Related Manuals for Advantech UTC-510
Summary of Contents for Advantech UTC-510
- Page 1 User Manual UTC-510/515/520/532/542 10.1”/15.6”/21.5”/32”/42.5” Ubiquitous Touch Computer...
- Page 2 The documentation and the software included with this product are copyrighted 2017 by Advantech Co., Ltd. All rights are reserved. Advantech Co., Ltd. reserves the right to improve the products described in this manual at any time without notice. No part of this manual may be reproduced, copied, translated, or transmitted in any form or by any means without the prior written permission of Advantech Co., Ltd.
-
Page 3: Declaration Of Conformity
– DC 12V/3A 36W adaptor (UTC-510) – DC 12V/7A 84W adaptor (UTC-520 C/D/E SKU) – SATA cable (not applicable for UTC-510) – Packet of screws (not applicable for UTC-510) Accessories for UTC-532 – SATA cable – Packet of screws –... -
Page 4: Technical Support And Assistance
Technical Support and Assistance Visit the Advantech website at http://support.advantech.com to obtain the latest product information. Contact your distributor, sales representative, or Advantech's customer service center for technical support if you need additional assistance. Please have the following information ready before calling: –... -
Page 5: Safety Instructions
The sound pressure level at the operator position does not exceed 70 dB (A) in accordance with the IEC 704-1:1982. DISCLAIMER: These instructions are provided according to IEC 704-1 standards. Advantech disclaims all responsibility for the accuracy of any statements contained herein. UTC-510/515/520/532/542 User Manual... - Page 6 The computer is equipped with a battery-powered real-time clock circuit. There is a danger of explosion if the battery is incorrectly replaced. Replace only with same or equivalent type recommended by the manufacturer. Discard used batteries according to the manufac- turer’s instructions. UTC-510/515/520/532/542 User Manual...
-
Page 7: Table Of Contents
UTC-510/510(PoE) ..............37 3.6.2 UTC-515/520/532 ............... 38 Panel Mount Installation for UTC-510 ............. 38 Installing a DRAM Module for UTC-510..........39 3.8.1 UTC-510 ..................39 3.8.2 UTC-510(PoE) ................39 Installing an SSD Module for UTC-510 ........... 40 UTC-510/515/520/532/542 User Manual... - Page 8 3.9.1 UTC-510 ..................40 3.9.2 UTC-510(PoE) ................40 3.10 Installing an mSATA SSD Module for UTC-510 ........41 3.10.1 UTC-510 ..................41 3.10.2 UTC-510(PoE) ................41 3.11 Installing a Wi-Fi Module for UTC-510............ 42 3.11.1 UTC-510 ..................42 3.11.2 UTC-510(PoE) ................42...
-
Page 9: Chapter 1 General Information
Chapter General Information... -
Page 10: Introduction
1.1 Introduction Advantech’s UTC-500 series products are 10.1”, 15.6”, 21.5”, 32”, and 42.5” fanless, low-power, all-in-one touch panel computers suitable for use as control room comput- ing devices, production line industrial digital signage, showroom interactive signage, self-service kiosks, and public service terminals, as well as to support diverse digital retail, hospitality, healthcare, education, entertainment, and information processing applications. -
Page 11: Specifications
Typical 10W Consumption Max. 20W Size/Type 10.1" TFT LCD with LED backlight Max. Resolution 1280 x 800 Max. Color 16.7M Pixel Pitch 169.5 x 169.5 um LCD Panel Brightness 350 cd/m Viewing Angle 170°/170° Camera 5 Megapixels (optional) UTC-510/515/520/532/542 User Manual... - Page 12 Type Glass panel with projected capacitive touch Light Touchscreen 80% ± 5% / 90% Transmission (PE/GE) Controller USB interface UTC-510/515/520/532/542 User Manual...
