Page 1
Electric MedSurg Bed Model FL23SE Maintenance Manual For Parts or Technical Assistance: USA: 1-800-327-0770 (option 2) Canada: 1-888-233-6888 2010/02 72-1114E MM FL23SE REV A www.stryker.com...
(WEEE), this symbol indicates that the product must not be disposed of as unsorted municipal waste, but should be collected separately. Refer to your local distributor for return and/or collection systems available in your country. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Note This provides special information to make maintenance easier or important instructions clearer. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Introduction This manual is designed to assist you with the maintenance of Stryker Model FL23SE Electrical MedSurg Bed. Carefully read this manual thoroughly before using the equipment or beginning maintenance on it. To ensure safe operation of this equipment, it is recommended that methods and procedures be established for educating and training staff on the safe operation of this bed.
1060 hPa Atmospheric Pressure 700 hPa 500 hPa Stryker reserves the right to change specifications without notice. • Specifications listed are approximate and may vary slightly from unit to unit. • Operating environment recommended to ensure the scale system (optional) precision.
(optional) Foot End Control Panel Fixed Siderail Control Panel (optional) Siderail Release Lever Wheel Cover (optional) 5th Wheel Emergency Crank Brake / Steer (optional) Openings Pedal Drainage Bag Hook Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Summary of Safety Precautions Before operating the Electric MedSurg Bed, Model FL23SE, it is important to read and understand all information in this manual. Carefully read and strictly follow the safety guidelines listed below. It is important that all users have been trained and educated on the inherent hazards associated with the usage of electric beds.
Page 12
• Do not steam clean or hose off the Electric MedSurg Bed, Model FL23SE. Do not immerse any part of the bed. Some of the internal parts of the bed are electric and may be damaged by exposure to water.
Static Discharge Precautions The electronic circuits in the Electric MedSurg Bed, Model FL23SE are completely protected from static electricity damage only while the bed is assembled. It is extremely important that all service personnel always use adequate static protection when servicing the electronic systems of the bed. Whenever you are touching wires, you should be using static protection.
Hand wash all surfaces of the bed with warm water and mild detergent. Dry thoroughly. Do not steam clean or hose off the Electric MedSurg Bed, Model FL23SE. Do not immerse any part of the bed. Some of the internal parts of the bed are electric and may be damaged by exposure to water.
______ All casters roll properly. Check caster for cuts, wear, etc. ______ Current leakage not more than 100 µA (microamps). ______ Ground impedance not more than 100 mΩ (milliohms). Bed Serial Number: Completed by: _______________________________________ Date: _________________ Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Page 16
Tools Required: • #2 Phillips Screwdriver • Bungee Cords (or equivalent) • OG2 Grease (or equivalent) • Brush Screw Covers Screw Covers Shown Are Optional Shown are Optional Figure 1 Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 17
Using the electronic controls, raise and lower the bed several times to spread the grease evenly. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Improper operation of the CPR emergency release • Check the two CPR mechanism limit switches for proper (optional): Gatch does not lower and/or the Fowler operations. Replace if necessary. actuator does not reset. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
The parts and accessories listed on this page are all currently available for purchase. Some of the parts identified on the assembly drawing parts in this manual may not be individually available for purchase. Please call Stryker Customer Service USA: 1-800-327-0770 (Option 2) or Canada: 1-888-233-6888 for availability and pricing.
