that the oil level is at the top of the full indicator (2) Engine Detail on the dipstick. NOTE: Disconnect the spark plug lead before • If the oil level on the dipstick is too low, performing any maintenance procedures. carefully pour a small amount of oil into the oil fi... -
Page 13: Before Operation
fi ll above the bottom of the fuel Fuel stabiliser and engine oil are both available to tank neck. purchase from your Authorised Hayter Service Dealer. 111-9367 - Lawnmower Oil SAE 30 Hayter (Refer fi g.6) 111-9368 - Premium Fuel Treatment Hayter 3. -
Page 14: Adjusting The Cutting Height
BEFORE OPERATION Adjusting the Cutting Height Controls Before Mowing WARNING: The blade is sharp; contacting the blade WARNING: Improper maintenance, use of non- To prevent accidents, thoroughly inspect the area can result in serious personal injury. Shut off the conforming replacement components, or the removal and remove all objects which when contacted by the engine and wait for all moving parts to stop before or modifi... -
Page 15: During Operation
If the engine does not start after repeated attempts, mowing in confi ned areas. front wheels just above ground level and steer in the contact your local Hayter Authorised Service Dealer required direction. or go to briggsandstratton.com. Shutting off the Engine Stand behind the mower, hold the handle and move Release the BBC control and Sens-a-Speed®... -
Page 16: Engaging The Blade
Hayter Authorised Service Dealer. bag fi tted. Refer to Adjusting the Cutting Height. Reduce the height of cut and mow the area again as Trim Side Cutting necessary until the required fi... -
Page 17: Grass Bag
Good grass collection depends on good air fl ow ALWAYS replace a damaged blade. Consult your through the grass bag. To empty the grass bag, Authorised Hayter Service Dealer. pour out the grass clippings and shake the grass bag vigorously to clean the airways. -
Page 18: After Operation
6. Turn the water on. If a cable is damaged, contact a Hayter Authorised serious injury. Service Dealer. Start the engine, engage the BBC and run it until... -
Page 19: Maintenance Schedule
MAINTENANCE SCHEDULE Note: Determine the left and right sides of the mower from the normal operating position. Recommended Maintenance Schedule Maintenance Service Interval Maintenance Procedure Before each use or daily Check the engine-oil level. Check the air fi lter. Clean grass clippings and dirt from under the mower. Check the condition of guards and safety devices. -
Page 20: Maintenance
MAINTENANCE Preparing for Maintenance damage the fi lter and solvents will dissolve the fi lter. IMPORTANT: Before tipping the mower to change 1. Loosen the fasteners (1) at the top of the air fi lter the oil or replace the blade, allow the fuel tank to run cover (2). -
Page 21: Changing The Engine Oil
MAINTENANCE 9. Wait for the oil to settle in the engine. Servicing the Spark Plug Changing the Engine Oil 10. Wipe the dipstick clean with a clean cloth. NOTE: Run the engine a few minutes to warm the oil Improper maintenance, use of nonconforming 11. -
Page 22: Remove & Replace The Blade
If you are uncomfortable (Refer fi g. 30) performing this procedure or do not have a torque wrench, contact a Hayter Authorised Service Dealer. Blade Sharpening WARNING: The blade is sharp; contacting the blade A slightly worn blade may be re-sharpened. Both blade can result in serious personal injury. -
Page 23: Clutch Cable Adjustment
50 mm from the handle. you release the BBC control lever, contact a Hayter or modifi cation of the rear defl ector may cause death Authorised Service Dealer. -
Page 24: Storage
STORAGE Storage Safety • Remove the spark plug, add 30 ml (1 fl oz) of Removing the Mower from Storage engine oil through the spark-plug hole, and pull the Always shut off the mower, wait for all moving engine start cord slowly several times to distribute •... -
Page 25: Trouble Shooting
TROUBLE SHOOTING PROBLEM CAUSES CORRECTIVE ACTION PROBLEM CAUSES CORRECTIVE ACTION Engine stop lever released Operate engine stop lever Undulating ground conditions Change direction of travel Engine will not Incorrect oil level Check oil level Blade worn Sharpen blade turn over Uneven cut Obstruction under deck Remove obstruction... -
Page 26: Warranty
90 Day Warranty – Commercial Use Hayter Limited warrants to the original purchaser that this unit shall be free from defects in material and workmanship, under normal, residential use, for a period of fi ve years from the date of purchase or, if used commercially, for a period of 90 days from the date of purchase. -
Page 27: Eu Privacy Statement
To do so, please contact us by email at legal@toro.com. If you have concerns about the way in which Hayter Ltd. has handled your information, we encourage you to raise this directly with us. Please note that European residents have the right to complain to your... - Page 28 Hayter Limited Spellbrook, Bishop’s Stortford, Herts CM23 4BU England Customer Care Helpline: 0800 616 298 www.hayter.co.uk...