Table of Contents
Advertisement
Quick Links
IMPORTANT: READ THESE INSTRUCTIONS CAREFULLY BEFORE STARTING INSTALLATION OR USE.
DANGER:
IF YOU SMELL GAS:
1. Shut off the gas to the appliance.
2. Extinguish any open fl ame.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or the fi re department.
CODE AND SUPPLY REQUIREMENTS: This
grill must be installed in accordance with local
codes and ordinances, or, in the absence of local
codes, with the latest National Fuel Gas Code
(ANSI Z223.1/NFPA 54), or Natural Gas and
Propane Storage and Handling Installation Code
(CSA-B149.1).
This appliance and its dedicated manual shutoff
valve must be disconnected from the gas-
supply piping system when testing the system at
pressures in excess of 1⁄2 psig (3.5 kPa).
WARNING:
Improper installation, adjustment, alteration,
service, or maintenance can cause injury or
property damage. For proper installation, refer
to the installation instructions. For assistance
or additional information, consult a qualifi ed
professional service technician, service agency,
or the gas supplier.
INSTALLER: Leave these instructions with the consumer.
CONSUMER: Retain for future reference
WARNINGS AND SAFETY CODES
GAS SERIES
OUTDOOR GAS GRILL
INSTALLATION INSTRUCTIONS
AND OWNER'S MANUAL
MODEL# G420C (Freestanding) G420H (Head only)
This appliance must be isolated from the gas-
supply piping system by closing its dedicated
manual shutoff valve during any pressure testing
of the gas-supply system at pressures up to and
including 1⁄2 psig (3.5 kPa).
Proper operation of your grill requires prompt
and periodic maintenance. See the CARE &
CLEANING section for details.
Keep all electrical-supply cords and fuel-supply
hoses away from any heated surface.
WARNING
WARNING:
1. Do not store or use gasoline or other
fl ammable vapors and liquids in the vicinity
of this or any other appliance.
2. An LP cylinder not connected for use shall
not be stored in the vicinity of this or any
other appliance.
PCG.rev04282017- 10:53
Advertisement
Table of Contents
Related Manuals for Primo Water G420C
Summary of Contents for Primo Water G420C
- Page 1 GAS SERIES OUTDOOR GAS GRILL INSTALLATION INSTRUCTIONS AND OWNER’S MANUAL MODEL# G420C (Freestanding) G420H (Head only) INSTALLER: Leave these instructions with the consumer. CONSUMER: Retain for future reference IMPORTANT: READ THESE INSTRUCTIONS CAREFULLY BEFORE STARTING INSTALLATION OR USE. WARNINGS AND SAFETY CODES...
- Page 2 PCG.rev04282017- 10:53...
- Page 3 INSTALLATION INSTRUCTIONS ET MANUEL DU PROPRIÉTAIRE PRIMO GRIL EXTÉRIEUR DE GAZ DU PORTATIF IMPORTANT: LISEZ CES INSTRUCTIONS SOIGNEUSEMENT AVANT DE COMMENCER OU L’INSTALLATION L’UTILISATION INSTALLATEUR : Laissez ces instructions avec le consommateur. CONSOMMATEUR : Maintenez pour la future référence. SÛRETÉ ET CODES D’AVERTISSEMENT •...
