POLYESTER STEERING CONSOLE FUEL SYSTEM DRAIN SYSTEM Care & Maintenance of your Sunbrella® Fabric WIRING DIAGRAM PREPARATION FOR EXPLOITATION INFLATION/DEFLATION BOAT TUBE STORAGE BATTERY INSTALLATION BOAT TRANSPORTATION BY TRAILER HOW TO INSTALL SUNDECK MAINTENANCE OPERATING REGULATIONS — 2 — "BRIG" inflatable boats...
Page 3
CHECK, THAT THE CHECKS HAVE BEEN MADE AND THAT THE PLANTS HAVE BEEN COMPLETED BEFORE DELYVERY. BRIG Ltd declines any responsibility for systems and accessories that have not been installed and checked by expert and authorised personnel. The manual and all its enclosures should be stored carefully, and the manual should always be kept aboard.
Page 4
94/25/EC as amended by Directive 2003/44/EC applied to pleasure craft Certifying Body: BUREAU VERITAS S.A. 92077 Paris La Defense Cedex Name of Manufacture: BRIG Ltd. Lozovskaya 88, Dergachy 62303 Kharkovskaya obl. UKRAINE www.brig.ua, www.brig-ribs.com — 4 — "BRIG" inflatable boats...
Before using your boat, read this MANUAL carefully and ensure that you have understood all the procedures it describes. Before taking command of your boat, be sure to have acquired experience and confidence in its operation. — 5 — Series "NAVIGATOR" N520 N570 N610 2384C.01...
Without them the boat does not comply with the legislation in effect. The plates must never be removed. Any tampering or removal not authorised by the manufacturer is the full responsibility of the owner. — 6 — "BRIG" inflatable boats...
(ISO 6185), so always make reference to total maximum transportable weight. The max weight of the installable motors indicates the maximum overall weight applicable on the stern board, including any emergency motors. NEVER exceed the stated value. — 7 — Series "NAVIGATOR" N520 N570 N610 2384C.01...
NOTE: The significant wave height is the mean height of the highest one-third of the waves, which approximately corresponds to the wave height estimated by an experienced observer. Some waves will be double this height. — 8 — "BRIG" inflatable boats...
Extinguisher or any other fire-fighting equipment should be checked periodically and replaced with the same or superior types if expired or inefficient. Equip the boat with fire-fighting equipment before launch and use. — 9 — Series "NAVIGATOR" N520 N570 N610 2384C.01...
The basic parameters and dimensions of the "NAVIGATOR" boats comply with the data specified in the following table. All dimensions measurements indicated have a tolerance of +/- 3%, weight measurements indicated have a tolerance of +/- 5%. Parameter N520 (N520H) N570 (N570H) N610 (N610H) Length (without engine) 5.2 m...
THE MAIN DIMENSIONS. The main dimensions of N520, N570, N610 have tolerance of +/- 3%. The length of the boat with the engine(L1) can vary depending on the model of the engine and the angle of its deviation. (See Fig. D0)
— outer neck for fuel fill (13); — inspection hatches (12); — two stern cleats (17); The fore part of the cockpit may be simply converted into the sundeck by means of false decks and soft cushions. — 16 — "BRIG" inflatable boats...
Also there are the following elements fitted on the tube (Fig. D1): — doubled rubbing strake (3, Fig.D1); — safety handles (4, Fig.D1); — bow step-plate with a special moulded antiskid coating (6, Fig.D1). — 17 — Series "NAVIGATOR" N520 N570 N610 2384C.01...
— console upper part (2); — windscreen (3); — stainless steel railing (4); — front soft seat (5) (not applicable for N520) — console recess (7); — special place for installation of analog or/and digital devices, such as speedometer, tachometer, trim-meter, fuel-level meter, multipurpose meters, GPSmap, etc.
Page 19
Always check the fuse. Burning red LED display on the fuse box warns of H ORN faulty fuse Always keep a spare set the fuse in an easily-accessible location. — 19 — Series "NAVIGATOR" N520 N570 N610 2384C.01...
Do not smoke when refueling. Stop the engine and switch off any electric equipments before refueling. It is dangerous to pretend to be an expert. This may cause damages. Refer to expert and authorized specialists for all types of maintenance and repair. — 20 — "BRIG" inflatable boats...
Do not dispose bulky objects in front of the cockpit drain sockets. Do not modify drain systems. Before navigation check the drain valves. Never locate heavy objects on the drain hoses. It will be cause of bucking, distortions and damages. — 21 — Series "NAVIGATOR" N520 N570 N610 2384C.01...
Page 22
Never locate heavy objects on the d r a i n h o s e s . I t w i l l b e c a u s e o f bucking, distortions and damages. — 22 — "BRIG" inflatable boats...
Care & Maintenance of your Sunbrella® Fabric If soft seats and cushions of your BRIG boat are made from Protection Sunbrella® fabric, please read this instruction for the proper 303 High Tech Fabric Guard restores your fabric’s original care of fabric.
The rated pressure value is 0.15 bar (2.2 psi). If the tube pressure more than nominal, deflate the tube slightly. Boat exploitation with board pressure more than nominal decreases boat service life. — 25 — Series "NAVIGATOR" N520 N570 N610 2384C.01...
It is possible to install the boat on several reference points. Thereby the point of support (1) must be an obligatory, and the point of support (2), (3), (4) must be an additional. Lateral roller supports can be used only with a view of prevention from tipping. — 26 — "BRIG" inflatable boats...
Page 27
I n o r d e r t o a v o i d t h e h u l l N520 – 775 kg damage, install the boat on the N570 – 830 kg stated areas only. N610 – 970 kg — 27 — Series "NAVIGATOR" N520 N570 N610 2384C.01...
HOW TO INSTALL SUNDECK (not applicable for N520) Sundeck set includes two false deck boards and two soft cushions. One of the boards (the small one) may be used as an upper part of the demountable table. In order to install the sundeck (Fig. A1), please do the next: —...
0°C, it must be kept at a temperature above +15°C at least for 1 hour before to be unpacked and unfolded. For small repair boat tube use the coated fabric and glue set from the complete set. — 29 — Series "NAVIGATOR" N520 N570 N610 2384C.01...
This arrangement will enable you to avoid any traumas and to reach the boat. Take all possible precautions against penetration of fuel, oil or electrolyte from the storage battery into the inflatable boat. If it does happen wash thoroughly the fouled spots with water. — 30 — "BRIG" inflatable boats...
Page 31
Despite the strong shell of the boat we recommend carefully handle and operate with sharp and pricking objects which you have on board . It concerns, for example, a knife blade, fish-hook point, etc. — 31 — Series "NAVIGATOR" N520 N570 N610 2384C.01...
Page 32
Reduce the speed and shift your body to the undamaged part of the boat. Observe changes in stability. After that, immediately head for the nearest shore. To prevent penetration of water into the boat, pull the shell of the damaged air chambers upwards. — 32 — "BRIG" inflatable boats...
Page 33
When the boat is fitted with an engine with maximum recommended power it must be use with extreme care. This application is directed at experienced users using their boats for very specific purposes. — 33 — Series "NAVIGATOR" N520 N570 N610 2384C.01...
Page 34
Observe right-of-way as defined by Rules of the Road and required by COLREG. Always be certain to have sufficient distance to stop or manoeuvre if required to avoid collisions. — 34 — "BRIG" inflatable boats...
Page 36
N520 N570 N610 MODEL SERIAL No. UA-QRK Date of manufacture Quality inspection stamp NOTE: The inflatable boat was delivered with the following equipment installed: Stamp and signature 1.Fuel tank...