3/8” Drive Ratchet • Small Slotted Head Screwdriver • Long Nose Pliers • Retaining Ring Pliers • Rubber Mallet • 7/16” Socket Right Head Siderail Shown Figure 4.1 A Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 23
Note: Inspect the self-lubricating bearings for wear and replace them if need be. Reverse the above steps to install the replacement rail. Verify the siderail movement for proper operation before returning the bed to service. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Note: First, remove the two locknuts and bolts at one end of the assembly and, while holding the assembly, finish with the ones at the opposite end. Reverse the above steps to install the replacement siderail assembly. Verify the siderail for proper operation before returning the bed to service. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Note: At assembly, tighten the two locknuts to a 75 in/lb torque using the torque wrench. Reverse the above steps to install the replacement transfer plate. Verify the siderail for proper operation before returning the bed to service. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Page 26
Service Information Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Note: Apply grease on a 4” distance from both ends of the tube. Reverse the above steps to install the replacement pivot tube. Verify the siderail movement before returning the bed to service. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Note: Hold the rail firmly when removing the last bolts. Reverse the above steps to install the replacement rail. Verify the siderail movement before returning the bed to service. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
10. Reverse the above steps to install the replacement siderail assembly. 11. Verify the siderail for proper operation before returning the bed to service. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Note: Use the same procedure to insert the upper part of the new handle on the rod, but this time turn the lock rod Reverse the above steps to install the replacement release handle. Verify the release handle for proper operation before returning the bed to service. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Using the two 1/2” combination wrenches, remove locknut, shoulder spacer and bolt (J) holding the locking hook to the plate. Remove hook. 10. Reverse the preceding steps to install the new hook. 11. Verify siderail for proper operation before returning the bed to service. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Using the #2 Phillips screwdriver, remove the three screws, washers and spacers (D) holding the panel to the cover. Reverse the above steps to install the new control panel. Verify all the controls of the foot end control panel before returning the bed to service. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Keep the seal for the replacement connector. Reverse the above steps to install the new connector. Verify all the controls of the foot end control panel for proper operation before returning the bed to service. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Reverse the above steps to install the replacement foot board panel. Verify all the controls of the foot board panel for proper operation before returning the bed to service. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
(D) holding the connector to its support. Remove the defective connector. Reverse the above steps to install the replacement connector. Verify the foot board controls for proper operation before returning the bed to service. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Note: Make sure to connect the membrane cables before fastening together the two sections of the control panel housing. Stick the membranes to the support at the end of the replacement procedure. Verify all the siderail functions for proper operation before returning the bed to service. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Using the 1/2” combination wrench, remove the two locknuts, washers, shoulder spacers and bolts (D) linking the foot section to the thigh section and remove the defective section. 10. Reverse the above steps to install the new foot section. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Using the 1/2” combination wrench, remove the four locknuts, washers, shoulder spacers and bolts (D, E) linking the thigh section to the foot and seat sections and remove the thigh section. Reverse the above steps to install the replacement thigh section. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Remove the four screws (L) holding the stops (M) to the defective section and replace the parts on the replacement section. Reverse the above steps to install the replacement seat section. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
If the bed is not equipped with the CPR emergency release (optional), proceed with steps 7 to 14. Otherwise, proceed with steps 15 to 24. Figure 4.3 B Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Page 42
24. Verify the CPR emergency release and the Auto Contour positioning (optional) for proper operation before returning the bed to service. End of the procedure for beds with CPR and Auto Contour. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
#2 Phillips Screwdriver • Diagonal Pliers • 5/16” Socket • Small Regular Head Screwdriver • Pliers • Bungee Cord (or equivalent) • 1/4” Drive Ratchet Procedure: Figure 4.3 C Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Page 44
E. Before installing the rue ring cotter to finalize the head actuator replacement, raise and lower completely the Fowler. Check that the actuator stops working as soon as the head section reaches the frame. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
It is of utmost importance that the course of the replacement thigh actuator be adjusted before hooking up its tube to the thigh section lever arms. An improper adjustment can damage the thigh section structure. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Page 46
Before installing the rue ring cotter to finalize the head actuator replacement, raise and lower completely the Knee Gatch. Check that the actuator stops working as soon as the thigh section reaches the frame. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
