Adjustment Of Gas Pressure Regulator; Parts List - Southbend SSB-32 Owner's Manual

A B
DJUSTMENT OF ROILER
The burners are adjusted at the factory. Adjustment may be required to achieve proper operation due to elevation
change or other variables. Remove the burner cover to adjust the air shutter on each burner venturi (shown in Figure
6 on the previous page) to achieve proper combustion and optimum burn.
A G
DJUSTMENT OF AS
The pressure regulator is located at the rear right lower corner of the broiler. The regulator is preset for 6" W.C. for
natural gas, or 10" W.C. for propane gas. If adjustment is necessary, do the following:
1. Turn the broiler control knobs to OFF.
2. Attach a pressure-measuring device to the 1/8" NPT connector located on the main manifold (accessible by
removing the grease drawer).
3. Turn the broiler control knobs to HIGH. With the burners lit, check the manifold pressure. The pressure should be
6" W.C. (for natural gas) or 10" W.C. (for propane gas).
4. If necessary, adjust the pressure by unscrewing the top of the pressure regulator (use a screwdriver) to expose
the adjustment screw underneath. Rotating the adjustment screw clockwise increases the manifold pressure.
5. After the pressure has been adjusted, turn the broiler control knobs to OFF, and replace the top cap of the
pressure regulator. Disconnect the pressure-measuring device and replace the plug into the manifold.
P
ARTS
The following table describes the serviceable parts. For parts not listed, contact a Southbend Authorized Parts
Distributor or a Southbend Authorized Service Agency.

PARTS LIST

NATURAL GAS
Part Number
1006436 BURNER ORIFICE
1176008 BURNER VALVE
1184384 PILOT ADJUST
1167782 REGULATOR,PRESS,WC @ 6",NAT
1130399 BURNER, HI-GLOW
1130398 VENTURI ASSEMBLY, HI-GLOW
1-5371 CERAMIC TILE
1189600 KNOB
PARTS LIST PROPANE GAS
Part Number
1006451 BURNER ORIFICE
1176009 BURNER VALVE
1184384 PILOT ADJUST
1167783 REGULATOR,PRESS,WC @10",PROP
1130399 BURNER, HI-GLOW
1130398 VENTURI ASSEMBLY, HI-GLOW
1-5371 CERAMIC TILE
1189600 KNOB
P 18 20
AGE OF
B
URNERS
P R
RESSURE EGULATOR
DESCRIPTION
DESCRIPTION
Quantity
SSB-32 SSB-36 SSB-45
2 2
2 2
1 1
1 1
2 2
2 2
20 20 30
2 2
Quantity
SSB-32 SSB-36 SSB-45
2 2
2 2
1 1
1 1
2 2
2 2
20 20 30
2 2
O ' M
WNER S ANUAL
R S
ADIANT TEAKHOUSE
3
3
1
1
3
3
3
3
3
1
1
3
3
3
1190950 (02/09)
B
ROILER