Maintenance; Cleaning/Replacing The Filters; Cleaning The Air Hoses - WAGNER FINECOAT 9900 PLUS Owner's Manual

fc9900 Plus
7

Maintenance

Use the following procedures to keep your HVLP
i
spray system running properly.
7.1
cleaning / replacing the filterS
Make sure the turbine is unplugged before
changing the filters.
Attention
1. Remove the filter covers (1) on each side of the turbine by
turning them counterclockwise.
1
2. Remove each filter set (pre-filter [2] and filter [3]) from the
filter housing on each side of the turbine.
The white pleated filter (4) is removed from the
i
turbine in the same manner as the filter cover.
Turn counterclockwise to unlock and remove.
4
2
2
3
Do not use highly flammable solvents, such as
lacquer thinner, to clean the filters.
Do not soak paper pleated filter in solvents. Only
tap the filter or use compressed air directed at
the inside (the clean side).
Attention
3. Clean the filters. Either tap the filters to knock out the
contaminants or use pressurized air to blow out the
contaminants. For material that is not blown or knocked
loose easily, soak the filters in soapy water or mineral
spirits. Allow the filters to dry completely before placing
them back in the turbine.
4. Insert each filter back into its corresponding filter can.
Make sure the white pleated filter is fitted securely
i
to the spokes of the filter can. Turn clockwise to
secure in place.
5. Replace the filter covers on each side of the turbine by
turning them clockwise.
After several cleanings, it may become necessary
i
to replace the filters. Refer to the parts list near
the end of this manual for the filter replacement
kit part number.
7.2

cleaning the air hoSeS

1. Periodically wipe the outer surface of the air hose with a
damp cloth to keep clean.
DO NOT submerge into or flush the air hose with
water or any chemical.
DO NOT use methylethylketon (MEK), naphtha,
Attention
mineral spirits, paint thinner, xylol/xylene, or
toluel/toluene to clean the air hose. Exposure
over time could cause damage to the hose.
Store indoors with the cord wrapped around the
handle.
maintenance
11