Table Of Contents - ACP RFS12MPSB Service Manual

Table of Contents

Important Information .................................................... 2
Important Safety Information ......................................... 4
Grounding Instructions ............................................... 7
General Information
Unpacking Equipment ................................................ 8
Equipment Placement ................................................ 8
Radio Interference ...................................................... 8
Model Identification .................................................... 8
Service ....................................................................... 8
Parts and Accessories ................................................ 8
Troubleshooting Procedures .................................... 9-13
Service Information
Proper Handling of Magnetron Tubes ...................... 14
Magnetron Failure Mode .......................................... 14
Microwave Leakage Test
Equipment ................................................................ 15
Procedure For Measuring Radiation Leakage ......... 15
Measurement With the Outer Panel Removed ........ 15
Measurement With a Fully Assembled Oven ........... 15
Record Keeping and Notification
After Measurement ............................................... 15
Testing Procedures ................................................. 16-19
Power Test ................................................................ 20
©2010 ACP, Inc.
Disassembly Procedures
Disconnecting Wire Terminals .................................. 21
Outer Case ................................................................. 21
Door Assembly ......................................................... 22
Door Disassembly .................................................... 22
Control Removal ...................................................... 23
Interlock Switches .................................................... 23
H.V. Capacitor .......................................................... 24
Diode ........................................................................ 24
Transformer .............................................................. 24
Fuse / Fuse Block / Filter Assembly ......................... 24
Magnetron ................................................................ 25
Blower Motor or Wheel ................................................ 25
Splatter Shield .......................................................... 26
Antenna (Upper & Lower) ........................................ 26
Stirrer Motor (Upper & Lower) .................................. 26
Magnetron Thermal Cut-Out (TCO) ......................... 27
Cavity Thermal Fuse ................................................ 27
Tray Replacement .................................................... 27
Oven Light Removal ................................................. 27
16400007 Rev. 0 3