-
Page 13: Utc-510(Poe)
Typical 10W Consumption Max. 20W Size/Type 10.1" TFT LCD with LED backlight Max. Resolution 1280 x 800 Max. Color 16.7M Pixel Pitch 169.5 x 169.5 um LCD Panel Brightness 350 cd/m Viewing Angle 170°/170° Camera 5 Megapixels (optional) UTC-510/515/520/532/542 User Manual... - Page 14 Type Glass panel with projected capacitive touch Light Touchscreen 80% ± 5% / 90% Transmission (PE/GE) Controller USB interface UTC-510/515/520/532/542 User Manual...
-
Page 15: Utc-515 A/B/C
0 ~ 40 °C (32 ~ 104 °F) Temperature Relative 10 ~ 95% @ 40 °C non-condensing Humidity Vibration 0.5 Grms Environmental 5G peak acceleration (11 msec. dura- Shock tion) EMC/Safety CE, FCC, CB, UL, CCC, BSMI Front Panel IP65/NEMA4 compliant Protection UTC-510/515/520/532/542 User Manual... - Page 16 Pixel Pitch 252 x 252 um Brightness 400 cd/m View Angle 170°/160° Glass panel with projected capacitive/5-wire analog resistive Type touch Touchscreen Light (PE/RE/GE) 90% ± 2% / 80% ± 5% / 90% Transmission Controller USB interface UTC-510/515/520/532/542 User Manual...
-
Page 17: Utc-515D/E/F
Protection Input 12 V/5 A (60W ITE 12 V/5 A (60W ITE 12 V/5 A (60W ITE Rating adapter) adapter) adapter) Power Supply Power Typical 35W Typical 40W Typical 35W Consumption Max. 40W Max. 50W Max. 40W UTC-510/515/520/532/542 User Manual... - Page 18 Pixel Pitch 252 x 252 um Brightness 400 cd/m Viewing Angle 170°/160° Glass panel with projected capacitive/5-wire analog resistive Type touch Touchscreen Light Trans- (PE/RE/GE) 90% ± 2% / 80% ± 5% / 90% mission Controller USB interface UTC-510/515/520/532/542 User Manual...
-
Page 19: Utc-520A/B/C
0 ~ 40 °C (32 ~ 104 °F) Temperature Relative 10 ~ 95% @ 40 °C non-condensing Humidity Vibration 0.5 Grms Environmental Shock 5 G peak acceleration (11 msec. duration) CE, FCC, UL, CB, CCC, BSMI Front Panel IP65/NEMA4 compliant Protection UTC-510/515/520/532/542 User Manual... - Page 20 248.25 (H) x 248.25 (V) (mm) Brightness 250 cd/m2 (400 cd/m2 optional) Viewing 178°/178° Angle Glass panel with projected capacitive/5-wire analog Type resistive touch Touchscreen (PE/ Light RE/GE) 90% ± 2% / 80%± 5% / 90% Transmission Controller USB interface UTC-510/515/520/532/542 User Manual...
-
Page 21: Utc-520D/E/F
517.64 x 313.51 x 43.50 mm (W x H x D) Weight 8 kg (17.6 lb) Windows Embed- ded 7/8, Windows Windows Embed- 10 IoT Enterprise, OS Support ded 7/8, Windows Linux Ubuntu 10 IoT Enterprise 14.04, Android 4.4.2 UTC-510/515/520/532/542 User Manual... - Page 22 (H x V) Brightness 250 cd/m2 (400 cd/m2 optional) Viewing 178°/178° Angle Glass panel with projected capacitive/5- Type wire analog resistive touch Touchscreen Light (PE/RE/GE) 90% ± 2% / 80% ± 5% / 90% Transmission Controller USB interface UTC-510/515/520/532/542 User Manual...
