HearthStone Stowe DX 8322 Owner's Manual
  1. Manuals
  2. Brands
  3. HearthStone Manuals
  4. Gas Heater
  5. Stowe DX 8322
  6. Owner's manual
HearthStone Stowe DX 8322 Owner's Manual

HearthStone Stowe DX 8322 Owner's Manual

Gas-fired direct-vent heater
Hide thumbs Also See for Stowe DX 8322:
Table of Contents

Advertisement

Quick Links

Download this manual
f i r e - p a r t s . c o m
WARNING:
FOLLOW
THESE INSTRUCTIONS EXACTLY, IF NOT, A FIRE
OR
EXPLOSION
PROPERTY DAMAGE, PERSONAL INJURY OR
LOSS OF LIFE.
WARNING: DO NOT STORE OR USE GASOLINE
OR ANY OTHER FLAMMABLE VAPORS AND
LIQUIDS NEAR THIS OR ANY OTHER GAS
APPLIANCE.
WHAT TO DO IF YOU SMELL GAS:
Do not try to light any appliance.
Do not touch electrical switches; do not use the phone
in your building.
Immediately call your gas supplier from a phone
outside the structure. Follow your gas supplier's
instructions.
If you cannot reach your gas supplier, call the fire
department or 911.
A qualified installer, service agency, or gas supplier must
perform installation and service of this appliance. In the
Commonwealth of Massachusetts, all installation of gas
lines and gas fittings must be performed by a licensed gas
fitter or licensed plumber.
THE
INFORMATION
MAY
RESULT
CAUSING
GAS-FIRED DIRECT-VENT HEATER
Read This Manual in Its Entirety
Operate And Maintain This Gas Heater
According To This Instruction Manual.
IN
AVERTISSEMENT:
SUIVRE
LES
CETTE NOTICE POUR RÉDUIRE AU MINIMUM LE
RISQUE D'INCENDIE OU POUR ÉVITER TOUT
DOMMAGE MATÉERIEL, TOUTE BLESSURE OU
LA MORT.
AVERTISSEMENT: NE PAS ENTRESPOSER NI
UTILISER D'ESSENCE NI D'AUTRE VAPERURS
OU
LIQUIDES
VOISINAGE DE CET APPRAREIL OU DE TOUT
AUTRE APPAREIL.
QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:
Ne pas tenter d'allumer d'appareil.
Ne touchez à aucun interrupteur. Ne pas vous servir
des téléphones se trouvant dans le batiment où vous
vous trouvez.
Appelez immédiatement votre fournisseur de gaz
depuis un voisin. Suivez les instructions du
fournisseur.
Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service dos incendies.
L'installation et service doit être exécuté par un qualifié
installer, agence de service ou le fournisseur de gaz.
Hearthstone Quality Home Heating Products, Inc. ®
Stowe DX
(Model 8322)
Owner's Manual
Installation & Operating
Instructions
SAVE THESE INSTRUCTIONS!
ASSUREZ-VOUS
INSTRUCTIONS
DONNÉ
INFLAMMABLES
Stowe Model 8322
Manual: 6400-40449
R: 4 - 4/17/2013
DE
BIEN
DANS
DANS
LE

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Stowe DX 8322 and is the answer not in the manual?

Questions and answers

Related Manuals for HearthStone Stowe DX 8322

Summary of Contents for HearthStone Stowe DX 8322

  • Page 1 Hearthstone Quality Home Heating Products, Inc. ® Stowe Model 8322 Manual: 6400-40449 R: 4 - 4/17/2013...
  • Page 2 Intentionally Blank f i r e - p a r t s . c o m...
  • Page 3 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Information Sheet Use this page to record all relevant information concerning the purchase, installation, and maintenance of your Stowe Model 8322 Direct -Vent heater. This information will facilitate servicing, purchase of replacement parts, and warranty claims (if necessary).

  • Page 4: Table Of Contents

    Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Table of Contents ................................5 NTRODUCTION ..............................6 AFETY NFORMATION & F ........................ 9 ROFLAME ONTROL YSTEM EATURES Stowe 8322 DX Model Overview ..........................9 Control Functions ..............................11 ............................... 13 PECIFICATIONS ............................

  • Page 5: Introduction

    Six (6) blower speeds, Model 8322, Gas-Fired Direct-Vent heater. The adjustable via the remote Stowe, by Hearthstone, incorporates the latest in b. Thermostatic mode to turn on/off based direct vent gas technology, which will provide you upon room temperature.

