Ingersoll-Rand PD05P Series Operator's Manual

OPERATOR'S MANUAL
INCLUDING: OPERATION, INSTALLATION & MAINTENANCE
It is the responsibility of the employer to place this information in the hands of the operator. Keep for future reference.
SERVICE KITS
Refer to Model Description Chart to match the pump material options.
637427 XX for fluid section repair (see page 4).
637428 for air section repair (see page 6).
PUMP DATA
Models . . . . . . . . . . . . see Model Description Chart for  XXX".
Pump Type . . . . . . . . . Air Operated Double Diaphragm.
Material . . . . . . . . . . . . see Model Description Chart.
Weight . . . PD05P XDS XXX B
PD05P XES XXX B
PD05P XKS XXX B
PD05P XLS XXX B
PD05P XPS XXX B
PD05P XRS XXX B
Maximum Air Inlet Pressure . . . . . . . . .
Maximum Material Inlet Pressure
Maximum Outlet Pressure . . . . . . . . . .
Air Consumption @ 40 p.s.i. . . . . . . . . .
Maximum Flow Rate
(flooded inlet)
Displacement / Cycle @ 100 p.s.i.
Maximum Particle Size . . . . . . . . . . . .
Maximum Temperature Limits (diaphragm / ball / seat material)
Acetal . . . . . . . . . . . . . . . . .
HytrelR . . . . . . . . . . . . . . . .
Nitrile . . . . . . . . . . . . . . . . .
Polypropylene . . . . . . . . . . .
Polyurethane . . . . . . . . . . . .
PVDF (KynarR) . . . . . . . . . .
SantopreneR . . . . . . . . . . .
PTFE (TeflonR) . . . . . . . . . .
VitonR . . . . . . . . . . . . . . . .
Groundable Models . . . . . . . . . . . . . . .
Dimensional Data . . . . . . . . . . . . . . . .
Noise Level @ 70 p.s.i., 60 c.p.m.
À The pump sound pressure levels published here have been updated to an Equivalent
Continuous Sound Level (L ) to meet the intent of ANSI S1.13 1971, CAGI PNEU
Aeq
ROP S5.1 using four microphone locations.
NOTICE: All possible options are shown in the chart however certain com
binations may not be recommended, consult a representative or the fac
tory if you have questions concerning availability.
INGERSOLL-RAND COMPANY
P.O. BOX 151 ONE ARO CENTER
D
&
D
(800) 276-4658 FAX (800) 266-7016
1/2" DIAPHRAGM PUMP
1:1 RATIO, NON-METALLIC
READ THIS MANUAL CAREFULLY BEFORE INSTALLING,
OPERATING OR SERVICING THIS EQUIPMENT.
. . . . . 6.28 lbs (2.85 kgs)
. . . . . 6.67 lbs (3.03 kgs)
. . . . . 6.78 lbs (3.08 kgs)
. . . . . 7.24 lbs (3.28 kgs)
. . . . . 5.21 lbs (2.36 kgs)
. . . . . 5.44 lbs (2.47 kgs)
100 p.s.i.g. (6.9 bar)
. . . . . 10 p.s.i.g. (0.69 bar)
100 p.s.i.g. (6.9 bar)
1 c.f.m. / gallon (approx.)
. . . . . 14.4 g.p.m. (54.5 l.p.m.)
. . . . 0.039 g.p.m. (0.15 l.p.m.)
3/32" dia. (2.4 mm)
10_ to 180_ F ( 12 to 82_ C)
20_ to 150_ F ( 29_ to 66_ C)
10_ to 180_ F ( 12 to 82_ C)
35_ to 150_ F (2_ to 66_ C)
10_ to 150_ F ( 12_ to 66_ C)
10_ to 200_ F ( 12 to 93_ C)
40_ to 225_ F ( 40_ to 107_ C)
40_ to 225_ F (4_ to 107_ C)
40_ to 350_ F ( 40_ to 177_ C)
PD05P XDS XXX B
PD05P XES XXX B
see page 8
. . . . . 75.0 db(A)
À
BRYAN, OHIO 43506 0151
D
E
2005 CCN 15250376
PD05P-X-X-B
MODEL DESCRIPTION CHART
PD05 P X X S X X X B
CENTER SECTION MATERIAL
P Polypropylene
FLUID CONNECTION
A 1/2 14 N.P.T.F. 1
B Rp 1/2 (1/2 14 BSP)
FLUID CAPS / MANIFOLD MATERIAL
D Groundable Acetal (single port)
E Groundable Acetal (multiple port)
K PVDF (Kynar) (single port)
L PVDF (Kynar) (multiple port)
P Polypropylene (single port)
R Polypropylene (multiple port)
HARDWARE MATERIAL
S Stainless Steel
SEAT MATERIAL
D Acetal P Polypropylene
K PVDF (Kynar) S Stainless Steel
BALL MATERIAL
A Santoprene T PTFE (Teflon)
C Hytrel U Polyurethane
G Nitrile V Viton
S Stainless Steel
DIAPHRAGM MATERIAL
A Santoprene T PTFE (Teflon) / Santoprene
C Hytrel U Polyurethane
G Nitrile V Viton
FLUID SECTION SERVICE KIT SELECTION
EXAMPLE: MODEL # PD05P ARS SAA B
FLUID SECTION SERVICE KIT # 637427 AA
RELEASED: 9-13-05
REVISED:
(REV. 01)
Figure 1
PD05P ARS S X X B
637427 X X
Ball Diaphragm