Table of Contents
Advertisement
Quick Links
MFG. NO. 9210858, 9210864, 9210865
Place this manual in the Toaster section
of your Equipment Manual.
Manufactured exclusively for
McDONALD'S ®
BY
ANTUNES
180 KEHOE BLVD.
CAROL STREAM, ILLINOIS 60188, U.S.A.
PHONE: +1-630-784-1000
TOLL FREE: +1-877-392-7854
FAX: +1-630-784-1650
www.antunes.com
Owner Information .....................................................2
General ......................................................................2
Service/Technical Assistance ....................................2
Warranty Information .................................................2
Specifications .............................................................3
Electrical Specifications & Plug Configuration ..........3
Dimensions ................................................................3
Important Safety Information ....................................4
Installation ...................................................................5
Unpacking ..................................................................5
Location .....................................................................5
Operation .....................................................................6
Operating Instructions ...............................................6
User Mode .................................................................6
Manager Mode ..........................................................6
Safety Features .........................................................7
A.J. Antunes & Co. provides the following limited warranty to the original purchaser of all McDonald's Equipment.
All components are warranted against defects in the material and workmanship for a period of two (2) years. If any part becomes inoperable during the period of this
warranty, A.J. Antunes & Co. will pay labor costs to an Authorized Service Agent to replace the part plus travel expenses.
WARRANTY EXCLUSIONS
• The cost of installation.
• Equipment that has been damaged due to shipment. Purchaser should make
damage claim directly upon carrier.
• Alteration, misuse, abuse.
• Improper storage or handling.
• Improper maintenance.
• Failure to follow proper installation instructions, including electrical connec-
tion.
A.J. Antunes & Co. reserves the right to make changes in design or add improvements on any products. The right is always reserved to modify Equipment because of
factors beyond our control and government regulation. Changes to Equipment do not constitute a warranty charge.
This warranty is exclusive and is in lieu of all other warranties, expressed or implied, including any implied warranty of merchantability or fitness for a particular pur-
pose, each of which is expressly disclaimed. The remedies described above are exclusive, and in no event shall A.J. Antunes & Co. or any of its Divisions be liable for
special consequential or incidental damages for the breach or delay in the performance of this warranty.
This manual is for the exclusive use of licensees and employees of McDonald's Systems, Inc..
P/N 1011328 Rev. I 04/18
McDonald's
BUN TOASTER
HEBT-3V
A.J. Antunes & Co.
HEBT-3V
Scan with mobile device or enter URL
for product and service information.
http://tiny.cc/ajaHEBT3V
TABLE OF CONTENTS
Operation .....................................................................7
Maintenance ................................................................8
Daily Cleaning ...........................................................8
Quarterly ..................................................................11
(Annually) ................................................................13
Troubleshooting .......................................................14
Replacement Parts ...................................................17
Wiring Diagram .........................................................24
Notes..........................................................................25
LIMITED WARRANTY
• Improper or unauthorized repairs.
• Scheduled Maintenance procedures as outlined in your MRC Card.
• Consumables such as Grill Covers (Release Sheets), gaskets, Conveyor Belt
Wraps, O-rings, removal of links, and light bulbs.
• Freight, foreign, excise, municipal, or other sales or use taxes.
• Consequential damages such as loss of profit, loss of time, the cost of repair-
ing or replacing other property which is damaged, or any other incidental
damage of any kind.
© McDonald's Corporation All Rights Reserved
1
HEBT-3V BUN TOASTER
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Antunes HEBT-3V
Summary of Contents for Antunes HEBT-3V
-
Page 1: Table Of Contents
This warranty is exclusive and is in lieu of all other warranties, expressed or implied, including any implied warranty of merchantability or fitness for a particular pur- pose, each of which is expressly disclaimed. The remedies described above are exclusive, and in no event shall A.J. Antunes & Co. or any of its Divisions be liable for special consequential or incidental damages for the breach or delay in the performance of this warranty. -
Page 2: Owner Information
Serial No.: Service/Technical Assistance Mfg. No.: If you experience any problems with the installation or operation of your unit, contact Antunes Technical Network ID Number: Service at +1-877-392-7854 (toll free). Use only genuine Antunes replacement parts in this Warranty Information unit. -
Page 3: Specifications
HEBT-3V BUN TOASTER SPECIFICATIONS Electrical Specifications & Plug Configuration Model & Plug Plug Volt Watts Mfg. No Description Configuration L6-30P 30 Amp., HEBT-3V 3300 50/60 250 Volt, 9210858 Straight Twist Lock L6-30P 30 Amp., HEBT-3V 3300 50/60 250 Volt, 9210865... -
Page 4: Important Safety Information
Live circuits will be exposed. • This equipment should be serviced by quali- CAUTION fied personnel only. Contact Antunes Technical All electrical connections must be in accordance SErvice for adjustment or repair. with local electrical codes and any other appli- •... -
Page 5: Installation
• Accessories box 2. Remove the accessories box from the large box. 3. With the help of another person, carefully remove the HEBT-3V from the large box. 4. Remove all protective coverings from the unit. 5. Open the Accessories Box. It contains: •... -
Page 6: Operation
User Mode Operating Instructions User Mode allows an operator to view the toaster set- The HEBT-3V toasts Crowns, Heels, Clubs, and other tings but does not permit any adjustments. products. Follow these steps to start the HEBT-3V: 1. Turn on the toaster and wait for warm-up to com- 1. -
Page 7: Safety Features
NOTE: The unit exits Manager Mode after 30 sec- onds of keypad inactivity. There are variations in bun products Worldwide that are used on the A.J Antunes HEBT toaster such as mois- 2. TEMPERATURE ADJUSTMENT: Adjust the set point ture content, bun formulations, age, tolerances etc. The temperature on the platens in the program menu. -
Page 8: Maintenance
HEBT-3V BUN TOASTER MAINTENANCE Daily Cleaning 8. Wash, rinse, and sanitize the bun feeder and bun stop in the three-compartment sink. Allow to air Clean the Toaster and Belt Wraps dry. 1. Turn the toaster’s power switch to the off position. - Page 9 HEBT-3V BUN TOASTER MAINTENANCE (continued) Figure 3. Examples of Damaged Belts P/N 1011328 Rev. I 04/18 McDonald’s...