11. Reverse the above steps to install the replacement actuator. Take note of the following caution before hooking up the motor to the bed lift lever. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Page 48
B. Link the motor to the bed lift lever. C. The alignment jigs still in position, completely raise and lower the bed to ensure that the lower limit has been preserved following the motor replacement. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Note: Do not over tighten the nut. Reverse the above steps to install the replacement transformer. Test all the bed electric controls for proper operation before returning the bed to service. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
12. Keep the jumper (W1) that is located on the electronic board before replacing the board. 13. Reverse the above steps to install the replacement control board. 14. Test all the bed electric functions before returning the bed to service. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Reverse the above steps to install the replacement power connector. 10. Verify the bed powers on before returning it to service. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Remove the cable wires from the switch. Note their location so they will be connected correctly to the replacement switch. Using the #2 Phillips screwdriver, remove the two screws (A) holding the support to the frame and remove the support. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 53
Remove the defective switch. Reverse the above steps to install the replacement micro switch. Test the Auto Contour positioning for proper operation before returning the bed to service. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Service Information CPR MICRO SWITCH REPLACEMENT (OPTIONAL) Tools Required: • Inclinometer • #1 Phillips Screwdriver • #2 Phillips Screwdriver Procedure: Figure 4.3 F Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 55
Using the regular screwdriver, remove the micro switch from its support. Reverse the above steps to install the replacement micro switch. Test the CPR emergency release before returning the bed to service. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Note: Make sure there is no loose space at the CPR handle once the replacement cable is installed. Test the CPR emergency release before returning the bed to service. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
(N). Note the location of the locknut before loosening it so the replacement cylinder will be properly screwed into the end fitting. Reverse the above steps to install the replacement cylinder. Test the CPR emergency release for proper operation before returning the bed to service. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
62) on the side of the defective pedal and lay the support down. Keep the molded spacer (B). Remove the pedal from the activation lever shaft. Use a rubber mallet if necessary. Reverse the above steps to install the replacement pedal. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Position the brake/steer pedal to neutral. Using two 1/2” combination wrenches, remove the nut and bolt (C) holding the caster to the swing arm. Reverse the above steps to install the replacement caster. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Remove and keep the two locking levers (G, Figure 4.4 B, 62). Reverse the above steps to install the replacement fifth wheel assembly. Test the fifth wheel for proper operation before returning the bed to service. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Reverse the above steps to install the replacement swing arm assembly. 10. Test the fifth wheel for proper operation before returning the bed to service. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Remove, using needle nose pliers, the rue ring, washer and locking axle (A) linking the caster shaft to the locking lever (B) and the brake rod (C) if the caster is part of the braking system. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 63
Reverse the above steps to install the replacement caster. 10. If the replacement caster is part of the brake mechanism, apply the brakes and check that the caster is locked before returning the bed to service. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Using a 1/2” combination wrench, remove the nut, shoulder spacer, washer and bolt (E1, E2) holding each end of the linking rod. Remove the defective linking rod. Reverse the above steps to install the replacement linking rod. Check the braking mechanism before returning the bed to service. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 65
Notes Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Base L23-006G Rev 01 (Reference Only) Item Part No. Part Name Qty. 25-0108G Base 28-0469 Ground Chain VV83A9G16 Pan Head Tapping Screw Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Brake Mechanism with Fifth Wheel OL230043 Rev 02 (Reference Only) Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 73
Spacer 25-0451 Lever Spacer QDF7878 Rue Ring Cotter QPA23-0233 Locking Axle QPA25-0411 Brake Lever QPA25-0427 Locking Lever VB35A1O28FT Long Neck Carriage Bolt VE79A1O VW10A10 Flat Washer VW10C162404 Nylon Washer Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Wheel Covers OL230101G Rev 02 (Reference Only) Item Part No. Part Name Qty. QP28-0299-07 Right Caster Cover 25-0550 Caster Hood Velcro QP28-0300-07 Left Caster Cover VV81A9E16 Flat Head Tapping Screw Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Fifth Wheel OL230219 Rev 02 (Reference Only) Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Page 76
Fifth Wheel Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 77
Flat Head Hexagonal Socket Cap Screw 5/16-18 UNC x 1 1/4” z.p. VV11A1P48 Flat Head Hexagonal Socket Cap Screw 3/8-16 UNC x 2” z.p. VVB4A1O32 Bolt 5/16” - 18 X 1” Thread Rolling Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
120V Electric System OL230303G Rev 01 (Reference Only) Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 83
120V Electric System Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Page 84
120V Electric System Attach to the wire. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 85
25-0251Z Head/Thigh Actuator Support Cover 4 M0019 OG2 Petro Canada Grease .03 kg QDF17-0138 PC Board Ground Wire QDF23-0574 FL23SE Siderail Control Cable S.A. QDF23-0315 Control Board QDF7878 Rue Ring Cotter Diameter 3/8” z.p. QDF8042 Mate-N-Lock Female 2 x 1...