-
Page 23: Utc-532A/C
Pixel Pitch (H x 0.36375 x 0.36375 mm Brightness 300 cd/m2 Viewing Angle 178°/178° Glass panel with projected capacitive touch (No touch Type function optional) Touchscreen Light (PE/GE) 90% ± 2% / 90% Transmission Controller USB interface UTC-510/515/520/532/542 User Manual... -
Page 24: Utc-532D/E/F
0 ~ 40 °C (32 ~ 104 °F) Temperature Relative 10 ~ 95% @ 40 °C non-condensing Humidity Environmental Vibration 0.5 Grms Shock 5 G peak acceleration (11 msec. duration) CE, FCC, UL, CB, CCC, BSMI Front Panel IP65/NEMA4 compliant Protection UTC-510/515/520/532/542 User Manual... - Page 25 Pixel Pitch 0.36375 x 0.36375 mm (H x W) Brightness 300 cd/m2 Viewing 178°/178° Angle Glass panel with projected capacitive Type touch (No touch function optional) Touchscreen Light (PE/GE) 90% ± 2% / 90% Transmission Controller USB interface UTC-510/515/520/532/542 User Manual...
-
Page 26: Utc-542
Input Rating 100 ~ 240V 50/60Hz 2.5A Power Power Consumption Size/Type 42.5" TFT LCD with LED backlight Max. 1920 x 1080 Resolution Pixel Pitch LCD Panel 0.49 x 0.49 mm (H x W) Brightness 450 cd/m2 Viewing 178°/178° Angle UTC-510/515/520/532/542 User Manual... - Page 27 Type Glass panel with projected capacitive touch Light >90% (pure glass); >25% (mirror coating) Transmission Touchscreen (PE/GE) Surface Anti-glare 3H mirror coating (optional) Treatment Controller USB interface UTC-510/515/520/532/542 User Manual...
-
Page 28: Dimensions
VESA Screw hole VESA Screw hole M4x6mm Depth M4x6mm Depth Unit: mm 252.0 252.0 40.1 40.1 265.4 260.4 27.3 Cut out 75.0 75.0 75x75 VESA M4 screw hole 75x75 VESA M4 screw hole 7mm depth 7mm depth UTC-510/515/520/532/542 User Manual... -
Page 29: Utc-515
1.3.2 UTC-515 Dimensions: 390 x 240 x 45 mm VESA Hole 139.91 M4 depth=5mm 389.81 VESA Mounting: 100 x 100 mm VESA Hole 139.91 M4 depth=5mm UTC-510/515/520/532/542 User Manual... -
Page 30: Utc-520
1.3.3 UTC-520 Unit: mm 308.82 208.82 517.64 132.17 VESA Hole M4 Depth=5mm 43.50 517.64 UTC-510/515/520/532/542 User Manual... -
Page 31: Utc-532
1.3.4 UTC-532 Dimensions: 786 x 480 x 63 mm 292.82 VESA Hole M6 depth=10mm 785.64 62.50 VESA Mounting: 200 x 200 mm 292.82 VESA Hole M6 depth=10mm UTC-510/515/520/532/542 User Manual... -
Page 32: Utc-542
1.3.5 UTC-542 Unit: mm Mirror Pcap 60.50 1016.86 60.20 990.58 34.30 898.22 59.33 898.22 46.19 508.43 495.29 100 100 UTC-510/515/520/532/542 User Manual... -
Page 33: Chapter 2 System Setup
Chapter System Setup... -
Page 34: Quick Start Tour
LCD panel with touchscreen control (PE/RE/GE) Note! The UTC-515 and UTC-520 PE models feature an anti-microbial Corn- ing® Gorilla® Glass panel with capacitive touch control. See Appendix C for additional details. Resistive touch control is not available for the UTC-510/532/542 series. UTC-510/515/520/532/542 User Manual... -
Page 35: Rear View
Refer to Section 2.2 regarding system I/O according to UTC model. 2.1.3 Side View Side Grooves Note! The UTC-500 series (excluding the UTC-510/542 models) features unique side grooves for easy peripheral integration using two screws. Refer to Section 3.6 for installation information. UTC-510/515/520/532/542 User Manual... -
Page 36: I/O Ports
E. USB 3.0 (DC version only) K. Power switch F. HDMI With the standard UTC-510 PoE model, users are recommended to avoid using the USB 2.0 (A) and USB 3.0 (E) ports. To change the configuration, the total power input must be under 25.5W. -
Page 37: Utc-515
J. 2 x LAN D. COM3 (UTC-520A/B only) K. CFast (UTC-520A/B only) E. COM2 L. DC input F. COM1 M. Power switch G. 4 x USB 2.0 (1 x USB 3.0 for UTC-520D; 2 x USB 3.0 for UTC-520C/E) UTC-510/515/520/532/542 User Manual... -
Page 38: Utc-532
H. 1 x USB 3.0, 3 x USB 2.0 (UTC-542D) C. 2 x COM USB 3.0 x 2, USB 2.0 x 2 (UTC-542F) D. Mic-In/Line-Out I. AC power E. 2 x LAN J. Antenna connector F. VGA UTC-510/515/520/532/542 User Manual... -