  • Page 6: Safety Information

    Use of any components not supplied by CAN/CGA B149 Installation Code. (Installer Hearthstone on the stove voids all warranties. Do l’appareil selon les codes ou réglements locaux, ou, not substitute components. en l’absence de tells réglements, selon les Codes d’installation CAN/CGA B149.) Proper Fuel...
  • Page 7 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 AUTRE PERSONNE À RISQUE D’AVOIR ACCÈS À COMPARTIMENT DES COMMANDES SONT PROPRES. VOIR LES INSTRUCTIONS LA PIÈCE ET AUX SURFACES CHAUDES. D’INSTALLATION ET D’UTILISATION QUI CLOTHING OR OTHER FLAMMABLE MATERIAL ACCOMPAGNENT L’APPAREIL.)

  • Page 8: Hearthstone Quality Home Heating Products, Inc. Stowe Dx Model

    Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 f i r e - p a r t s . c o m...

  • Page 9: Proflame Control System & Features

    Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Proflame Control System & Features NOTE: OPEN DOOR UNDER THE ASH LIP AND REMOVE MODESTY PANEL FOR ACCESS TO ELECTRICAL AND GAS CONNECTIONS. Stowe 8322 DX Model Overview Proflame GTMF System f i r e - p a r t s .
  • Page 10 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Proflame DFC Ignition Module Receiver This is the command center for the appliance. The The Receiver accepts commands via radio frequency DFC Module allows the pilot to run in the Intermittent from the Remote to operate the appliance.

  • Page 11: Control Functions

    Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Control Functions Pilot Mode Continuous Pilot (CPI): Running the Stowe 8322 in CPI mode will keep your pilot running even when the thermostat does not call for heat and when the burner is not lit. This is an advantage in cold climates or under windy conditions.
  • Page 12 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Remote Transmitter f i r e - p a r t s . c o m Figure 4 – Remote Transmitter Function Keys (remote color may differ from shown) ON/OFF Key: Controls the main burner, blower, and Mode Key: Toggles through the component to be the modulation of both.

  • Page 13: Specifications

    Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Specifications : Gas-Fired Direct-Vent Fireplace Heater Certified for use by: ISTED Model: Stowe DX Direct-Vent Gas Fireplace Board of State Examiners of Plumbers & Gasfitters Heater (8322) 100 Cambridge Street, Room 1511...

  • Page 14: Installation Preparation

    Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Installation Preparation Codes Items Required for Installation Adhere to all local codes or, in their absence, the External regulator (for propane (LP) only) latest edition of THE NATIONAL FUEL GAS CODE LP conversion kit (not included, for propane ANSI Z223.1 (NFPA 54) or CAN/CGA B149 (Installer...

  • Page 15: Unpacking And Inspection

    Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 See the firebox access instructions on page 16. Unpacking and Inspection Unpack and inspect the logs for damage. Inspect the Hearthstone packages your Stowe to withstand ceramic burner. Open the other boxes and inspect normal shipment without damage.
  • Page 16 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Firebox Access 2. Release the front panel by disengaging the two spring clips at its top – tilt the front toward you 1. Remove the grill and top of the stove (lift off). Set slightly and lift it up out of the bottom slots and carefully aside on a soft surface.

  • Page 17: Clearances To Combustibles

    Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Clearances to Combustibles Note: Ensure clearances are in accordance with local installation codes requirements supplier. Dégagement conforme codes d’installation locaux et aux exigences du foumisseunde gaz. Clearance to Combustibles Due to high surface temperatures, locate the unit out of traffic areas and away from furniture and draperies.
  • Page 18 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 The corner clearance for the Stowe 8322 is 4”, measured from the edge of the top castings, to the adjacent wall. f i r e - p a r t s . c o m...

  • Page 19: Venting Information

    Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Venting Information Approved Venting Configurations Venting Components Starter collar is installed by Hearthstone. WARNING: HIGH WIND AREAS PARTICULARLY COLD CLIMATES IT MAY BE Use the following instructions along with the pipe NECESSARY TO HEAT YOUR VENT SYSTEM manufacturer’s...
  • Page 20 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 All termination caps must be no less than 18” The maximum length of vent is 35’. (457mm) horizontally from any roof or vertical The liner must have an inside dimension or diameter 6”...
  • Page 21 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 f i r e - p a r t s . c o m Figure 16 - Acceptable Direct Vent Terminal Vent Cap Locations A = Clearance above grade, veranda, porch, deck, H = *Not to be installed within 15 feet (4.5m) above...

  • Page 22: Minimum Venting Installation Instructions

    Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Minimum Venting Installation Instructions 1. Install the 45º elbow over the outer collar. Place the elbow so that the twist lock end is pointing 2. Install one of the 9” pipe sections into the elbow by fully inserting it and turning approximately ¼...
  • Page 23 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 the fully opened position. This ensures proper Restrictor Plate flames for a wide variety of vent configurations and The restrictor plate is used to control excess draft if efficiency. The restrictor plate consists of a rotating necessary.
  • Page 24 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 f i r e - p a r t s . c o m Figure 21 - Venting Termination Diagram...

