Wayne RPP50 Operating Instructions And Parts Manual
  1. Manuals
  2. Brands
  3. Wayne Manuals
  4. Water Pump
  5. RPP50
  6. Operating instructions and parts manual

Wayne RPP50 Operating Instructions And Parts Manual

Hide thumbs Also See for RPP50:
Table of Contents

Advertisement

Quick Links

Operating Instructions and Parts Manual
SPECIFICATIONS
POWER SUPPLY
REQUIREMENTS
120 V, 60 Hz
MOTOR
Single Phase, Dielectric Oil Filled
HORSEPOWER
1/2 HP ............ Sewage (RPP50, SEL50, WCS50T)
LIQUID TEMPERATURE
40° F - 120° F
CIRCUIT REQUIREMENTS
15 A (minimum)
DIMENSIONS
14 in. high x 12 in. base (RPP50)
13-1/2 in. high x 11 in. base (SEL50, EFL50)
16-5/8 in. high x 9-5/8 in. base (WCS50T)
ON LEVEL (FACTORY SET)
Approximately 16. in. (RPP50)
Approximately 17 in. (SEL50, EFL50)
Approximately 19 in. (WCS50T)
OFF LEVEL (FACTORY SET)
Approximately 7.5 in. (RPP50)
Approximately 7 in. (SEL50, EFL50)
Approximately 10.5 in. (WCS50T)
CONSTRUCTION
Cast Iron (RPP50, WCS50T)
MOTOR HOUSING
Reinforced Thermoplastic (SEL50, EFL50)
VOLUTE
Cast Iron (RPP50, WCS50T)
Cast Iron
IMPELLER
Glass Reinforced Thermoplastic
SHAFT
Steel
DISCHARGE
2 in. NPT
PERFORMANCE
Model
HP Discharge Head
RPP50
1/2
SEL50
1/2
WCS50T
1/2
EFL50
1/2
© 2018, WAYNE/Scott Fetzer Company.
Effluent (EFL50)
Reinforced Thermoplastic
(SEL50, EFL50)
Glass Reinforced Thermoplastic
0 ft
5 ft
10 ft
Gal / hr
6200
4800
3240
Gal / hr
10000
9000
7200
Gal / hr
10000
9600
8000
Gal / hr
10000
9000
7200
Please read and save these instructions. Read carefully before attempting to assemble, install,
operate or maintain the product described. Protect yourself and others by observing all safety
information. Failure to comply with instructions could result in personal injury and/or property
damage! Retain instructions for future reference.
15 ft
20 ft
1500
-
5000
2000
3300
-
5000
2000
Intended for Indoor Use Only
www.waynepumps.com
Sewage/Effluent Pumps
Sewage/Effluent
RPP50
Sewage- SEL50
Effluent- EFL50
WCS50T
610001-001 B 08/18

Advertisement

Table of Contents
loading

Related Manuals for Wayne RPP50

Summary of Contents for Wayne RPP50

  • Page 1 40° F - 120° F CIRCUIT REQUIREMENTS 15 A (minimum) DIMENSIONS 14 in. high x 12 in. base (RPP50) 13-1/2 in. high x 11 in. base (SEL50, EFL50) 16-5/8 in. high x 9-5/8 in. base (WCS50T) ON LEVEL (FACTORY SET) Approximately 16.

  • Page 2: Safety Signal Words

    INSTALLATION MANUAL SEWAGE/EFFLUENT PUMP SAFETY SIGNAL WORDS DESCRIPTION This manual contains information that is very important Sewage pumps are pumps used to remove waster water that contains solids up to 2 inches in diameter. The most common to know and understand. This information is provided for application is for draining bathroom waster water to a sewer or SAFETY and to PREVENT EQUIPMENT PROBLEMS.
  • Page 3 INSTALLATION MANUAL ALWAYS DISCONNECT THE PUMP from power supply before installing, servicing or making any adjustments. TOUJOURS METTRE LA POMPE HORS TENSION avant de procéder à DO NOT USE AN EXTENSION CORD OR SURGE PROTECTOR. Extension l’installation, à l’entretien ou à des réglages. cords and/or surge protectors could present a safety hazard if not sized properly, become damaged or the connection falls into the DO NOT WALK on the floor when water is present until all power is...
  • Page 4 INSTALLATION MANUAL IT IS REQUIRED TO USE RIGID PIPING AND FITTINGS to secure the pump in the basin and reduce pump movement. Pump movement can prevent the switch from operating correctly. Do not use flexible hosing. This product can expose you to chemicals, including DEHP, IL EST NÉCESSAIRE D’UTILISER DES TUYAUX ET DES RACCORDS which is known to the State of California to cause cancer, birth RIGIDES pour fixer la pompe dans le système et réduire les...

