Subscribe to Our Youtube Channel
Related Manuals for Emerson Copeland Scroll XFAL Series
Summary of Contents for Emerson Copeland Scroll XFAL Series
- Page 1 Copeland Scroll Outdoor Refrigeration Unit ™ Installation and reference manual Models: XFAL, XFAM, XFAP 1.5 to 6 HP...
-
Page 2: Table Of Contents
6.20.3. Liquid Line Solenoid Control ....13 6.21. Enhanced Vapor Injection (EVI) for Low Temperature Units..........13 6.21.1. Low Temp EVI Discharge Line Temperature Protection Mode....13 6.21.1.1. Low Temp EVI Discharge Line Temperature Protection Error Handling ........ 14 © 2016 Emerson Climate Technologies, Inc. 552-7018-00... - Page 3 NOTICE NOTICE is used to address practices not related to personal injury. CAUTION, without the safety alert symbol, is used to address practices CAUTION not related to personal injury. © 2016 Emerson Climate Technologies, Inc.
- Page 4 • Refrigerant compressors must be employed only for their intended use. • install, commission and maintain this equipment. • • All valid standards and codes for installing, servicing, and maintaining electrical and refrigeration equipment must be observed. © 2016 Emerson Climate Technologies, Inc.
-
Page 5: Introduction
Discharge line temperature control is provided by enhanced vapor injection (EVI). Medium temperature XFAM units (0°F to +45°F saturated suction) include all the standard features. 2. Nomenclature – – – Base Model Electrical Bill of Material © 2016 Emerson Climate Technologies, Inc. -
Page 6: Electrical/Physical Data
For ground mounting, the units should be which this particular unit will need to operate. Follow the placed on a level solid concrete slab with rubber strips ASHRAE guidelines for proper piping practice. © 2016 Emerson Climate Technologies, Inc. -
Page 7: Quick Setup Guide
AE5-1412 R1 5. Quick Setup Guide © 2016 Emerson Climate Technologies, Inc. -
Page 8: User Interface
Flashing Fast access menu (Viewing set points and measured values) Browsing the alarm menu Flashing New alarm occurred An alarm is occurring In defrost or evap fan drip time when ON Evaporator fans enabled © 2016 Emerson Climate Technologies, Inc. -
Page 9: Button Descriptions And Key Combinations
Pon message is displayed. NOTE: The set value is stored even when the procedure is exited by waiting for the time-out to expire. NOTE: If a menu does not have any parameters available, noP will be displayed © 2016 Emerson Climate Technologies, Inc. -
Page 10: Changing Clock Setting
H t Not used R-448A tU1 Line voltage (1-phase) R-449A tU2 Line voltage (3-phase) tU3 Line voltage (3-phase) tA1 Current (1-phase) tA2 Current (3-phase) tA3 Current (3-phase) Menu © 2016 Emerson Climate Technologies, Inc. -
Page 11: Alarm Menu
End label. the set and up button are pressed together to exit, the After 10 seconds the controller will restart and begin controller will resume normal operation. © 2016 Emerson Climate Technologies, Inc. -
Page 12: Controller Startup
There are no reliability issues in this For three seconds the controller will display the application. program number (EX: 100, 101, 200, etc.) The controller will then wait 6 seconds before turning on the compressor or any other device. © 2016 Emerson Climate Technologies, Inc. -
Page 13: Crankcase Heater
40% before turning off. When a fan first turns on it will run for 3 seconds at full speed before it begins modulating. Fans will run for at least © 2016 Emerson Climate Technologies, Inc. -
Page 14: Defrost Controls
If the discharge temperature goes above 250°F, the compressor trips off and the control displays an E44 error. The compressor cannot turn back on until the temperature drops below 170°F and has been off for 3 minutes. © 2016 Emerson Climate Technologies, Inc. -
Page 15: Low Temp Evi Discharge Line Temperature Protection Error Handling
6.21.4. Low Temperature Units With EVI TXV the mid coil and ambient sensor. Selection For use with low temperature units with EVI, Emerson If the DLT sensor fails and a mid-coil temperature sensor recommends a balanced port TXV because it offers a is available, the injection valve will be opened based on wider operating range for floating liquid temperatures. -
Page 16: Incorrect Phase Sequence Protection (3 Phase Only)
3 legs for 1 second, the controller will display E22 and shut the unit down (based on a parameter PiC) for 5 minutes and until the phase imbalance is corrected. © 2016 Emerson Climate Technologies, Inc. -
Page 17: Fixed High Pressure Control
This relay has a 5 Amp limit, up to 250V. The alarm contact will close in the event of an alarm or lockout. © 2016 Emerson Climate Technologies, Inc. -
Page 18: Physical And Installation Requirements
