Table of Contents
Advertisement
Quick Links
WARNING:
FOLLOW
THESE INSTRUCTIONS EXACTLY, IF NOT, A FIRE
OR
EXPLOSION M
PROPERTY DAMAGE, PERSONAL INJURY OR
LOSS OF LIFE.
WARNING: DO NOT STORE OR USE G ASOLINE
OR ANY OTHER FL AMMABLE VAPORS AND
LIQUIDS NEAR THIS O R ANY OTHER G AS
APPLIANCE.
WHAT TO DO IF YOU SMELL GAS:
Do not try to light any appliance.
Do not touch electrical switches; do not use the phone
in your building.
Immediately call your gas supplier from a phone
outside the structure. Follow your gas supplier's
instructions.
If you cannot reach your gas supplier, call the fire
department or 911.
A qualified installer, service agency, or gas supp lier must
perform installation and service of this app liance. In the
Commonwealth of M assachusetts, all installation of gas
lines and gas fittings must be performed by a licensed gas
fitter or licensed plumber.
THE
INFORMATION
AY
RESULT C
AUSING
GAS-FIRED DIRECT-VENT HEATER
Read This Manual in Its Entirety
Operate And Maintain This Gas Heater
According To This Instruction Manual.
IN
AVERTISSEMENT:
SUIVRE
LES INSTRUCTIONS DONNÉ D
CETTE NOTICE POUR RÉ DUIRE AU MINIMUM LE
RISQUE D'INCENDIE OU
DOMMAGE MATÉERIEL, TOUTE BLESSURE O U
LA MORT.
AVERTISSEMENT: NE P AS ENTRESPOSER NI
UTILISER D'ESSENCE NI
OU
LIQUIDES
VOISINAGE DE CET APPRAREIL OU DE TOUT
AUTRE APPAREIL.
QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:
Ne pas tenter d'allumer d'appareil.
Ne touchez à aucun interrupteur. Ne pas vous servir
des téléphones se trouvant dans le batiment où vous
vous trouvez.
Appelez immédiatement votre fournisseur de gaz
depuis un voisin. Suivez les instructions du
fournisseur.
Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service dos incendies.
L'installation et service doit être exécuté par un qu alifié
installer, agence de service ou le fournisseur de gaz.
Hearthstone Quality Home Heating Products, Inc. ®
Stowe DX
(Model 8322)
Owner's Manual
Installation & Operating
Instructions
SAVE THESE INSTRUCTIONS!
ASSUREZ-VOUS
POUR ÉVITER TOUT
D'AUTRE VAPERURS
INFLAMMABLES
Stowe Model 8322
Manual: 6400-40449
R: 3 - 5/23/2011
DE BIEN
ANS
DANS
LE
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for HearthStone Stowe DX 8322
Summary of Contents for HearthStone Stowe DX 8322
- Page 1 L’installation et service doit être exécuté par un qu alifié fitter or licensed plumber. installer, agence de service ou le fournisseur de gaz. Hearthstone Quality Home Heating Products, Inc. ® Stowe Model 8322 Manual: 6400-40449 R: 3 - 5/23/2011...
- Page 2 Intentionally Blank...
- Page 3 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Information Sheet Use this page to record all relevant information concerning the purchase, installation, and maintenance of your Stowe Model 8322 Direct -Vent heater. This information will facilitate servicing, purchase of replacement parts, and warranty claims (if necessary).
-
Page 4: Table Of Contents
Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Table of Contents ................................5 NTRODUCTION ..............................6 AFETY NFORMATION & F ........................9 ROFLAME ONTROL YSTEM EATURES Stowe 8322 DX Model Overview ..........................9 Control Functions ..............................11 ...............................13 PECIFICATIONS ............................14 NSTALLATION REPARATION Codes .................................. -
Page 5: Introduction
Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Introduction Congratulations on you r purchase of the Stowe ii. Six (6) blower speeds, Model 8322, Gas-Fired Direct-Vent heater. The adjustable via the remote Stowe, by Hearth stone, incorporates the latest in b. -
Page 6: Safety Information
Use of any components not supplied by CAN/CGA B149 Installation Code. (Installer Hearthstone on the stove voids all wa rranties. Do l’appareil selon les codes ou réglements locaux, ou, not substitute components. en l’absence de tells réglements, selon les Codes d’installation CAN/CGA B149.) Proper Fuel... - Page 7 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 COMPARTIMENT DES COMMANDES SONT AUTRE PERSONNE À RISQUE D’AVOIR ACCÈS À PROPRES. VOIR LES INSTRUCTIONS LA PIÈCE ET AUX SURFACES CHAUDES. D’INSTALLATION ET D’UTILISATION QUI CLOTHING OR OTHER FLA MMABLE MATERIAL ACCOMPAGNENT L’APPAREIL.)
