Annual Servicing; Replacement Of Air Cleaner Element; Checking Of Egr Piping; Checking Of Intake Air Line - Kubota D1803-CR-TIE4 Operator's Manual

ANNUAL SERVICING

BReplacement of air cleaner element
Consult your local KUBOTA Dealer for this service.
(See "Cleaning of air cleaner element" in "EVERY 100
SERVICE HOURS [D1803-CR-TIE4, V2403-CR-TIE4]"
and "EVERY 250 SERVICE HOURS [V2607-CR-TIE4,
V3307-CR-TIE4, V3800-TIE4]" in "REGULAR CHECKS
AND MAINTENANCE WORK" section.)
BChecking of EGR piping
Consult your local KUBOTA Dealer for this service.
BChecking of intake air line
Visually check for cracks, gas leak and anything else
unusual.
Check to see if the lock bolts and nuts are tight enough.
In particular, the hose between the turbo-charger and the
intake manifold must be checked for cracks and come-off.
This is because this line will be under high pressure.
See if this hose is deep enough into the pipe. If not,
reinsert the hose deeper. Put the clamp on the hose free
of the bulge of the pipe, and tighten the clamp bolt to the
specified torque.
BChecking of exhaust manifold for cracks
or gas leak and for looseness or damage
Visually check for cracks, damages, gas leak and
anything else unusual.
Check to see if the lock bolts and nuts are tight enough.
REGULAR CHECKS AND MAINTENANCE WORK

BIENNIAL SERVICING

BReplacement of rubber piping related oil
separator
Consult your local KUBOTA Dealer for this service.
BReplacement of intake air line and suction
air pressure takeout rubber piping
Consult your local KUBOTA Dealer for this service.
BReplacement of boost sensor pressure
rubber piping
[V2607-CR-TIE4, V3307-CR-TIE4, V3800-TIE4]
Consult your local KUBOTA Dealer for this service.
BReplacement of EGR cooler rubber piping
Consult your local KUBOTA Dealer for this service.
BReplacement of water rubber piping
Consult your local KUBOTA Dealer for this service.
BReplacement of lubricant rubber piping
Consult your local KUBOTA Dealer for this service.
BChanging of radiator coolant (L.L.C.)
1. To drain coolant, always open both drain shutoff-
valves and simultaneously open the radiator cap as
well. With the radiator cap kept closed, a complete
drain of water is impossible.
2. Remove the overflow pipe of the radiator pressure cap
to drain the recovery tank.
3. Prescribed coolant volume (U.S.gallons)
Models
D1803-CR-TIE4
V2403-CR-TIE4
V2607-CR-TIE4
V3307-CR-TIE4
V3800-TIE4
A Coolant quantities shown are for standard radiators.
4. An improperly tightened radiator cap or a gap between
the cap and the seat quickens loss of coolant.
5. Coolant (Radiator cleaner and anti-freeze)
Season
All seasons
27
Quantity
5.8 L (1.53 U.S.gals.)
8.4 L (2.22 U.S.gals.)
6.0 L (1.32 U.S.gals.)
6.3 L (1.67 U.S.gals.)
9.0 L (2.38 U.S.gals.)
Coolant
Pure water and anti-freeze
(See "Anti-freeze" in
"DAILY CHECKS" in
"MAINTENANCE" section.)