Related Manuals for BRIG E340
Summary of Contents for BRIG E340
- Page 1 OWNER'S MANUAL English "EAGLE" SERIES: E340 E380 MODELS: complete set: E340, E340H* E380, E380H* Design category (2003/44/EC): C ISO6185-3: Category VII H* – boat tube is made of HYPALON (Du Pont registered trademark) coated fabrics.
-
Page 2: Table Of Contents
REMEMBER FIRE DANGER ALWAYS TECHNICAL SPECIFICATIONS COMPLETE SET BOAT DESIGN RIGID HULL REINFORCED BUOYANCY TUBE STEERING CONSOLE FUEL SYSTEM DRAIN SYSTEM WIRING DIAGRAM STORAGE BATTERY INSTALLATION INFLATION TUBE BOAT TRAILERING THE MAIN DIMENSIONS MAINTENANCE OPERATING REGULATIONS — 2 — "BRIG" inflatable boats... - Page 3 CHECK, THAT THE CHECKS HAVE BEEN MADE AND THAT THE PLANTS HAVE BEEN COMPLETED BEFORE DELYVERY. BRIG Ltd declines any responsibility for systems and accessories that have not been installed and checked by expert and authorised personnel. The manual and all its enclosures should be stored carefully, and the manual should always be kept aboard.
- Page 4 The CE marking indicates that the inflatable boat was built in compliance with the Directive 94/25/EC applied to pleasure craft Certifying Body: BUREAU VERITAS S.A. 92077 Paris La Defense Cedex Name of Manufacture: BRIG Ltd. Lozovskaya 88, Dergachy 62303 Kharkovskaya obl. UKRAINE www.brig-ribs.ua — 4 — "BRIG" inflatable boats...
-
Page 5: Danger Levels
Before using your boat, read this MANUAL carefully and ensure that you have understood all the procedures it describes. Before taking command of your boat, be sure to have acquired experience and confidence in its operation. Series "EAGLE" E340 E380 2378B.01 — 5 —... -
Page 6: Identification Plate
Without them the boat does not comply with the legislation in effect. The plates must never be removed. Any tampering or removal not authorised by the manufacturer is the full responsibility of the owner. — 6 — "BRIG" inflatable boats... -
Page 7: Safety Regulations
(ISO 6185), so always make reference to total maximum transportable weight. The max weight of the installable motors indicates the maximum overall weight applicable on the stern board, including any emergency motors. NEVER exceed the stated value. Series "EAGLE" E340 E380 2378B.01 — 7 —... -
Page 8: Beaufort Wind Scale
NOTE: The significant wave height is the mean height of the highest one-third of the waves, which approximately corresponds to the wave height estimated by an experienced observer. Some waves will be double this height. — 8 — "BRIG" inflatable boats... - Page 9 Extinguisher or any other fire-fighting equipment should be checked periodically and replaced with the same or superior types if expired or inefficient. Equip the boat with fire-fighting equipment before launch and use. Series "EAGLE" E340 E380 2378B.01 — 9 —...
- Page 10 TECNICAL SPECIFICATIONS. The basic parameters and dimensions of the boats E340 (E340H) and E380 (E3800H) comply with the data specified in the following table. All dimensions measurments indicated have a tolerance of +/- 3%, weight measurments indicated have a tolerance of +/- 5%.
-
Page 11: Complete Set 1
Note. Perfection of the design and improvement of quality of our products is the fundamental production policy of our company. Therefore, alternations may be made to the complete set (and as the components become available). Series "EAGLE" E340 E380 2378B.01... -
Page 12: Boat Design
BOAT DESIGN. — 12 — "BRIG" inflatable boats... - Page 13 2 3 — Thru-hull (engine recess drain system). 2 4 — Cockpit drain system socket (2 pcs.). 2 5 — Outlet for steering system cable. 2 6 — Bilge valve. Fig.D1 Series "EAGLE" E340 E380 2378B.01 — 1 3 —...
-
Page 14: Rigid Hull 1
RIGID HULL. Fig.D2 — 14 — "BRIG" inflatable boats... -
Page 15: Reinforced Buoyancy Tube 1
– handles (12, 20); – two stern mooring cleats (11); – bow fiberglass plastic plate (5) with semi-hawse (6) and navigation – fuel tank (33L for E340 or 43L for E380) (4); lights (7, 8); – fuel fill (12); – two fiberglass plastic ends of the tube (21) with two antiskid steps each. -
Page 16: Steering Console 1
In order to have access to the inner part of the steering console Fig.D4 when mounting steering system, remote control box, additional electrical equipment, etc. it is necessary: — 16 — "BRIG" inflatable boats... - Page 17 • switches and fuses: hull drain pump switch – navigation lights and meter lamp switch (5); – hull drain pump switch (6); masthead light switch – masthead light switch (7). Fig.D6 Series "EAGLE" E340 E380 2378B.01 — 1 7 —...