Page 39: Setup Procedures
2.3 Setup Procedures 2.3.1 System Power On For the UTC-510 model, connect the system to a power adaptor with 12V/3A input voltage. For the UTC-515 and UTC-520A/B/C/D/E models, a 12V/5A power adaptor. For the UTC-520C/E models, a 12V/7A power adaptor. For the UTC-532/542 models, connect the system to an AC power cable. - Page 40 UTC-510/515/520/532/542 User Manual...
-
Page 41: Chapter 3 Upgrades And Installation
Chapter Upgrades and Installation... -
Page 42: Introduction
3.1 Introduction Advantech’s UTC series systems are PC-based computers housed in an aluminum enclosure. To perform system maintenance or hardware upgrades, such as installing an HDD, DRAM, or CompactFlash (A/B models only), simply remove the unit’s rear cover. Warning! Do not remove the rear cover until you have verified that power is not flowing within the device. -
Page 43: Installing A Cfast Card (A/B Models Only)
Loosen the affixing screws and remove the rear cover. Remove the 4 screws from the DRAM memory module heatsink. Turn the memory module over and remove the 2 screws on the underside. Install the DRAM module into the SODIMM socket. UTC-510/515/520/532/542 User Manual... -
Page 44: Installing A Wireless Lan Card (Optional)
If the motherboard is removed from the chassis and the cables detached and reattached, Pin 1 of the header can be located by aligning the red side of the ribbon cable to the edge indicated by a small triangle marking on the PCB. UTC-510/515/520/532/542 User Manual... -
Page 45: Installing Peripherals (Optional)
Installing Optional Modules Attach the peripheral module to the bottom of the UTC system. Affix the module in place using the screws removed from the frame. Connect a cable to the peripheral module and to an I/O port (USB). UTC-510/515/520/532/542 User Manual... -
Page 46: Utc-515/520/532
Connect a cable to the peripheral module and to an I/O port (USB). Place the cable clamp in a secure location and attach the cable to it for simple cable routing. 3.7 Panel Mount Installation for UTC-510 UTC-510/515/520/532/542 User Manual... -
Page 47: Installing A Dram Module For Utc-510
3.8 Installing a DRAM Module for UTC-510 3.8.1 UTC-510 3.8.2 UTC-510(PoE) DRAM UTC-510/515/520/532/542 User Manual... -
Page 48: Installing An Ssd Module For Utc-510
3.9 Installing an SSD Module for UTC-510 3.9.1 UTC-510 3.9.2 UTC-510(PoE) UTC-510/515/520/532/542 User Manual... -
Page 49: Installing An Msata Ssd Module For Utc-510
3.10 Installing an mSATA SSD Module for UTC-510 3.10.1 UTC-510 3.10.2 UTC-510(PoE) MSATA SSD UTC-510/515/520/532/542 User Manual... -
Page 50: Installing A Wi-Fi Module For Utc-510
3.11 Installing a Wi-Fi Module for UTC-510 3.11.1 UTC-510 3.11.2 UTC-510(PoE) UTC-510/515/520/532/542 User Manual... -
Page 51: Appendix A Installation Accessories
Appendix Installation Accessories... -
Page 52: Introduction
A.1 Introduction The floor stand and wall mount accessories provided for Advantech’s UTC series systems combine simplicity with style, making them easy to install without additional costs or space requirements. Additionally, because the UTC series are aimed at sup- porting applications in diverse usage scenarios, such as self-service kiosks in hospi- tality reception areas, the units are slim and compact, and feature an attractive elegant appearance that ensures integration in a variety of environments. -
Page 53: Wall Mount
2 3 0 1 0 0 1 0 0 2 2 0 Flush fit without movement Sits: 42.5 mm from a wall Weight capacity: Up to 35 kg For UTC-532 only Material: Steel UTC-510/515/520/532/542 User Manual... - Page 54 UTC-WALL-MOUNT3E VESA 75/100 mm Can be firmly fixed to a solid wall Sits: 27 mm from the wall Weight capacity: Up to 20 kg For UTC-515/520 Material: Steel UTC-510/515/520/532/542 User Manual...