Item Part No. Part Name Qty. QDF20-0081 100V Connector QDF8078 10A, 250V Long Fast Action Fuse QED9575 Fuse Holder QE71-0571 Sticker - 10A, 250V Fuses QE71-1273-E 100V CSA Sticker Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Bed Lift Motors Screw Covers OL230302 Rev 00 (Reference Only) Item Part No. Part Name Qty. QP23-0256 Screw Cover VV83A9G16 Tapping Screw Pan Phillips Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Part Name Qty. 23-0795Z Micro Switch Support 23-0796G Angle Detector Arm 23-0797Z Switch Support QDF2083 Toggle Switch QDF23-0814 Auto Contour Cable QDF9518 Cable Tie VV83A9G16 Pan Head Tapping Screw Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Mattress Support L23-016G Rev 01 (Reference Only) Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 97
Pan Head Tapping Screw VVB4A1O24 Bolt VW10A10 Flat Washer 5/16” SAE z.p. 17-0211G Foot End Mattress Retainer 23-0815 Centre Section Stop VV83A9G36 Type B Screw, #10 X 1-1/4 28-0468Z Left Hook Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
CPR Emergency Release OL230227 Rev 04 (Reference Only) Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 101
Sleeve 25-0514Z Cylinder Inner Sleeve 25-0515Z Cylinder Outer Sleeve M0008 Threadlocker - Medium Strength (Blue) .3000 M0019 Petro Canada OG2 Grease .0450 QDF17-0020 Shoulder Spacer Diameter 5/16” x 0.210” Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Page 102
Nylon Shoulder Washer (ID 270” x D 480” x OD 720”) VE20AOP Locknut M10 x 1.0 z.p VV87A9A24 Tapping Screw Truss Phillips Socket #4 x 1/2” QDF9159 Cherry Limit Switch Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
BNQ Certification OL230258 Rev 00 (Reference Only) Item Part No. Part Name Qty. QE71-1201-F BNQ Sticker Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Part Name Qty. 25-0273Z Night Light Support QDF18825 Interlocking Outlet QDF9539 Night Light QE71-0712 Sticker - Night Light VV83A9G16 Tapping Screw Pan Phillips Type B #10 x 1/2” z.p. Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Cable and Phone Plug 1/4” OL230215 Rev 01 (Reference Only) Item Part No. Part Name Qty. QDF23-0571 Mono Wall Connection Cable Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Bolt 1/4”-20 x 3/4” Grade 5 z.p. VB15A1O44 Bolt 5/16-18 x 1 3/4” LG Grade 5 VE30A1N Nylon Locknut 1/4-20 VE30A1O Nylon Locknut 5/16”-18 QPN-14-0705 Caster for Head Lever Arm Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Short Bed Bumper OL230244 Rev 00 (Reference Only) Item Part No. Part Name Qty. QPPE1207 Plastic Cap 1/4 QP23-0776 Glider Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Power Cord with Straight Molded North American Hospital Grade Plug OL250053 Rev 01 (Reference Only) Item Part No. Part Name Qty. QDF8066 Power Cord with Straight Molded North American Hospital Grade Plug 1 Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
For Reference Only: For Reference Only: OL250068 OL250069 OL250073 OL250074 Rev. 02 Rev. 02 Rev. 02 Rev. 01 Part Number: Part Number: Part Number: Part Number: QDF8066-ISR QDF8066-ITA QDF8066-ARG QDF8066-CHI Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Full-Length Retractable Siderail OL230202 Rev 08 (Reference Only) Return To Table of Contents Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Page 116
Full-Length Retractable Siderail Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 117
Flat Washer 5/16” SAE z.p. 23-0658 Spacer 23-0485G Full-Length Retractable Siderails S.A. QPCE1207 Diameter 5/8”-18 unc ga 16-18 Cap M0019 Petro Canada OG2 Grease .0300 QE71-1175-T Sticker: Manipulate Here Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Page 118
Flat Washer 5/16” SAE z.p. 23-0658 Spacer 23-0485C Full-Length Retractable Siderails S.A. QPCE1207 Diameter 5/8”-18 unc ga 16-18 Cap M0019 Petro Canada OG2 Grease .0300 QE71-1175-T Sticker: Manipulate Here Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