-
Page 8: Hearthstone Quality Home Heating Products, Inc. Stowe Dx Model
Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322... -
Page 9: Proflame Control System & Features
Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Proflame Control System & Features NOTE: OPEN DOOR UNDER THE ASH LIP AND REMOVE MODESTY PANEL FOR ACCESS TO ELECTRICAL AND GAS CONNECTIONS. Stowe 8322 DX Model Overview Proflame GTMF System Figure 1 –... - Page 10 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Proflame DFC Ignition Module Receiver This is the comman d center for the a ppliance. The The Receiver accepts commands via radio frequency DFC Module allows the pilot to run in th e Intermittent from the Re mote to operate the a ppliance.
-
Page 11: Control Functions
Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Control Functions Pilot Mode Continuous Pilot (CPI): Running the Stowe 8322 in CPI mode will keep your pilot running even when the thermostat does not call for heat and when the burner is not lit. This i s an advantage in cold climates or under windy conditions. - Page 12 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Remote Transmitter Figure 4 – Remote Transmitter Function Keys (remote color may differ from shown) ON/OFF Key: Controls the main burner, blower, and Mode Key: Toggles through the component to be the modulation of both.
-
Page 13: Specifications
Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Specifications : Gas-Fired Direct-Vent Fireplace Heater Certified for use by: ISTED Model: Stowe DX Direct-Vent Gas Fireplace Board of State Examiners of Plumbers & Gasfitters Heater (8322) 100 Cambridge Street, Room 1511... -
Page 14: Installation Preparation
Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Installation Preparation Codes Items Required for Installation Adhere to all local codes or, i n their absence, the External regulator (for propane (LP) only) latest edition of THE NATIONAL FUEL GAS CODE LP conversion kit (not included, for propane ANSI Z223.1 (NFPA 54) or CAN/CGA B149 (Installer... -
Page 15: Unpacking And Inspection
Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Unpacking and Inspection See the fi rebox access instructions on page 16. Unpack and inspect the logs for damage. Inspect the Hearthstone packages your Stowe to withstand ceramic burner. Open the other boxes and inspect normal shipment without damage. - Page 16 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 2. Release the front panel by disengaging the two Firebox Access spring clips at its top – tilt the front toward you 1. Remove the grill and top of the stove (lift off). Set...
-
Page 17: Clearances To Combustibles
Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Clearances to Combustibles Note: Ensure clearances are in accordanc e with local installation codes requirements of th supplier. Dégagement conforme codes d’installation locaux et aux exigences du foumisseunde gaz. Clearance to Combustibles... - Page 18 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 The corner clearance for the Stowe 8322 i s 4”, measured from the ed ge of the top castings, to the adjacent wall. Figure 14 - Corner Clearance Figure 13 - Snorkel Termination Mantle...
-
Page 19: Venting Information
Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Venting Information Venting Components Approved Venting Configurations Starter collar is installed by Hearthstone. WARNING: HIGH WIND AREAS PARTICULARLY COLD C LIMATES IT M AY BE Use the follo wing instructions along with the pip e NECESSARY TO HE AT YOUR VENT SYSTEM manufacturer’s... - Page 20 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 All termination caps must be no less than 18” The maximum length of vent is 35’. (457mm) horizontally from any roof or vertical The liner must have an inside dimension or surface.
- Page 21 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Figure 16 - Acceptable Direct Vent Terminal Vent Cap Locations A = Clearance above grade, veranda, porch, deck, H = *Not to be installed within 15 feet (4.5m) above or balcony: 12 inches (30cm) minimum.
-
Page 22: Minimum Venting Installation Instructions
Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Minimum Venting Installation Instructions 1. Install the 45º elbow over the outer collar. Place the elbow so that the twist lock e nd is pointing 2. Install one of the 9” pip e sections into the elbow by fully inserting it and turning ap proximately ¼... - Page 23 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Restrictor Plate the fully opened p osition. This en sures proper flames for a wide variety of vent co nfigurations and The restrictor plate is used to control excess draft if efficiency.
- Page 24 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Figure 21 - Venting Termination Diagram...
