Page 1
For parts and technical support, call the Industrial Coating Systems Customer Support Center at (800) 433-9319 or contact your local Nordson representative. This document is subject to change without notice. Check http://emanuals.nordson.com for the latest version. NORDSON CORPORATION • AMHERST, OHIO • USA...
......Contact Us Notice This is a Nordson Corporation publication which is protected by copyright. Nordson Corporation welcomes requests for information, comments, and Original copyright date 2019. No part of this document may be inquiries about its products.
Page 3
Change Record Change Record Revision Date Change 03/19 New release. Part 1614813-01 E 2019 Nordson Corporation...
Page 4
Change Record Part 1614813-01 E 2019 Nordson Corporation...
Regulations and Approvals Make sure all equipment is rated and approved for the environment in which it is used. Any approvals obtained for Nordson equipment will be voided if instructions for installation, operation, and service are not followed. All phases of equipment installation must comply with all federal, state, and local codes.
Clean, maintain, test, and repair equipment according to the instructions in your equipment documentation. Use only replacement parts that are designed for use with original equipment. Contact your Nordson representative for parts information and advice. Part 1614813-01 E 2019 Nordson Corporation...
Disconnect and lock out electrical power. Close pneumatic shutoff valves and relieve pressures. Identify the reason for the malfunction and correct it before restarting the equipment. Disposal Dispose of equipment and materials used in operation and servicing according to local codes. Part 1614813-01 E 2019 Nordson Corporation...
HD Pump Cabinet Description The Encorer HD pump cabinet is configurable from four to eighteen pump modules. Figure 1 Encore HD Pump Module Cabinet (shown with 18 pump modules) 1. HD pump module 3. Hose tray panel 5. Base 2. Lifting rings 4.
Factory made connections 1. Pump module 3. Air hose from filter regulator 5. Filter regulator 2. Grounding point 4. Air connection from pump module 6. Pump module air lines to air tank (not shown) Part 1614813-01 E 2019 Nordson Corporation...
8.2 kg (18 lb) Sound Level Table NOTE: See Encore HD Pump Module manual for maximum sound level for an individual pump module. Base ambient sound level is 56 dBA. The maximum number of pumps that can be purged at one time is eight.
561 mm (22.09 in.) 340.3 mm 2197.2 mm (13.40 in.) (86.5 in.) 340.3 mm (13.40 in.) 1981.2 mm (78.00 in.) 1122.5 mm (44.19 in.) 980.7 mm (38.61 in.) Figure 3 Pump Module Cabinet Dimensions Part 1614813-01 E 2019 Nordson Corporation...
Installation Anchoring Pump Cabinet See Figure 4 for anchoring points. The Encore HD pump cabinet must be permanently anchored to the area where the pump cabinet is to be installed, either along side of the spray controller or in an area near the spray controller.
Pump and air tubes are labeled 1-18 from factory. Labels 19-36 are included in ship with system items. Figure 5 User Made Connections 1. Main air line connection 3. True earth grounding point 2. Air connection from tank Part 1614813-01 E 2019 Nordson Corporation...
Adding Additional Pump Module NOTE: When adding a pump module to the cabinet, cable and tubing for the pump module must be ordered separately. Refer to the Encore HD Pump Module manual for parts. 1. See Figure 7. Remove the blank plate (4), by removing the four button head socket screws (2) and a dished lock washer (3) behind the upper right hand socket screw.
A dash (—) is used when number does not apply. The number in the Part column is the Nordson Corporation part number. A series of dashes in this column (−−−−−−) means the part cannot be ordered separately.
Encore HD Pump Cabinet Pump Cabinet Configurations The Encore HD pump cabinet is available with four to eighteen pump modules, see the chart below for available configurations. Part Part Part Description Encore HD Encore HD+ Encore XD 1616016 1614537 1616031...
Encore HD Pump Cabinet Pump Cabinet Parts See Figure 3 and the following parts list to order parts. Figure 8 Pump Cabinet Parts Part 1614813-01 E 2019 Nordson Corporation...
Page 19
973410 S PLUG, pipe, socket, standard, ¼, zinc 1615942 KIT, cover, upper, pump cabinet, Encore HD 1615943 KIT, guide, hose pump cabinet, Encore HD NOTE A: This part number is common to all configurations of the pump. See page 13 to order the pump cabinet configured with number of pump modules.
Page 20
Encore HD Pump Cabinet Part 1614813-01 E 2019 Nordson Corporation...