PVC Protector for Full-Length Siderail OL230208 Rev 00 (Reference Only) Item Part No. Part Name Qty. 23-0641 Full-Length Siderail PVC Protector QDF7826 3M Adhesive Tape #950 x 1” 140” Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Retractable Half-Length Siderails with Fixed Control OL230245 Rev 00 (Reference Only) Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 121
Retractable Half-Length Siderails with Fixed Control Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Page 122
Retractable Half-Length Siderails with Fixed Control Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 123
Control Board Stand-off Pin QDF7908 Black Plug 1” #SQR-1-10-14 QDF9018 “AMP” Pin Contact #66103-2 QDF299X Adhesive Neoprene 1/4 x 3/4 .1666 QDF2043 Cable Clamp “AMP” 206070-1 QDF2042 14-Positions Circular Connector Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Page 124
Control Board Stand-off Pin QDF7908 Black Plug 1” #SQR-1-10-14 QDF9018 “AMP” Contact Pin #66103-2 QDF299X Adhesive Neoprene 1/4 x 3/4 .1666 QDF2043 Cable Clamp “AMP” 206070-1 QDF2042 14-Positions Circular Connector Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 125
Raise Fowler Brown Raise Bed Blue Raise Gatch Orange Communication Black Lower Gatch White Lower Bed Green Lower Fowler Normally Open Buzzer Yellow Communication Buzzer Grey Normally Closed Buzzer Purple Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Retractable Siderails with Removable Controls OL230246 Rev 00 (Reference Only) Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 127
Retractable Siderails with Removable Controls 10.00” 10.00” Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Page 128
Retractable Siderails with Removable Controls Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 129
Type B #10 x 3/4” VW10A08 Flat Washer 1/4” x 1/16” M0019 Petro Canada OG2 Grease .0300 QP23-0735 PCB Support QDF7908 Black Plug 1” #SQR-1-10-14 QDF299X Adhesive Neoprene 1/4 x 3/4 .3333 Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Page 130
Type B #10 x 3/4” z.p. VW10A08 Flat Washer 1/4” x 1/16 M0019 Petro Canada OG2 Grease .0300 QP23-0735 PCB Support QDF7908 Black Plug 1” #SQR-1-10-14 QDF299X Adhesive Neoprene 1/4 x 3/4 .3333 Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
OL230199 Rev 01 (Reference Only) Item Part No. Part Name Qty. QPCE1207 Diameter 5/8”-18 unc ga 16-18 Cap QDF23-0392 Left Membrane without Nurse Call QDF23-0393 Right Membrane without Nurse Call Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 133
Notes Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
0.505” ins. x 3/4” out. x 1/16” wi. QDF9012 Connection Terminal (6x2) VV83A9E12 Tapping Screw Type B Pan Head Phillips #8 x 3/8” z.p. QDF23-0530 1/4 Normally Open (N.O.) Phono Plug Cable Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
0.505” ins. x 3/4” out. x 1/16” wi QDF9012 Connection Terminal (6x2) VV83A9E12 Tapping Screw Type B Pan Head Phillips #8 x 3/8” z.p. QDF23-0531 1/4 Normally Closed (N.C.) Phono Plug Cable Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Foot End Control Panel OL230026 Rev 05 (Reference Only) Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 137
Nurse Control Membrane QDF7826 3M Adhesive Tape #950 x 1” .1250 VV83A9G16 Tapping Screw Pan Phillips Type B #10 x 1/2” z.p. VW60C201320 Nylon Spacer 5/8” x .386” x 39/64” Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Control Panel on Frame for Full-Length OL230209 Rev 02 (Reference Only) Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 139
Foot End Casing Cover without Connector QDF23-0693 Nurse Control Membrane QP17-0127-07 Nurse Control Board VV83A9G16 Tapping Screw Pan Phillips VW60C201320 Nylon Spacer QDF7826 3M Adhesive Tape #950 x 1” .2500 Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Foot End and Foot Board Control Panels OL230033 Rev 05 (Reference Only) Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 141