AE5-1412 R1 8. Physical and Installation Requirements Single Fan Unit 1.5-3 HP Dual Fan Unit 4- 6 HP Bottom View All Models Figure 1 © 2016 Emerson Climate Technologies, Inc. -
Page 19: 2016 Emerson Climate Technologies, Inc
Powers Crankcase Heater and Receiver ¼” Spade Connector 8A Relay Heater ¼” Spade Connectors (2) 5A Relay Dry (Switch Only) Alarm Contact Left Terminal – Defrost Termination Input 250VAC Max Right Terminal – L2 © 2016 Emerson Climate Technologies, Inc. -
Page 20: 2016 Emerson Climate Technologies, Inc
Other Connections Label Functions Remote Display Connection Connect + to + and – to - RS485 RS-485 Communications CANBUS Future Use B.BKP Future Use Hotkey programming (use with part # 043-0171-01 to reset control) © 2016 Emerson Climate Technologies, Inc. -
Page 21: Wiring Diagrams
AE5-1412 R1 9. Wiring Diagrams 052-7287-00 Low Temp 1-Phase 2.0-3.5 HP 1 Condenser Fan © 2016 Emerson Climate Technologies, Inc. -
Page 22: 2016 Emerson Climate Technologies, Inc
AE5-1412 R1 052-7287-01 Low Temp 1-Phase 4-5 HP 2 Condenser Fans © 2016 Emerson Climate Technologies, Inc. -
Page 23: 2016 Emerson Climate Technologies, Inc
AE5-1412 R1 052-7287-02 Medium Temp 1-Phase 1.5-3 HP 1 Condenser Fan © 2016 Emerson Climate Technologies, Inc. -
Page 24: 2016 Emerson Climate Technologies, Inc
AE5-1412 R1 052-7287-04 Medium Temp 3-Phase 4.5-6 HP 2 Condenser Fans © 2016 Emerson Climate Technologies, Inc. -
Page 25: 2016 Emerson Climate Technologies, Inc
AE5-1412 R1 052-7287-05 Low Temp 3-Phase 2-3 HP 1 Condenser Fans © 2016 Emerson Climate Technologies, Inc. -
Page 26: 2016 Emerson Climate Technologies, Inc
AE5-1412 R1 052-7287-13 Low Temp 3-Phase 4-6 HP 2 Condenser Fans © 2016 Emerson Climate Technologies, Inc. -
Page 27: 2016 Emerson Climate Technologies, Inc
AE5-1412 R1 052-7287-14 Medium Temp 3-Phase 1.5-3 HP 1 Condenser Fan © 2016 Emerson Climate Technologies, Inc. -
Page 28: 2016 Emerson Climate Technologies, Inc
AE5-1412 R1 052-7287-15 Medium Temp 1-Phase 4.5-5 HP 2 Condenser Fans © 2016 Emerson Climate Technologies, Inc. -
Page 29: Refrigerant Liquid Temperature Valve Capacity Multiplier Correction Factors
These factors include corrections for liquid refrigerant density and net refrigerating effect and are based on an average evaporator temperature of 0°F. However, they may be used for any evaporator temperature from - 40°F to + 40°F since the variation in the actual factors across this range is insignificant. © 2016 Emerson Climate Technologies, Inc. -
Page 30: Alarm Codes
Lockout compressor to pull excessive current Check start component wiring per diagram Open run circuit error/ Alarm Check run capacitor Check wires are properly routed lockout Lockout through controller current transducers per wiring diagram © 2016 Emerson Climate Technologies, Inc. -
Page 31: 2016 Emerson Climate Technologies, Inc
Replace faulty controller communication error clock Reload factory settings with the E82-E85 Configuration Errors Alarm Replace faulty controller hotkey EEPROM Memory Reload factory settings with the Lockout Replace faulty controller Error hotkey © 2016 Emerson Climate Technologies, Inc. -
Page 32: Sensor Values
12.73 14.4 1.08 10.79 12.8 0.998 9.20 11.6 0.937 7.87 10.4 0.868 6.77 9.46 0.816 5.85 8.47 0.758 5.09 4.45 3.87 3.35 2.92 2.58 2.28 2.02 1.80 1.59 1.39 1.25 1.12 1.01 0.92 0.83 © 2016 Emerson Climate Technologies, Inc. -
Page 33: Parameters
Lod / Remote Display visualization P1 - P7 Compressor Ambient temperature required to initiate low LAS / -40 - 230 ambient on time (°F) LMO / Low ambient minimum on time (sec) 0 - 255 © 2016 Emerson Climate Technologies, Inc. -
Page 34: 2016 Emerson Climate Technologies, Inc
Emerson Climate Technologies, Inc. and/or its affiliates (collectively "Emerson"), as applicable, reserve the right to modify the design or specifications of such products at any time without notice. Emerson does not assume responsibility for the selection, use or maintenance of any product. - Page 35 Emerson.com 2015ECT-53 R1 (4/17) Emerson, Copeland Scroll and CoreSense are trademarks of Emerson Electric Co. or one of its affi liated companies. ©2017 Emerson Climate Technologies, Inc. All rights reserved.
Need help?
Do you have a question about the Copeland Scroll XFAL Series and is the answer not in the manual?
Questions and answers
What does the code rst or r5t mean on the controller display when pressing the start button? On Emerson XFAL-030Z series.
The codes "rst" or "r5t" on the display of the Emerson XFAL-030Z controller indicate that the controller is going through a reset process when the start button is pressed.
This answer is automatically generated