Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Charnwood ISLAND Series
Summary of Contents for Charnwood ISLAND Series
- Page 1 ® Operating & Installation Instructions...
-
Page 3: Table Of Contents
C O N T E N T S QUICK GUIDE OPERATING INSTRUCTIONS FUEL MULTI GRATE RIDDLING OPERATING TOOL HOLDER LIGHTING CONTROLLING THE FIRE REFUELLING ASH CLEARANCE REDUCED BURNING MAINTENANCE THROAT PLATE AND FLUEWAY CLEANING CHIMNEY SWEEPING TROUBLE SHOOTING CO ALARM IF YOU NEED FURTHER HELP UNPACKING THE STOVE HEALTH AND SAFETY PRECAUTIONS... -
Page 4: Quick Guide
Boost Nominal AIR CONTROL SERVICING Stove should be serviced by a professional at least once a year. Suitable fuels for your LIGHTING AND CONTROLLING THE FIRE Charnwood: Wood logs Smokeless Fuel Unsuitable fuels: Petroleum coke Liquid fuel Household waste Coal singles... -
Page 5: Operating Instructions
Please pay careful attention to the special points made with each type of fuel as they will help you to get the best from your stove. It Your Charnwood Island is fitted with a multi grate to enable wood must be remembered that only authorised fuels and wood logs may or smokeless fuel to be burned and ash to be cleared. -
Page 6: Riddling
OPERATING INSTRUCTIONS ® times. When burning wood the ash should be allowed to build up silicon paint with which the firebox is painted reacts to the heat. This and riddling should only be carried out once or twice a week. is normal and will cease after a short time, but meanwhile the room should be kept well ventilated. -
Page 7: Refuelling
Charnwood. may be purchased from your supplier or, in case of difficulty, from The Charnwood Island is fitted with an air control stop for use in a Charnwood. smoke control area. This stops the stove from burning too slowly. -
Page 8: Throat Plate And Flueway Cleaning
Manufacturer or their approved agents. Where the chimney previously served an open fire, it is possible Use only genuine Charnwood replacement parts. that the higher flue gas temperature from a stove may loosen soot THROAT PLATE AND FLUEWAY CLEANING deposits with the consequent risk of flue blockage. -
Page 9: Trouble Shooting
OPERATING INSTRUCTIONS ® the installer will have provided alternative means, such as a soot If blackening of the glass still occurs check that all flue connections door. After sweeping the chimney the appliance flue outlet and the and the blanking plate are well sealed. It is also important that the flue pipe connecting the stove to the chimney must be cleaned with chimney draw is sufficient and that it is not affected by down-draught. -
Page 10: If You Need Further Help
“Warning Note” above. IF YOU NEED FURTHER HELP If you need further help with your Charnwood then your Installer will be able to provide the answers to most questions. Your Local Charnwood Premier Dealer has a great deal of experience and will also be able to provide helpful advice. -
Page 11: Unpacking The Stove
The stove arrives bolted and strapped to its pallet. There must be adequate facilities for unloading and manoeuvring into position The External air supply kits are available please contact Charnwood for wrapping is first removed, then the stove released from the pallet by more information. -
Page 12: Chimney
This may be stainless steel, cast iron, or thick wall steel pipe. specification table) to the sides or rear above hearth level unless Charnwood Pipe to match the stove is available if required. adequately fireproofed in accordance with local building regulations. -
Page 13: Soot Doors
INSTALLATION INSTRUCTIONS ® be more in length than the flue diameter. Fig. 8 Horizontal Register Plate With Top Flue Connection Alternative The stove comes with the blanking plate (fig. 10) fitted to the top Soot Door Positions flue outlet. The seal for the top outlet is a 155mm dia ring of rope seal. -
Page 14: Pre Lighting Check
® PRE LIGHTING CHECK Your local authority is responsible for implementing the Clean Air Act 1993 including designation and supervision of smoke control areas Ensure that the throat plate is fitted in the roof of the appliance. The and you can contact them for details of Clean Air Act requirements. location and positioning of the throat plate is shown in Fig. -
Page 15: Dimensions
DIMENSIONS ® PLAN VIEW To suit 125mm (5”) flue pipe Optional rear flue adaptor 63 I/D FRONT SIDE REAR... - Page 16 DIMENSIONS ® To suit 150mm (6”) flue pipe PLAN VIEW Optional rear flue adaptor FRONT SIDE REAR...
-
Page 17: Parts List
PARTS LIST Island I (AP) Parts List ® Issue A ISLAND I - AP PARTS 26 27 Item Part No. Description Item Part No. Description 008/AY62S Door Seal Set Inc. Adhesive 004/AP051 Tool Holder 008/FW29 Door Seal Adhesive 010/AP116 Air Box Spacer 002/CG20 Grate Bar 008/AP036... -
Page 18: Island Ii - Bp Parts
PARTS LIST Island II (BP) Parts List ® Issue A ISLAND II - BP PARTS Item Part No. Description Item Part No. Description 008/BP004 Door Seal Set Inc. Adhesive 004/EZ095 Riddling/Ashpan Tool 008/FW29 Door Seal Adhesive 004/AP051 Tool Holder 002/CG20 Grate Bar 008/BP110 Air Control Gasket... -
Page 19: Certific Ation
CERTIFIC ATION ® ® AJ WELLS & SONS LTD Bishops Way, Newport, Isle Of Wight PO30 5WS, United Kingdom A Division of A.J.Wells & Sons Limited Registered In England No. 03809371 CE certificate for compliance with EN13240:2001 EN13240:2001 ROOMHEATERS FIRED BY SOLID FUEL ISLAND I - AP ISLAND I - AP ISLAND II - BP... - Page 20 ErP (EU 2015/1187) EN - PRODUCT FICHE IT - SCHEDA PRODOTTO FR - FICHE DE PRODUIT PL - KARTA PRODUKTU MANUFACTURER MARQUE MARCHIO Bishops Way, Newport, Isle of Wight PO30 5WS, United Kingdom MARCA A Division of A.J.Wells & Sons Limited Registered in England No. 03809371 MODEL MODÈLE MODELLO...
- Page 24 your premier dealer...