-
Page 25: Electrical System Information
Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Electrical System Information CAUTION: LABEL ALL WIRES PRIOR TO DISCONNECTION WHEN SERVICING CONT ROLS. WIRING ERRORS CAN CAUSE IMPROPER AND DANGEROUS OPERATION. VERIFY PROPER OPER ATION AFTER SERVICING. (ATTENTION: AU MOMENT DE L’ENTRETIEN DES COMMANDES, ÉTIQUETEZ TOUS LES FILS AVANT LE DÉBRANCHEMENT. - Page 26 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Figure 23 - Proflame GTMF Component Specifications...
-
Page 27: Gas Supply & Connections
RÈGLEMENTS, SELON CODES D'INSTALLATION CAN/CGA-B149 NFPA Code and Hearthstone require the use of a dedicated sediment trap just u pstream of the Figure 25 - Sediment Trap (Typical) unit. Damage to the valve, or othe r components due to the lack of a se diment trap are not... -
Page 28: Gas Connections
(NG) and req uires conversion for use with propane (LP). You must purchase and install a propane (LP) fuel conversion kit if req uired for your installation. Use kit 97-56104. Contact your Hearthstone dealer. Gas Supply This appliance and its i ndividual shutoff valve mu st... -
Page 29: Heat Wave Baffle, Log Set, & Screen Placement
Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Heat Wave Baffle, Log Set, & Screen Placement CAUTION: FRAGILE! HANDLE LOG SET WITH CARE. ALWAYS WEAR GLOVES AND SAFETY GOGGLES WHILE HANDLING THE LOG SET. WARNING: FAILURE TO POSITION THE PARTS IN... -
Page 30: Installation Of The Log Set
Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 2. Place log 1 on support bracket as shown. Figure 31 – Log 1 Mounting Detail Figure 29 – Baffle Mounting Bolt 5. Do not over tighten the bolt as it may damage or break the baffle. -
Page 31: Removal Of Log Set
Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 4. Place log 3 onto the end of log 1 as shown. Figure 36 – Log 5 Position 7. Place small tufts of the Platinum Bright Embers Figure 34 – Log 3 Position on the burner and log surfaces for a dditional glow as desired –... -
Page 32: Lighting & Operation
Pilot Light Warning installation. Hearthstone tests each unit prior t o Do not attempt to light the unit with a match o r by shipment, so ignition sh ould take pl ace without any means other than th e ignition sy stem supplied issue. - Page 33 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Some conditions cannot be corrected through air shutter adjustment; an adjustment must be made to the gas supply pressure or by changi ng the restriction plate setting. Q ualified service personnel must perform supply line/manifold gas line pressure adjustments and restrictor plate adjustments.
-
Page 34: Daily Operation
Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Note: Very little movement is needed to substantially personnel. unit i s controlled via the change the burn a nd flame p atterns. Some ON/REMOTE/OFF switch on the Receiver or by the conditions cannot be corrected th rough air shutter Remote Control. - Page 35 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 operation of the unit an d contact qualified service personnel. To Turn off Gas and Shut Down the Appliance: 1. Close the sh ut-off in the gas supply to the valve.
-
Page 36: Routine Maintenance And Care
For replacement parts, or for information about parts or service, contact your local Hearthstone dealer. Annually: Any safety screen or guard removed for servicing an appliance must be replaced prior to Clean Firebox, Pilot, &... -
Page 37: As Needed
97-56110 compartment. Authorized Hearthstone Dealer. Your Stowe u ses a 2. Install four new AA batteries. Ensure you orient folded flat fibergl ass gasket to ma ke a tight seal the batteries correctly as indicated on the battery between the glass frame and the firebox. -
Page 38: Parts List
XX = Finish (e.g. 10 = Matte Black Paint) – Specify finish required when ordering parts WARNING: DO NOT SUBSTITUTE MATERIALS. FOR REPLACEMENT PARTS, OR FOR INFORMATION ABOUT PARTS OR SERVICE, CONTACT YOUR AUTHORIZED HEARTHSTONE RETAILER. For the name of the authorized retailer nearest to you, visit our website www.hearthstonestoves.com... -
Page 39: Troubleshooting
Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Troubleshooting Symptom Possible Cause Corrective Action 1. Pilot will not light. A. Power supply not plugged in A. Ensure power supply is plugged in and receiving 120V and/or batteries are dead. - Page 40 Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Symptom Possible Cause Corrective Action 5. Frequent pilot outage A. Pilot flame may be too low or A. Clean and/or adjust the pilot flame for maximum problem in CPI mode.
-
Page 41: Rating Label
Hearthstone Quality Home Heating Products, Inc. Stowe DX Model 8322 Rating Label...
Need help?
Do you have a question about the Stowe DX 8322 and is the answer not in the manual?
Questions and answers