-
Page 18: Fuel System 1
FUEL SYSTEM. Fig.D7 Fuel system consists of the following components (Fig. D7): – built-in fuel tank (33L for E340 or 43L for E380) (1); – electric fuel gauge (2); – fuel line (from fuel fill to fuel tank) (3); – fuel fill (4);... - Page 19 Do not smoke when refueling. Stop the engine and switch off any electric equipments before refueling. It is dangerous to pretend to be an expert. This may cause damages. Refer to expert and authorized specialists for all types of maintenance and repair. Series "EAGLE" E340 E380 2378B.01 — 1 9 —...
-
Page 20: Drain System 2
– engine recess drain thru-hull (4). HULL DRAIN SYSTEM : – automatic bilge pump (5); – drain hose (6); – bilge pump drain thru-hull mounted in the engine recess (7). – bilge valve (8). Fig.D8 — 20 — "BRIG" inflatable boats... - Page 21 Do not dispose bulky objects in front of the cockpit drain sockets. Do not modify drain systems. Before navigation check the drain valves. Never locate heavy objects on the drain hoses. It will be cause of bucking, distortions and damages. Series "EAGLE" E340 E380 2378B.01 — 2 1 —...
-
Page 22: Wiring Diagram 2
12 — Meter lamp and navigation lights switch with 5A safety device. Do not touch the electrical equipment 13 — Hull drain pump "FORCED" / "AUTO" switch with 10A safety device. with wet hands. 14 — Masthead light switch with 5A safety device. — 22 — "BRIG" inflatable boats... -
Page 23: Storage Battery Installation 2
The rated pressure value is 0.15 bar (2.2 psi). If the tube pressure more than nominal, deflate the tube slightly. Boat exploitation with board pressure more than nominal decreases boat service life. Series "EAGLE" E340 E380 2378B.01 — 2 3 —... -
Page 24: Boat Trailering 2
E340 E380 Points of support Points of support 60...200 Basic load area 1500 (keel line) 1900 Basic load area (keel line) Support areas 1900 Support areas 1300 Points of support Points of support Fig.T1 — 24 — "BRIG" inflatable boats... -
Page 25: The Main Dimensions 2
THE MAIN DIMENSIONS. The main dimensions of E340 and E380 have tolerance of +/- 3%. All dimensions in meters. The length of the boat with the engine can vary depending on the model of the engine and the angle of its deviation. (See Fig. T2) -
Page 26: Maintenance 2
0°C, it must be kept at a temperature above +15°C at least for 1 hour before to be unpacked and unfolded. For small repair boat tube use the coated fabric and glue set from the complete set. — 26 — "BRIG" inflatable boats... -
Page 27: Operating Regulations 2
This arrangement will enable you to avoid any traumas and to reach the boat. Take all possible precautions against penetration of fuel, oil or electrolyte from the storage battery into the inflatable boat. If it does happen wash thoroughly the fouled spots with water. Series "EAGLE" E340 E380 2378B.01 — 2 7 —... - Page 28 Despite the strong shell of the boat we recommend carefully handle and operate with sharp and pricking objects which you have on board . It concerns, for example, a knife blade, fish-hook point, etc. — 28 — "BRIG" inflatable boats...
- Page 29 Reduce the speed and shift your body to the undamaged part of the boat. Observe changes in stability. After that, immediately head for the nearest shore. To prevent penetration of water into the boat, pull the shell of the damaged air chambers upwards. Series "EAGLE" E340 E380 2378B.01...
- Page 30 Reduce speed before sharp turn, in either direction. When the boat is fitted with an engine with maximum recommended power it must be use with extreme care. This application is directed at experienced users using their boats for very specific purposes. — 30 — "BRIG" inflatable boats...
- Page 31 Observe right-of-way as defined by Rules of the Road and required by COLREG. Always be certain to have sufficient distance to stop or manoeuvre if required to avoid collisions. Series "EAGLE" E340 E380 2378B.01 — 3 1 —...
- Page 32 E340 E380 MODEL SERIAL No. UA-QRK Date of manufacture Quality inspection stamp NOTE: The inflatable boat was delivered with the following equipment installed: Stamp and signature 1.Fuel tank 5.Steering system Stamp and signature 2.Electric system 6.Engine power system...