  • Page 25: Electrical System Information

    Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Electrical System Information CAUTION: LABEL ALL WIRES PRIOR TO DISCONNECTION WHEN SERVICING CONTROLS. WIRING ERRORS CAN CAUSE IMPROPER AND DANGEROUS OPERATION. VERIFY PROPER OPERATION AFTER SERVICING. (ATTENTION: AU MOMENT DE L’ENTRETIEN DES COMMANDES, ÉTIQUETEZ TOUS LES FILS AVANT LE DÉBRANCHEMENT.
  • Page 26 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 f i r e - p a r t s . c o m Figure 23 - Proflame GTMF Component Specifications...

  • Page 27: Gas Supply & Connections

    RÈGLEMENTS, SELON CODES D'INSTALLATION CAN/CGA-B149 NFPA Code and Hearthstone require the use of a dedicated sediment trap just upstream of the Figure 25 - Sediment Trap (Typical) unit. Damage to the valve, or other components due to the lack of a sediment trap are not...

  • Page 28: Gas Connections

    (NG) and requires conversion for use with propane (LP). You must purchase and install a propane (LP) fuel conversion kit if required for your installation. Use kit 97-56104. Contact your Hearthstone dealer. Gas Supply This appliance and its individual shutoff valve must be disconnected from the gas supply piping system f i r e - p a r t s .

  • Page 29: Heat Wave Baffle, Log Set, & Screen Placement

    Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Heat Wave Baffle, Log Set, & Screen Placement CAUTION: FRAGILE! HANDLE LOG SET WITH CARE. ALWAYS WEAR GLOVES AND SAFETY GOGGLES WHILE HANDLING THE LOG SET. WARNING: FAILURE TO POSITION THE PARTS IN...

  • Page 30: Installation Of The Log Set

    Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 2. Place log 1 on support bracket as shown. Figure 31 – Log 1 Mounting Detail Figure 29 – Baffle Mounting Bolt 5. Do not over tighten the bolt as it may damage or break the baffle.

  • Page 31: Removal Of Log Set

    Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 4. Place log 3 onto the end of log 1 as shown. Figure 36 – Log 5 Position 7. Place small tufts of the Platinum Bright Embers Figure 34 – Log 3 Position on the burner and log surfaces for additional glow as desired –...

  • Page 32: Lighting & Operation

    Pilot Light Warning unit is ready to be lit and adjusted to its particular installation. Hearthstone tests each unit prior to Do not attempt to light the unit with a match or by shipment, so ignition should take place without any means other than the ignition system supplied issue.
  • Page 33 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Some conditions cannot be corrected through air shutter adjustment; an adjustment must be made to the gas supply pressure or by changing the restriction plate setting. Qualified service personnel must perform supply line/manifold gas line pressure adjustments and restrictor plate adjustments.

  • Page 34: Daily Operation

    Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Note: Very little movement is needed to substantially personnel. unit controlled change the burn and flame patterns. Some ON/REMOTE/OFF switch on the Receiver or by the conditions cannot be corrected through air shutter Remote Control.
  • Page 35 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 operation of the unit and contact qualified service personnel. To Turn off Gas and Shut Down the Appliance: 1. Close the shut-off in the gas supply to the valve. 2. Set the thermostat to the “OFF” position...

  • Page 36: Routine Maintenance And Care

    For replacement parts, or for information about parts or service, contact your local Hearthstone dealer. Annually: Any safety screen or guard removed for servicing an appliance must be replaced prior to Clean Firebox, Pilot, &...

  • Page 37: As Needed

    97-56110 compartment. Authorized Hearthstone Dealer. Your Stowe uses a f i r e - p a r t s . c o m 2. Install four new AA batteries. Ensure you orient folded flat fiberglass gasket to make a tight seal the batteries correctly as indicated on the battery between the glass frame and the firebox.

  • Page 38: Parts List

    XX = Finish (e.g. 10 = Matte Black Paint) – Specify finish required when ordering parts WARNING: DO NOT SUBSTITUTE MATERIALS. FOR REPLACEMENT PARTS, OR FOR INFORMATION ABOUT PARTS OR SERVICE, CONTACT YOUR AUTHORIZED HEARTHSTONE RETAILER. For the name of the authorized retailer nearest to you, visit our website www.hearthstonestoves.com...

  • Page 39: Troubleshooting

    Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Troubleshooting Symptom Possible Cause Corrective Action 1. Pilot will not light. A. Power supply not plugged in A. Ensure power supply is plugged in and receiving 120V and/or batteries are dead.
  • Page 40 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Symptom Possible Cause Corrective Action 5. Frequent pilot outage A. Pilot flame may be too low or A. Clean and/or adjust the pilot flame for maximum problem in CPI mode.

  • Page 41: Rating Label

    Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Rating Label f i r e - p a r t s . c o m...

Table of Contents