Section 7: Troubleshooting - Lavit LB115 Service Manual

Section 7: Troubleshooting

Potential problems and solutions.
Condition
Water dripping After the dispensing of a sparkling beverage or sparkling water several
continuously drops may occur as the sparkling water in the water line heats up and
from the expands. This is normal.
dispense area.
Continuously dripping water is caused by foreign material lodged in the
soda water solenoid. Remove the soda water solenoid per the instructions
on Page xx and disassemble the solenoid to remove any trapped material.
Leaking water Possible leak issues:
from the rear of
the unit. First – Check the still water drain plug and then check the inlet water line. If
those connections are dry and not the source of the water leak, remove the
top cover of the unit.
Inspect the connections on the top of the water tanks. Remove the ozone
generator to view all connections. Ensure all fittings are tight and dry.
Inspect the area around the top insulation seam towards the left side panel.
If there is wetness in that area the leak may be from the soda tank seal.
Other possible sources of a leak are the soda pump inlet fitting, the inlet
solenoid, or the cold tank drain connection. To inspect these areas, remove
the back panel per the instructions of Page XX. Inspect the soda pump inlet
fitting for leak at the quick connect insert. Inspect the connections to the
inlet solenoid. If those connections show no evidence of leaking and water is
captured in the area at the bottom of the cold-water tank, the water drain
connection to the tank may be the cause of the leak. Remove the insulation
from around the water tank drain pipe and inspect.
Other possible sources of leaks are the still water and recirculation pump
connections and the cooling coil connection running to and from the
compressor and condenser.
No Sparkling If the soda pump is not filling the soda tank properly then CO2 gas will be
Water Dispense, released at the dispense nozzle when you select a sparkling beverage or
CO2 gas only. sparkling water.
Possible Solution
42
TM170915-B