Daikin Maverick II MPS062E Installation And Maintenance Manual page 115

Select Yes or No. If not applicable to the type of unit, select N/A.
Q. At what suction pressure does the hot gas bypass valve open?. . . . . . . . Circuit 1 __________ psig
R. Record discharge air temperature at discharge of unit: ___________ °F
S. Are all control lines secure to prevent excessive vibration and wear? . . . . . . . . . . . . . . . . . . . . . Yes
T. Are all gauges shut off and valve caps and packings tight after start-up? . . . . . . . . . . . . . . . . . . . Yes
V. ELECTRIC HEAT CHECK, TEST & START
A. Electrical heat service corresponds to unit nameplate? . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
B. Are there any signs of physical damage to the electric heat coils? . . . . . . . . . . . . . . . . . . . . . . Yes
C. Have all electrical terminals been tightened? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
D. Does sequence controller stage contactors properly? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
E. Electric heater voltage across each phase: . . . . . . . . . . . . . . . . . ___________ L1
F. Amp draw across each phase at each heating stage:
Stage 1
Phase L1: ___________
Phase L2: ___________
Phase L3 ___________
G. FLA: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . L1 ___________
H. Operate electric heat with fans off. Electric heat must cycle on high limit control . . . . . . . . . . . . . . . Yes
VI. GAS BURNER CHECK, TEST, & START
Specifications:
For gas, see Forced Draft Gas Burner Installation and Maintenance Bulletin. (IM 684 and IM 685)
A. Gas Furnace:. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Model no. __________________
B. Gas Burner: . . . . . . . . . . . . . . . . . . . . . . . . . . .Model no.___________________ Serial no. ___________________
C. Gas Rated firing rate (MBH input): . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ._________________
D. Gas Altitude (ft. above sea level): . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ._________________
E. Input (CFH): . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . _________________
F. Gas pressure at burner (inches w.c.): . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . _________________
G. CO (%) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . _________________
2
H. CO (%): . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . _________________
2
I. Pilot flame only in microamps (steady at low fire): . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . _________________
J. Pilot Tap-gas pressure (inches w.c.): . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . _________________
K. Motor only/burner FLA running amps: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . _________________
L. High limit control OK? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
M. Flame safeguard (microamps): . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . _________________
13F-4158 (06/17)
www.DaikinApplied.com
Stage 2 Stage 3
____________ ____________
____________ ____________
____________ ____________
115
Rooftop Equipment Warranty Registration
Rooftop Equipment Warranty Registration Form (continued)
Volts _____________ Hertz _____________ Phase _____________
Stage 4 Stage 5
___________ ___________
___________ ___________
___________ ___________
Circuit 2 __________ psig
No N/A
No N/A
No N/A
No N/A
No N/A
No N/A
___________ L2 ___________ L3
Stage 6
____________
____________
____________
L2____________ L3 ___________
No N/A
No N/A
IM 991-2 • MAVERICK II ROOFTOP
4