-
Page 4: Table Of Contents
TABLE OF CONTENTS Getting Started MODEL SPECIFICATIONS ......................1 HEAD UNIT ONLY CUTOUT SPECIFICATIONS ............... 2 ENCLOSURE REQUIREMENTS ....................3 REPLACEMENT PARTS ......................4 GRILL MAINTENANCE & SAFETY .................... 5 INSTALLATION REQUIREMENTS .................... 6 PROPANE SAFETY INFORMATION ..................9 SAFE USE AND MAINTENANCE OF PROPANE GAS CYLINDERS ........10 Installation INSTALLATION ........................ -
Page 5: Model Specifications
MODEL SPECIFICATIONS Main (High Burner) NOTE: G420C (Freestanding) ships with LP #66 / NAT #56 N/P orifi ce drill size propane orifi ce installed. G420H Seconadary (Low Burner) (Head only) ships with natural gas LP #76 / NAT #70 N/P orifi ce drill size orifi ce installed. -
Page 6: Head Unit Only Cutout Specifications
G420H HEAD UNIT ONLY CUTOUT AND INSTALLATION Top View NOTE: 4-1/4” open space behind grill shroud is required for hinge clearance. NOTE: 10" of clearance from back of hinge required to open lid. 4-1/4” of open space behind grill 4-1/4” of open space behind grill 27-1/2”... -
Page 7: Enclosure Requirements
ENCLOSURE REQUIREMENTS VENTILATION (ALL ENCLOSURES) Ventilation Requirements • 4 openings minium with 2 per side wall, spaced at 180º. For All Piping Systems and All Gas Types: (Natural • Top openings within 5” of countertop Gas, Household Propane, L.P. Cylinder) •... -
Page 8: Replacement Parts
REPLACEMENT PARTS PART NUMBER PART DESCRIPTION QTY HEAD CART • • 0142001 CERAMIC BOTTOM • • 0142002 CERAMIC TOP • • 0142003 INTERNAL STAINLESS STEEL BASKET • • 0142004 STAINLESS STEEL FLAVOR GRATE • • 0142005 STAINLESS STEEL COOKING GRATES •... -
Page 9: Grill Maintenance & Safety
GRILL MAINTENANCE & SAFETY 1. The outdoor grill and surrounding area MUST 5. The in-line gas valve or gas cylinder valve remain clear of flammable substances such must always be shut OFF when the grill is not as gasoline, yard debris, wood, etc. in use. -
Page 10: Installation Requirements
INSTALLATION REQUIREMENTS Installation must be performed by a qualified professional service technician. *Combustible overhead construction: This grill is designed for outdoor use only. DO Exhaust hood required Non-combustible overhead construction: NOT use this grill inside a building, garage, or Exhaust hood highly recommended enclosed area. - Page 11 INSTALLATION REQUIREMENTS SIDE AND REAR WALL CLEARANCES NOTE: 10" from back of hinge required to open lid. For the minimum clearances between the grill and any side or rear walls, your setup must fall 4” within one (or more) of the following: A.
- Page 12 INSTALLATION REQUIREMENTS The control panel MUST remain removable for servicing (see PARTS LIST). ENSURE PROPER COMBUSTION AIR AND COOLING AIRFLOW Proper airflow MUST be maintained for the grill to perform as it was designed. If airflow is blocked, overheating and poor combustion will result. Do not block air inlet along the bottom of the control panel or more than 75% of the cooking grid surface with pans or griddles.
-
Page 13: Propane Safety Information
PROPANE SAFETY INFORMATION WHEN OPERATING THIS APPLIANCE WITH PROPANE, ALL INSTRUCTIONS AND WARNINGS MUST BE OBSERVED. FAILURE TO DO SO MAY RESULT IN A FIRE OR EXPLOSION CAUSING SERIOUS INJURY OR DEATH. WARNING OPERATING THE UNIT SAFELY AND CORRECTLY THIS APPLIANCE MUST BE INSTALLED AND OPERATED ACCORDING TO THE Every time you use the unit, make sure that: INFORMATION BELOW. -
Page 14: Safe Use And Maintenance Of Propane Gas Cylinders
SAFE USE & MAINTENANCE OF PROPANE GAS CYLINDERS IMPORTANT FOR YOUR SAFETY READ AND FOLLOW ALL WARNINGS PROVIDED WITH THE PROPANE-GAS CYLINDER. When operating this appliance with a propane-gas cylinder, these instructions and warnings MUST be observed. FAILURE TO DO SO MAY RESULT IN A SERIOUS FIRE OR EXPLOSION. CYLINDER/CONNECTOR REQUIREMENTS valve. - Page 15 UTILISATION SÛRE ET ENTRETIEN DES CYLINDRES DE GAZ DE PROPANE MPORTANT POUR VOTRE SÛRETÉ LISEZ ET SUIVEZ TOUS LES AVERTISSEMENTS ÉQUIPÉS DE VOTRE CYLINDRE DE GAZ DE PROPANE. En actionnant cet appareil avec un cylindre de gaz de propane ON DOIT observer ces instructions et avertissements. LE MANQUE DE FAIRE AINSI PEUT AVOIR COMME CONSÉQUENCE UNE INCENDIE OU UNE EXPLOSION SÉRIEUSE CYLINDRE ET CONDITIONS ET CARACTÉRISTIQUES précision de fil de point culminant sur la valve de cylindre.
