Takeuchi TB285 Operator's Manual page 149

MAINTENANCE
maintenance liSt
Every 500 hours
Replacing the fuel filter
Replacing the water separator filter <TB285>
Replacing the feed pump filter <TB290>
Every 1000 hours
Replacing the hydraulic oil return filter
Replacing the pilot line filter
Replacing the travel motor gear oil *
Cleaning the engine cooling system
Replacing the air cleaner element
Replacing the air breather filter
Inspecting and adjusting the engine valve clearance
Retightening the engine cylinder head bolt <TB285>
Inspecting the engine compression pressure <TB290>
Inspecting and cleaning the engine starter and the alternator <TB290>
Every 1500 hours
Inspecting and cleaning the engine fuel injectors <TB285>
Inspecting the crankcase breather system <TB285>
Every 2000 hours
Lapping the engine valve seats <TB285>
Every 4000 hours
Replacing the hydraulic oil and cleaning the suction strainer
When Required
Replacing the bucket teeth and the side cutters
Replacing the bucket
Adjusting the gap between the bucket and arm
Inspecting and replenishing the windshield washer fluid
Draining the water from the water separator
Lubricating the levers and pedals
Inspecting the rubber crawlers
Replacing the rubber crawlers
*: If the percentage of the traveling time within the total operating time is high, replace the gear
oil earlier than the specified time.
Inspection and maintenance item
5-13
Page
5-44
5-46
5-47
5-48
5-48
5-48
5-48
5-50
5-51
5-51
5-51
5-51
5-51
5-52
5-52
5-53
5-54
5-58
5-60
5-62
5-63
5-63
5-64
5-65
5-66