- Page 10 HEBT-3V BUN TOASTER MAINTENANCE (continued) BELT IS TORN AND FOLDED. REPLACE BELT. Figure 6. Example of Damaged Belt Figure 4. Example of Damaged Belt BELT IS MISSING SNAPS AND IS DAMAGED. REPLACE BELT. Figure 5. Example of Damaged Belt P/N 1011328 Rev. I 04/18...
-
Page 11: Quarterly
HEBT-3V BUN TOASTER MAINTENANCE (continued) Quarterly Tense Tense Remove Belt Wraps and Clean Rollers 1. Turn the toaster’s power switch to the off position. The toaster enters a cool-down mode and will automatically shut down when complete. Loose 2. Unplug the power cord once the cool-down period Loose is complete. - Page 12 HEBT-3V BUN TOASTER MAINTENANCE (continued) Install Belt Wraps 1. If you are installing the existing belt wraps, inspect Tense Tense the belts. Replace belt wraps if worn or damaged. If the belt wraps are in good condition put them back on the toaster.
-
Page 13: Clean Cooling Fans And Electrical Housings (Annually)
HEBT-3V BUN TOASTER MAINTENANCE (continued) Clean Cooling Fans and Electrical Housings (Annually) 1. Turn the toaster’s power switch to the off position. The toaster enters a cool-down mode and will automatically shut down when complete. Unplug the power cord. 2. Remove the bun feeder and set aside. -
Page 14: Troubleshooting
HEBT-3V BUN TOASTER TROUBLESHOOTING Problem Possible Cause Corrective Action Control Display flashes The A Platen temperature has not Allow the unit to warm up for 30 minutes and then Err 5 continuously. Buns recheck. If the Control Display still flashes Err 5, reached the setpoint temperature not toasting properly. - Page 15 HEBT-3V BUN TOASTER TROUBLESHOOTING (continued) Problem Possible Cause Corrective Action Control Display flashes Mechanical bind in one or both con- Enter “user mode” to check the motor speed. Err 20. veyors. Check both conveyors for mechanical binds. Test the motor. Replace necessary parts. Contact Worn or damaged Ball Bearings.
- Page 16 HEBT-3V BUN TOASTER TROUBLESHOOTING (continued) Problem Possible Cause Corrective Action Control Display is blank. Power Cord is not plugged in. Plug the Power Cord into the appropriate out- let. Turn the toaster on. If the Control Display is still blank, contact your maintenance person or Authorized Service Agency for service.
-
Page 17: Replacement Parts
HEBT-3V BUN TOASTER REPLACEMENT PARTS P/N 1011328 Rev. I 04/18 McDonald’s... - Page 18 HEBT-3V BUN TOASTER REPLACEMENT PARTS (continued) P/N 1011328 Rev. I 04/18 McDonald’s...
- Page 19 HEBT-3V BUN TOASTER REPLACEMENT PARTS (continued) P/N 1011328 Rev. I 04/18 McDonald’s...
- Page 20 HEBT-3V BUN TOASTER REPLACEMENT PARTS (continued) P/N 1011328 Rev. I 04/18 McDonald’s...
- Page 21 HEBT-3V BUN TOASTER REPLACEMENT PARTS (continued) P/N 1011328 Rev. I 04/18 McDonald’s...
- Page 22 HEBT-3V BUN TOASTER REPLACEMENT PARTS (continued) Item Part No. Description Qty. Item Part No. Description Qty. 0012603 Sprocket / Tensioner Bracket Assy 49 0507247 Heat Sink, Relay 0012592 Sprocket /Bearing Assembly 50 3080157 Screw, Tap 8-32 X 3/8”Lg 0506185 Bracket, Chain Tensioner...
- Page 23 Belt Wrap Replacement Kit (incl 1 of Item 168 & 170) 171 7002071 Rear Belt Wrap 172 1070104 QR Code Label HEBT-3V 173 0400376 Lock Nut (Not shown) * Available in packages of 10 (ten) P/N 1011328 Rev. I 04/18...
-
Page 24: Wiring Diagram
HEBT-3V BUN TOASTER WIRING DIAGRAM P/N 1011328 Rev. I 04/18 McDonald’s... -
Page 25: Notes
HEBT-3V BUN TOASTER NOTES P/N 1011328 Rev. I 04/18 McDonald’s... - Page 26 HEBT-3V BUN TOASTER NOTES P/N 1011328 Rev. I 04/18 McDonald’s...
- Page 27 HEBT-3V BUN TOASTER NOTES P/N 1011328 Rev. I 04/18 McDonald’s...
Need help?
Do you have a question about the HEBT-3V and is the answer not in the manual?
Questions and answers