Pan Head Tapping Screw VW60C201320 Nylon Spacer QDF7826 3M Adhesive Tape #950 x 1” .2500 VV33A1G28 Pan Head Machine Screw VE30A1G Nylon Hex Locknut QDF2053 Red PVC Tape .5000 Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Foot End and Foot Board Control Panels - Full-Length Siderail OL230210 Rev 02 (Reference Only) Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 143
Pan Head Machine Screw VV83A9G16 Pan Head Tapping Screw VW10A06 Flat Washer # 10 z.p. VW60C201320 Nylon Spacer QDF7826 3M Adhesive Tape #950 x 1” .2500 QDF2053 Red PVC Tape .5000 Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
L23-005G Rev 06 (Reference Only) FOOT HEAD Item Part No. Part Name Qty. 23-0124G Post VV33A1N24-S Machine Screw Pan Head QPPF1521 Metal Washer 1/4” Diameter QPPF1514-1 White Plastic Cap Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Inner Right Handle QP23-0475-07 Inner Left Handle 23-0514XX Melamine Foot Board QE14376-T Sticker - Headboard Installation VV23A1G32HL Tapping Screw Pan Phillips QPAG1801 Rod Support VV27A9G16 Tapping Screw Truss Head Phillips Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Inner Right Handle QP23-0475-07 Inner Left Handle 23-0516XXXX Laminated Board QE14376-T Sticker - Headboard Installation VV23A1G32HL Tapping Screw Pan Phillips QPAG1801 Rod Support VV27A9G16 Tapping Screw Truss Head Phillips Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
MDF Laminated Boards with Control Panel OP230254 Rev 00 (Reference Only) Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Page 148
Phillips #10 x 1” z.p. VV33A1E24 Machine Screw Round Head Phillips 3-32 x 3/4 VV27A9G16 Tapping Screw Truss Head Phillips #10 x 1/2” LG VW11A9E Flat Washer #8 VW60C081005 Sleeve QPAG1801 Rod Support Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
QP23-0472-07 Outer Right Handle QP23-0473-07 Outer Left Handle QP23-0474-07 Inner Right Handle QP23-0475-07 Inner Left Handle VV23A1G32HL Tapping Screw Pan Phillips VV27A9G16 Tapping Screw Truss Head QPAG1801 Rod Support Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Solid Wood Boards with Control Panel OP230255 Rev 00 (Reference Only) Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 151
VV27A9G16 Tapping Screw Truss Phillips Type A #10 x 1/2” z.p. VV33A1E24 Machine Screw Pan Phillips #8-32 x 3/4” z.p. VW11A9E Flat Washer #8 VW60C081005 Sleeve QPAG1801 Rod Support Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Solid Core Boards with Flat Top and Control Panel OP230256 Rev 01 (Reference Only) Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 153
Outer Right Handle QP23-0474-07 Inner Right Handle QP23-0473-07 Outer Left Handle QP23-0475-07 Inner Left Handle VV23A1G32HL Tapping Screw Pan Phillips Type High-Low #10 x 1” z.p. QPAG1801 Rod Support Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Bed Labeling - English/French OL230120 Rev 03 (Reference Only) Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 155
Sticker - Left Pedal Positions QE71-0741-T Sticker - Mattress Maximum Thickness QE71-0749-T Serial Number Plate QE71-0752-F Fire Hazard - Sticker QE71-0778-F Sticker - Accessory Warning VR11H43 Dome Head Pop Rivet #43 Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Bed Labeling - English/Spanish OL230121 Rev 03 (Reference Only) Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 157
Sticker - Left Pedal Positions QE71-0741-T Sticker - Mattress Maximum Thickness QE71-0749-T Serial Number Plate QE71-0752-E Fire Hazard - Sticker QE71-0778-E Sticker: Accessory Warning VR11H43 Dome Head Pop Rivet #43 Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Removable Two-Sided, Two-Function Pendant Control FA64160 See pg. 164 P&D Two-Function Pendant Control FA64155 See pg. 165 Half an Inch Diameter Stryker Removable I.V. Pole FA64135 See pg. 166 Half-Length Siderail Protective Pads DM64232 See pg. 167 Full-Length Siderail Protective Pads DM64176 See pg.