-
Page 16: Installation
INSTALLATION LOCATION PREPARATION INSTALL THE FLAVOR GRIDS Prepare a fl at, level surface capable of supporting the Place the fl avor grids directly onto the studs as shown weight of the stand-alone grill and convenient to the gas below. The fl avor grids allow heat from the burners to be supply if connecting to a gas line. -
Page 17: Install The Igniter Battery
INSTALLATION (continued) INSTALL THE IGNITER BATTERY DROP-SHELF OPERATION 1. Grasp the cap/botton of the igniter and unscrew it in a A. To lower the shelf, grasp the middle of the shelf on both counter-clockwise motion (see below). sides and lift upward until the shelf does not move upward any further. -
Page 18: Lighting/Ignition Instructions
LIGHTING (IGNITION) INSTRUCTIONS Read all instructions before lighting, and follow these instructions each time you light the unit. ELECTRONIC LIGHTING MANUAL LIGHTING CAUTION: Always wait fi ve (5) minutes for gas to clear 1. Open lid. after any unsuccessful lighting attempt. 2. - Page 19 ALLUMAGE DES INSTRUCTIONS (D’ALLUMAGE) Lisez toutes les instructions avant l’allumage, et suivez ces instructions chaque fois vous lumière le unité. ÉCLAIRAGE ÉLECTRONIQUE ÉCLAIRAGE MANUEL ATTENTION: Attendez toujours cinq (5) minutes le gaz 1. Ouvrez les couvercles. pour se dégager après que n’importe quelle tentative non 2.
-
Page 20: Convert Gas Type & Check Burner Orifices
CONVERT GAS TYPE / CHECK BURNER ORIFICES CAUTION: Make sure the grill is at a safe temperature and isolated from gas and electrical supplies before beginning. For your safety, exercise caution, and make sure you have adequate hand protection, such as gloves, when handling metal parts. -
Page 21: Burner Specifications And Installation Orientation
BURNER SPECIFICATIONS AND INSTALLATION ORIENTATION Manifold Tube diameter: 9/16” Hole diameter: 5/16“ Hole Spacing: 4-1/4” 23” High Burners left right Tube diameter: 1/2” .035 wall welded 304 stainless steel. 6” Hole diameter: .036” (2 rows of 103 ports ea. rotational spacing between rows 10º) 19 3/4”... -
Page 22: Control Panel Removal
CONTROL PANEL REMOVAL To remove the control panel: then make the connection. This will ensure conductivity and prevent moisture from affecting the 1. Turn the control knobs to the OFF position and turn off contact. the gas supply to the unit. Important: During reinstallation;... -
Page 23: Troubleshooting
TROUBLESHOOTING PROBLEM POSSIBLE CAUSE PREVENTION/CURE Burner will not light using igniter Low or dead battery. Replace battery. Wire(s) and/or electrode covered with Clean wire(s) and/or electrode with cooking residue. rubbing alcohol and clean swab Electrode(s) and burner are wet Wipe dry with cloth Electrode(s) cracked or broken Replace electrode(s) “sparks at crack”... -
Page 24: Care & Cleaning
CARE AND CLEANING DRIP TRAY GRILL MUST BE COMPLETELY COOL WHEN CLEANING. DO NOT SPRAY ANY CLEANER OR The drip collector allows you to brush or scrape LIQUIDS ON THE APPLIANCE WHEN HOT. residue from the grill’s inner liner into the drip tray. The appliance must be cleaned as often as once a Regular cleaning of the grill’s interior will help prevent month (depending on use) to prevent grease build-up... -
Page 25: Warranty
WARRANTY Creative Ceramic Technologies, Inc. (CCT) warrants to the original purchaser of this Primo Ceramic Grill that it is free of defects in material and workmanship at the date of purchase for the following periods: • Limited Lifetime Warranty Backed by a Twenty (20) year guarantee on all ceramic parts. •... - Page 26 PCG.rev04282017- 10:53...
- Page 27 PCG.rev04282017- 10:53...
- Page 28 3289 Montreal Industrial Way Tucker, GA 30084 770.492.3920 www.primogrill.com PCG.rev04282017- 10:53...