Replacement Of Fuel Filter Cartridge; Cleaning Of Water Separator; Removal Of Sediment In Fuel Tank; Cleaning Of Water Jacket (Radiator Interior) - Kubota D1803-CR-TIE4 Operator's Manual

[V2607-CR-TIE4, V3307-CR-TIE4]
(1) Oil filter cartridge
[V3800-TIE4]
(1) Oil filter cartridge
(2) Remove with a filter wrench (Tighten with your hand)
5. After the new cartridge has been replaced, the engine
oil level normally decreases a little. Thus, run the
engine for a while and check for oil leaks through the
seal before checking the engine oil level. Add oil if
necessary.
A Wipe off any oil sticking to the machine completely.
REGULAR CHECKS AND MAINTENANCE WORK
BReplacement of fuel filter cartridge
[V2607-CR-TIE4, V3307-CR-TIE4, V3800-TIE4]
1. Replace the fuel filter cartridge with a new one every
500 operating hours.
2. Apply fuel oil thinly over the gasket and tighten the
cartridge into position by hand-tightening only.
3. Finally, vent the air.
A Replace the fuel filter cartridge periodically to prevent
wear of the supply pump or the injector, due to dirt in
the fuel.
A The fuel filter cartridge and water separator should be
replaced earlier according to the fuel classification in
use.
BCleaning of water separator
(See "Draining of water separator" in "EVERY 50
SERVICE HOURS" in "REGULAR CHECKS AND
MAINTENANCE WORK" section.)
BRemoval of sediment in fuel tank
Consult your local KUBOTA Dealer for this service.
BCleaning of water jacket (radiator interior)
Consult your local KUBOTA Dealer for this service.
BReplacement of fan belt
Consult your local KUBOTA Dealer for this service.
(See "Adjustment of fan belt tension" in "EVERY 100
SERVICE HOURS" or "EVERY 250 SERVICE HOURS"
in "REGULAR CHECKS AND MAINTENANCE WORK"
section.)

EVERY 800 SERVICE HOURS

BChecking of valve clearance
[D1803-CR-TIE4, V2403-CR-TIE4]
Consult your local KUBOTA Dealer for this service.

EVERY 1000 SERVICE HOURS

BChecking of valve clearance
[V2607-CR-TIE4, V3307-CR-TIE4, V3800-TIE4]
Consult your local KUBOTA Dealer for this service.
25