Description 2111A Tightening Sleeve-Anodized 2109 Compression Socket 2107A Top Tube-Anodized 2105A Bottom Tube-Anodized QE14399-T Manufacturer’s Nameplate QPCE1206 Rubber Cap #000 Black (1/2” x 11/32” x 7/8”) QE71-0246-T “Warning” Sticker Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Bed Extender - FA64152 Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 161
Tapping Screw Pan Phillips Type B #10 x 3/4” z.p. VW11A9E Flat Washer #8 QE71-0787-T Sticker - Emergency Crank Warning 1 QE14399-T Manufacturer’s Nameplate VE20A1N Hexagone Locknut 1/4-20 z.p. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Page 162
Part No. Description DM64063 Cushion for Bed Extender Cushion for Bed Extender - DM64064 Cushion for Bed Extender - DM64064 Item Part No. Description DM64064 Cushion for Bed Extender Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Petro Canada OG2 Grease 0.0002 kg QPN-9438 Black Nylon Handle QRC16887 Compression Spring VG10B0424 Spring Pin 1/8” x 3/4” VR43A9439 Shoulder Rivet QE71-0814-F Sticker - Emergency Crank QE71-1313-T Manufacturer’s Nameplate Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Removable Two-Sided, Two Function Pendant Control - FA64160 Item Part No. Description QDF64-0986 Removable Two-Function Pendant Control Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
P&D Two-Function Pendant Control - FA64155 Item Part No. Description QDF64-0687 P&D Two-Function Pendant Control QE71-0133 Stryker Label QDF8066 Security Clip (Interlock Press) 6400-035G Hook of the Pendant Control Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Half an Inch Diameter Stryker Removable I.V. Pole - FA64135 Item Part No. Description QDF9165 Stryker’s 1/2” Diameter Removable I.V. Pole Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
S.A. Top Rod 61-0002A S.A. Bottom Tube QPCE1206 Rubber Cap #000 (1/2” x 11/32” x 7/8”) Black QE71-0246-T Warning Sticker QE14399-T Manufacturer’s Nameplate VG10B0630 Spring Pin 3/16” Diameter x 15/16” Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Upright Oxygen Bottle Holder - FA64117 Item Part No. Description Qty. QE14399-T Manufacturer’s Nameplate QE71-0601 Sticker - Maximum Load VR11H42 Pop Rivet #42 Dome Head QDF64-1005 Oxygen Support Bottle 64-0647 S.A. Security Chain Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Overhead Trapeze - FA64145 Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Page 173
0.062” x 1” ins. x 1.563” out. VW20A10 Spring Washer 5/16” Diameter VR11H46 Pop Rivet #46, Dome Head 64-0536 Chain for Trapeze QDF7871 QR Hitch Pin QE14399-T Manufacturer’s Nameplate QE71-1163-T Storage of the Triangle Sticker Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Description Qty. 64-0745G S.A. Tray Support QDF5093 Tray and Fasteners QE14399-T Manufacturer’s Nameplate QE71-0578 Sticker - Maximum Load Capacity QE71-0579-F Sticker - Tied Up Load QE71-0580-F Sticker - Caution Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Pop Rivet 3/16” x 0.815” #AD610ABSLF QE71-0246-T Warning Sticker QE14399-T Manufacturer’s Nameplate VG10B0630 Spring Pin 3/16” Diameter x 15/16” VB15A1O60 Hexagone Bolt 5/16-18 x 3 1/2” Grade 5 z.p. Return To Table of Contents www.stryker.com 72-1114E MM FL23SE REV A...
Recycling Passport Reference: OL230303G, OL230304G Item Recycling/Material Code Control Board (QDF23-0315) Return To Table of Contents 72-1114E MM FL23SE REV A www.stryker.com...
Stryker Medical Division, a division of Stryker Corporation, warrants to the original purchaser the Electrical MedSurg Bed, model FL23SE, to be free from defects in material and workmanship for a period of one (1) year after date of delivery. Stryker’s obligation under this warranty is expressly limited to supplying replacement parts and labor for, or replacing, at its option, any product which is, in the sole discretion of Stryker, found to be defective.
Stryker authorized parts used Service during regular business hours (8−5) * Does not include maintenance due to abuse or for any disposable items. Stryker reserves the right to change options without notice. Stryker Medical also offers personalized service contracts. Pricing is determined by age, location, model and condition of product.
Page 180
3800 E. Centre Ave., Portage, Michigan USA 49002 CANADA Stryker Canada 45 Innovation Drive Hamilton, Ontario Canada L9H 7L8 European Representative Stryker France ZAC Satolas Green Pusignan Av. De Satolas Green 69881 MEYZIEU Cedex France 2010/02 72-1114E MM FL23SE REV A www.stryker.com...