Page 1
® Gold Standard Toaster Model GST-3V Owner’s Manual Manufacturing Number: 9210874 Rating Original Instructions www.antunes.com P/N 1011320 Rev. CAUTION: Read the instructions before using the machine G 02/19...
But not for Service/Technical Assistance problems with the installation or op- continuous mass production of food. eration of this product contact Antunes In Case of Damage Customer Service immediately at +1- Equipment Information to Save 877-392-7856 (toll free).
Building Officials and Code performed by qualified personnel Administrators, Inc. (BOCA) y Do not block or cover any ONLY. Contact Antunes Technical and the Food Service Sanitation openings on the equipment. Service for adjustment or repair. Manual of the Food and Drug y Do not immerse the cord, Administration (FDA).
In this example, the compression is set to 4 (recommended). Tall Profile Bun Tall Profile Bun Feeder Shown Feeder Shown Figure 1. GST-3V Figure 2. Compression Settings P/N 1011320 Rev. G 02/19 ®...
User Mode Manager Mode recent error code. Press the PROGRAM button to User Mode allows an operator to view Manager Mode allows an operator to proceed to the Voltage setting. the toaster settings but does not permit view and adjust the following settings: Use the LIGHTER or DARKER any adjustments.
If “Hi” flashes if the Rear Platen Heater power to the heaters and control circuits the error repeats, contact your Antunes temperature is 30° F more than the set- if the unit overheats. To reset the con- Technical Service for assistance.
Daily Cleaning Examples of Damaged Belts NOTE: The belt rollers will continue If the belts are torn and folded, replace Clean the Toaster and Belt turning while in cool-down the belts. Wraps mode. This allows you to clean the entire belt. Only Turn the toaster’s power switch to clean the belt where it is in the off position and it will enters a...
Quarterly Cleaning Install Belt Wraps If you are installing the existing belt Remove Belt Wraps & Clean wraps, inspect the belts. Replace Rollers belt wraps if worn or damaged. If the belt wraps are in good condition Turn the toaster’s power switch to put them back on the toaster.
Annual Cleaning Clean Fans & Electrical Housings Turn the toaster’s power switch to the off position. The toaster enters a cool-down mode and will auto- matically shut down when complete. Unplug the power cord. Remove the bun feeder and set aside.
Control Board or the Front toasting properly. Platen Thermocouple is open. front Thermocouple for continuity. Contact your mainte- nance person or Antunes Technical Service for service. Failed Control Board. Control Display flashes Er Loose Rear Platen Thermocouple con- Re-secure the Rear Platen Thermocouple connection 11 continuously.
Page 12
Clean fans as described in the Cooling Fan is dirty and needs to be Maintenance section of this manual. If problem persists, cleaned. contact your maintenance person or Antunes Technical Service for service. Control Display flashes Front Hi-Limit Control is tripped.
Motor Plate 0506691 Cam Bracket, RH Note 0506692 Cam Bracket, LH Use only genuine Antunes replacement parts in this unit. Use 0600143 Spring, Compression Setting of parts other than those supplied by the manufacturer will void the warranty. 0600156 Spring, Camp Adjustment...
Page 14
Item Part # Description Qty. 7001611 Handle, Pocket Pull Snap In 7001651 Sprocket, 215B18., 1/2” Bore 7001931 Kit, Belts Spacer .075 THK .203 ID x .312 05P6083 300P123* Ring, Retaining External 304P105* Nut, hex ‘KEPS’ #4-40 Nut, hex ‘KEPS’ #6-32 Small 306P130* Pattern 308P102*...
Antunes Technical Service. 2. Antunes reserves the right to make changes in design or add any improvements on any product. The right is always reserved to modify equipment because of factors beyond our control and government regulations. Changes to update equipment do not constitute a warranty charge.
Need help?
Do you have a question about the GST-3V and is the answer not in the manual?
Questions and answers