  • Page 5: Typical Sewage Installation

    7. If optional control device or float is used, follow mounting instruction supplied with device or float. ON LEVEL 8. A union should be installed above the basin to allow easy (RPP50-APPROX. 16 IN. removal of the pump for cleaning and service. SEL50-APPROX. 17 IN. WCS50T-APPROX. 19 IN.) 9.
  • Page 6 INSTALLATION MANUAL TYPICAL EFFLUENT INSTALLATION 1. This installation must be in accordance with the National Electric Code and all applicable local codes and ordinances. Effluent Pump in Septic Tank 2. Clean the basin of all debris. 3. Set the pump on a solid, level surface. Do not place pump directly on clay, earth, gravel, or sand.

  • Page 7: Troubleshooting Warnings

    INSTALLATION MANUAL TROUBLESHOOTING WARNINGS 1. Submersible pump models have permanently lubricated bearings and require no additional lubrication. 2. Submersible pumps contain dielectric oil for cooling. ALWAYS DISCONNECT THE PUMP FROM POWER SUPPLY before Dielectric oil can be harmful to the environment. Follow installing, servicing or making any adjustments.

  • Page 8: Routine Maintenance

    INSTALLATION MANUAL TROUBLESHOOTING (CONTINUED) Symptoms Possible Cause(s) Suggested Remedies Pump operates 1. Worn bearings 1. Replace pump noisily or vibrates 2. Impeller broken 2. Replace pump excessively 3. Piping attachments to building 3. Install rubber coupling (available at local hardware stores) to isolate structure too rigid or too loose pump vibration from discharge plumbing Pump will not...
  • Page 9 WARRANTY & SERVICE PARTS SHEET - REPLACEMENT PARTS REPAIR KITS REF. NO. DESCRIPTION MODELS Sewage- RPP50, SEL50, WCS50T Effluent- EFL50 TETHER SWITCH 56835-WYN1 (ALL MODELS) 10 FT. CORD 31006-WYN2 (WCS50T ONLY)

  • Page 10: Limited Warranty

    LIMITED WARRANTY For one year for RPP50, SEL50, and EFL50 models, and three years for WCS50T model from the date of purchase, from an authorized dealer, Wayne Water Systems will repair or replace, at its option for the original purchaser, any part or parts of its Sewage or Effluent Pumps or Water Pumps (“Product”) found upon examination by Wayne Water Systems to be defective in materials or workmanship.
  • Page 11 INSTALLATION MANUAL NOTES _____________________________________________________________________________________________ _____________________________________________________________________________________________ _____________________________________________________________________________________________ _____________________________________________________________________________________________ _____________________________________________________________________________________________ _____________________________________________________________________________________________ _____________________________________________________________________________________________ _____________________________________________________________________________________________ _____________________________________________________________________________________________ _____________________________________________________________________________________________ _____________________________________________________________________________________________ _____________________________________________________________________________________________ _____________________________________________________________________________________________ _____________________________________________________________________________________________ _____________________________________________________________________________________________ _____________________________________________________________________________________________ _____________________________________________________________________________________________ _____________________________________________________________________________________________ _____________________________________________________________________________________________ _____________________________________________________________________________________________ _____________________________________________________________________________________________ _____________________________________________________________________________________________...
  • Page 12 www.waynepumps.com...

This manual is also suitable for:

Sel50Efl50Wcs50t

Table of Contents