-
Page 55: Floor Stand
10 kg UTC-T01-STANDE Triangular floor stand Ø660 100 75 144° 1200 Organized cable management VESA 75/100 mm Height: 120 cm Easy tilt for optimum viewing comfort Dimensions: Ø660 mm Weight: 10 kg UTC-510/515/520/532/542 User Manual... - Page 56 MAX: 1000 x 300 x 10 (Signboard) Organized cable management VESA 75/100 mm Height: 120 cm Easy tilt for optimum viewing comfort Dimensions: Ø660 mm Weight: 10 kg Acrylic signboard not included UTC-510/515/520/532/542 User Manual...
-
Page 57: Appendix Butc Peripherals
Appendix UTC Peripherals... -
Page 58: Utc-P01 (Camera Module)
Dimensions 130 x 35 x 40 mm Operating Temperature 0 ~ 40 °C B.1.2 Packing List Description Quantity Cable Clamp Camera Module Unit B.1.3 Ordering Information Part Number Description UTC-P01-A1E 5 Megapixel camera module for UTC-500 series UTC-510/515/520/532/542 User Manual... -
Page 59: Utc-P02 (Msr)
Dimensions 130 x 35 x 40 mm Operating 0 ~ 40 °C Temperature B.2.2 Packing List Description Quantity Cable Clamp Magnetic Strip Reader Unit B.2.3 Ordering Information Part Number Description UTC-P02-A0E Magnetic strip reader for UTC-500 series UTC-510/515/520/532/542 User Manual... -
Page 60: Utc-P03 (Rfid Reader)
ISO 14443A Japanese railways (Suica/Edy card) Reading Range 3cm ± 1cm OS Support Windows XP/7 Dimensions 130 x 35 x 40 mm Operating 0 ~ 40 °C Temperature B.3.2 Packing List Description Quantity Cable Clamp RFID Reader Unit UTC-510/515/520/532/542 User Manual... -
Page 61: Ordering Information
B.3.3 Ordering Information Part Number Description UTC-P03-A0E RFID reader for UTC-500 series UTC-510/515/520/532/542 User Manual... -
Page 62: Utc-P06 (Smart Card Reader)
130 x 35 x 40 mm Operating Temperature 0 ~ 40 °C B.4.2 Packing List Description Quantity Cable Clamp Smart Card Reader Unit 1 B.4.3 Ordering Information Part Number Description UTC-P06-A0E Smart card reader for UTC-500 series UTC-510/515/520/532/542 User Manual... -
Page 63: Utc-P07 (Barcode Reader)
Stacked Codes: EAN/JAN Composites, GS1 DataBar Composites, GS1 DataBar Expanded Stacked, GS1 DataBar Stacked, GS1 DataBar Stacked Omnidirectional, MacroPDF, MicroPDF417, PDF417, UPC A/E Composites OS Support Windows 7/8 Dimensions 130 x 52 x 40 mm Operating 0 ~ 40 °C Temperature UTC-510/515/520/532/542 User Manual... -
Page 64: Packing List
B.5.2 Packing List Description Quantity Cable Clamp Barcode Reader Unit 1 B.5.3 Ordering Information Part Number Description UTC-P07-A1E 2D barcode module for UTC-500 series UTC-510/515/520/532/542 User Manual... -
Page 65: Utc-P21 (4-In-1 Module)
Windows XP/7 Dimensions 300 x 35 x 40 mm Operating 0 ~ 40 °C Temperature B.6.2 Packing List Description Quantity Cable Clamp 4-in-1 Module Unit B.6.3 Ordering Information Part Number Description UTC-P21-A0E 4-in-1 module for UTC-500 series UTC-510/515/520/532/542 User Manual... -
