Application Range; Qualified Refrigerants And Oils; Application Limits; Bill Of Material - Emerson Copeland EazyCool ZXDI Series Application Manuallines

2.6

Application range

2.6.1 Qualified refrigerants and oils

Qualified refrigerants
Qualified
servicing oils
Condensing
unit
Oil charge in litres
Table 1: Qualified refrigerants and oils
WARNING
Use of R450A and R513A refrigerants! Risk of compressor damage!
Migration of R450A or R513A into the compressor crankcase could cause low
oil viscosity, which could lead to compressor damage. When using R450A or
R513A it is critical to meet the following requirements:
▪ maintain adequate superheat settings with a minimum superheat of 8-10K;
▪ no liquid refrigerant migration into the compressor at any time, especially
during standstill, during or after defrost, or after reverse mode for example
in heat pumps;
▪ pump-down is not recommended;
▪ the use of a crankcase heater is mandatory;
▪ retrofit to R450A and R513A is only allowed for compressors which are
approved for these refrigerants.
Contact your local Application Engineering representative for any further
information.
NOTE: The ZXDI units are equipped with an oil separator. This separator is pre-charged
with 0.5 liter of oil.

2.6.2 Application limits

For application envelopes, please refer to the compressor application envelopes which can be
found in Copeland™ brand products Select software, available at www.emersonclimate.eu.
ZXDI indoor condensing units can be used at an ambient temperature from -15°C to 45°C. For
lower ambient temperatures please contact your local Application Engineering representative.
2.7

Bill of material

Introduction
BOM Family
554 ZXDI Jan/2018
Table 2: BOM
2.8

Main components description

2.8.1 Compressor

Condensing Compressor model
unit
ZXDI040E
ZXDI050E
ZXDI060E
ZXDI075E
* MOC = Maximum Operating Current
Table 3: Cross reference table units/compressor models
4
R404A, R407A, R407F, R448A, R449A
R134a, R450A, R513A
Emkarate RL 32 3MAF
Mobil EAL Arctic 22CC
ZXDI040E
1.36
Controller concept
date
XCM25D (Emerson - Dixell)
Compressor
(Digital)
ZBD29KQE-TFD
ZBD38KQE-TFD
ZBD45KQE-TFD
ZBD48KQE-TFD
ZXDI050E
ZXDI060E
ZXDI075E
1.89
Oil
separator
Yes
Compressor
LRA (A) MOC* (A)
48 7.9
64 11.3
74 11.4
100 14
Suction
accumulator
No
Unit rated
current (A)
11.3
14.7
14.8
17.4
C6.1.10/0118-0318/E