Page 66: Utc-510P-R01E
Reading Range 2 cm ± 1 cm OS Support Windows XP/7/8/Windows 10 IoT Enterprise, Android, Linux Dimensions 90 x 35 x 38 mm Operating 0 ~ 40 °C Temperature B.7.1 Packing List Description Quantity RFID Reader Unit UTC-510/515/520/532/542 User Manual... -
Page 67: Ordering Information
B.7.2 Ordering Information Part Number Description UTC-510P-R01E RFID reader for UTC-510 series (USB connection) UTC-510/515/520/532/542 User Manual... -
Page 68: Utc-510P-S01E
94 x 38 x 22 mm Operating 0 ~ 40 °C Temperature B.8.1 Packing List Description Quantity Smart Card Reader Unit 1 B.8.2 Ordering Information Part Number Description UTC-510P-S01 Smart card reader for UTC-510 series (USB connection) UTC-510/515/520/532/542 User Manual... -
Page 69: Utc-510P-B
GS1 DataBar (formerly RSS) Linear, Industrial 2 of 5, Standard 2 of 5, Stacked Linear Plessey, MSI-Plessey, etc. OS Support Windows 7/8, Windows 10 IoT Enterprise Dimensions 80 x 35 x 38 mm Operating 0 ~ 40 °C Temperature UTC-510/515/520/532/542 User Manual... -
Page 70: Packing List
B.9.1 Packing List Description Quantity Barcode Reader Unit B.9.2 Ordering Information Part Number Description UTC-510P-B01E 1D barcode scanner for UTC-510 series (USB connection) UTC-510P-B02E 1D/2D barcode scanner for UTC-510 series (USB connection) UTC-510/515/520/532/542 User Manual... -
Page 71: Utc-510P-M01E
Android, Windows 7/XP, Windows 10 IoT Enterprise Dimensions 94 x 38 x 22 Operating 0 ~ 40 °C Temperature B.10.1Packing List Description Quantity Magnetic Strip Reader Unit B.10.2Ordering Information Part Number Description UTC-510P-M01E Magnet strip reader for UTC-510 series (USB connection) UTC-510/515/520/532/542 User Manual... - Page 72 UTC-510/515/520/532/542 User Manual...
-
Page 73: Appendix C Touchscreen Options
Appendix Touchscreen Options... -
Page 74: Touchscreen Options
530g iron ball dropped Impact Test from 50 cm - Pass from 130 cm - Pass from 130 cm - Pass Touch Point Single touch Multi-touch Multi-touch Anti-Microbial Visible Light 80 ±5% 90 ± 2% 90 ± 2% Transmission UTC-510/515/520/532/542 User Manual... - Page 75 UTC-510/515/520/532/542 User Manual...
- Page 76 No part of this publication may be reproduced in any form or by any means, such as electronically, by photocopying, recording, or otherwise, without prior written permission from the publisher. All brand and product names are trademarks or registered trademarks of their respective companies. © Advantech Co., Ltd. 2017...
Need help?
Do you have a question about the UTC-510 and is the answer not in the manual?
Questions and answers